Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||||
| 13853 | 03/01/2001 | 620276 | Some vehicles equipped with a 4.0l ohv engine may exhibit clogged / plugged fuel injectors. *tt | 07/23/2001 | |
| 13853 | 02/01/2000 | 612449 | 4.0l ohv engine equipped vehicles may exhibit clogged / plugged fuel injectors. *tt | 06/08/2000 | |
| 8097 | 02/01/2000 | 612298 | Some vehicles equipped with a 4.0l ohv engine may exhibit clogged / plugged fuel injectors. *tt | 06/07/2000 | |
| FUEL SYSTEM, OTHER | |||||
| 0398 | 05/12/2003 | 10002780 | Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt | 09/17/2003 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, GASOLINE | |||
| 11/14/2012 | 68008 | ||
| While driving i heard a clunking noise in the rear of the vehicle i looked to see the frame had rusted through in at least two places, the shock absorber upper mount had rusted off. the gas tank straps mounts were about to fail. i had replaced the gas tank feeder tube that had corroded off the year before. the truck body is still in very good condition but the frame appears to be gone. the truck has seen very light duty and has never been used off road. since that time i have found many of the same occurrences on the internet. | |||
| 08/09/2011 | 138000 | ||
| Tl- the contact owns a 2000 ford ranger. while at the an independent mechanic for routine maintenance the mechanic noticed one of the fuel tank straps was fractured due to corrosion and the other was cracked. the fuel tank had partially detached from the vehicle causing the the filler neck of the fuel tank to crack. the mechanic stated the fuel tank straps needed to be replaced. the dealer was made aware of the failure and stated the straps for repair was not available. the vehicle was not repaired. the approximate failure mileage was 138,000. ds | |||
| 04/12/2011 | 133000 | ||
| Hanger for fuel tank rusted away same as the full size ford truck just announced in the recall. currently held up by a nylon strap while searching for parts. | |||
| 12/03/2009 | 82000 | ||
| I have a 2000 ford ranger,the sending unit on the fuel line is made of plastic,this is the most dangerous part of the vehicle.it should be stainless steel or brass,i cant drive the truck because not only is my life in danger but also cars around me,this is not a drip it gushes out.they say to cut cost but they raise the price thousands of dollars each year.please dont say its just my vehicle,i called junk yards in maryland,virginia,deleware and pennsylvania,they cant be found.how in gods name can you approve this 50 cent fitting.i can only guess someone was paid off by ford to get this passed.shame on you,you are paid to protect the people of this country,instead you get rich and we die,i wont stop,im going to the press,and any one who will listen.i hope you or your family drive one of these vehicles,and i hope it explodes right in front of you and you can watch your family burn alive.shame on you.your supposed to look for these problems,if its not a problem why cant any be found in junk yards.i did nothing,just started to smell gas.im on disability,i have to pay for this ranger every month while it sits.anf ford,this little plastic piece with about a 12 inch tube comming off it.ford wants 200.00 for plastic and our government bails these bastards out.i hope alkida targets ford next,i will root for them,all management and people who make these decisions including you and your corrupt organisation.i hope they get you all. | |||
| 01/01/1901 | 27000 | 1 | |
| Problems with gauge reading on 2000 ford ranger.*mr when the consumer started the vehicle in the morning the gauge would read 20% above full. after driving less than 10 miles the gauge dropped to the true reading 1/4 of a tank. the float in the tank seem to stick causing this problem. *nm | |||
| 11/08/2000 | 1 | 11/04/2000 | |
| Vehicle is burning fuel too fast. vehicle only gets 12 gallons in city when it should be 15 miles per gallon. *ak consumer states that nothing can be done about the poor fuel mileage. this vehicle came equipped with the firestone tires which were replaced under the recall. the spare tire however was not. the spare is a 15 inch tire. it wasn't replaced because it wasn't covered under the recall. *jg | |||
| 08/27/2000 | |||
| Consumer was traveling about 15mph one street and she was making a turn, and she was smelling gas odor for a week. gasoline started pouring out onto the ground. vehicle was towed to the dealership. currently, vehicle has stalling problems. *ak | |||
| FUEL SYSTEM, GASOLINE - CARBURETOR SYSTEM | |||
| 11/14/2000 | 2 | 11/14/2000 | |
| The left and right turn signals do not work, but when making a sharp turn like a u turn the signal comes on, the dealer was contacted about the problem but was unable to find the problem. nlm both left and right signals fail when making a slight turn to left or right. the driver window chatters when lowering windows. the dealer cleaned the window guide. right front seat would not latch. the dealer tightened bolts on seat. there was a squeak in suspension when stopping. the dealer could not duplicate the problem, but lubed suspension. there was a squeak sound from rear wheel when the vehicle was cold. also the vehicle pulls to the right on the highway. *yh | |||
| FUEL SYSTEM, GASOLINE - DELIVERY | |||
| 07/15/2002 | 1 | 07/01/2002 | |
| The fuel line came loose at the fuel filter allowing the gas to be pumped out under the truck. although their was no fire it was a very dangerous situation as the fuel tank was empitied, with the fuel being sprayed all over the underneath of the truck, including the exhaust system. i fell this is an extreme safety hazard and should be a recall situation befor someone is seriously injured or dies from this defect.*ak | |||
| 04/05/2002 | 1 | 01/01/2000 | |
| Truck was parked in airport parking lot. when picked up and engine turned on, fuel spewed out from an apparent failure in the connection of fuel line. no injuries resulted; clamp on line has either been broken/disconnected/failed. repairs have been completed. incident had no immediate adverse consequences, but significant potential disaster. dealer offered no explanation for failure except these things happen.*ak | |||
| 03/17/2001 | 1 | 02/01/2001 | |
| At 30 mph vehicle began to shake and check engine light came on. we stopped and call for a tow truck. when we looked under the truck we saw gasoline pouring from the area around the gas tank and onto the exhaust system. | |||
| 09/01/2000 | |||
| While coming to stop, downshifting or making a turn, vehicle stalled unexpectedly which may have caused a crash. dealer could not determine the cause. fuel line broke, causing a fuel leakage which may have caused a fire if there was a source of ignition. please provide further information. *ak | |||
| 02/21/2000 | 02/21/2000 | ||
| While driving about 65 mph, driver noticed a rapid decrease in the fuel gauge. owner pulled truck over and a large puddle of fuel formed on the ground immediately. after crawling under the truck, owner and fireman were able to see the that fuel line fitting came apart because the retaining ring was defective. truck was towed to the dealership. the problem has been corrected. *ak | |||
| FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
| 02/27/2010 | 68315 | ||
| Tl*the contact owns a 2000 ford ranger. while traveling at 30 mph the vehicle suddenlly shut off followed by all of the warning lights appearing on the dashboard.the vehicle was towed to a local mechanic shop where the contact had the fuel pump switch replaced. the vehicle had not been diagnosed by the dealership at the time of the complaint. the current and failure mileages were 68315. | |||
| FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
| 08/04/1999 | 65000 | 1 | 06/01/2000 |
| My son was driving his ford ranger p.u. on the freeway in san diego and noticed his fuel gauge dropped very fast. he re-fueled at service station and upon returning to freeway, two passing cars flagged him over to the side of the freeway and told him gas was spraying out from under his truck. apparently the fuel filter had come loose from the fuel line and could have had catastophic results if it had ignited. i have read similarcomplaints on this web site and can't imagine why something has not been done about this problem. i had to pay the cost to repair his truck along with a rental car,tow truck and loss of nearly two tanks of gas, even though i have an extended warranty. ford should be made responsible to make restitution in such cases, as this appears to be a manufacturer defect. this is a very unusual event to have happen on a motor vehical and should be looked into. | |||
| 07/22/2001 | 04/01/2000 | ||
| We were on the kansas turnpike heading home to dallas, the truck when we entered the turnpike had 2/3 of a tank of gas by the time i glanced down again it was at empty this occurred within a few miles, we where able to pull into a service station where the leak was seen, the truck was towed into the next town where in the next morning it was discovered that the white clip had come loose from the fuel filter to the line. we feel very fortunate that we only lost gasoline, and that no fire or explosion occurred. we would appreciate you looking into this as the next person may not be as lucky.*ak | |||
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
| 3 | |||
| Consumer stated vehicle was stalling, the dealer replaced a fuel regulator, however the vehicle continues to stall.*yd | |||
| 09/09/2000 | 1 | 08/26/2000 | |
| Consumer was traveling on highway and saw smoke in rearview mirror. he pulled over to the shoulders ,and he jumped out of vehicle. vehicle was on fire. vehicle was totaled. fire department was notifiied, and stated that fire was caused by a mechanical malfunction of the fuel injection system. *ak | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
| 02/21/2000 | 02/21/2000 | ||
| While driving about 65 mph, driver noticed a rapid decrease in the fuel gauge. owner pulled truck over and a large puddle of fuel formed on the ground immediately. after crawling under the truck, owner and fireman were able to see the that fuel line fitting came apart because the retaining ring was defective. truck was towed to the dealership. the problem has been corrected. *ak | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
| 09/01/2002 | 1 | ||
| Consumer states has plastic fuel tank w/a plastic screw-on cap that holds the fuel gauge metering system. the cap broke. while consumer was fueling vehicle, gas pump overflowed. nlm consumer states they wasn't aware of the failure until they were fueling the vehicle and fuel spilled on the groung. ph 09-dec-2002 | |||
| 02/08/2000 | |||
| Consumer was at a gas station filling up gas tank. and gas cap was open. he went to close the cap, and he received an electrical shock. *ak | |||
| FUEL SYSTEM, OTHER | |||
| 12/03/2009 | 82000 | ||
| I have a 2000 ford ranger,the sending unit on the fuel line is made of plastic,this is the most dangerous part of the vehicle.it should be stainless steel or brass,i cant drive the truck because not only is my life in danger but also cars around me,this is not a drip it gushes out.they say to cut cost but they raise the price thousands of dollars each year.please dont say its just my vehicle,i called junk yards in maryland,virginia,deleware and pennsylvania,they cant be found.how in gods name can you approve this 50 cent fitting.i can only guess someone was paid off by ford to get this passed.shame on you,you are paid to protect the people of this country,instead you get rich and we die,i wont stop,im going to the press,and any one who will listen.i hope you or your family drive one of these vehicles,and i hope it explodes right in front of you and you can watch your family burn alive.shame on you.your supposed to look for these problems,if its not a problem why cant any be found in junk yards.i did nothing,just started to smell gas.im on disability,i have to pay for this ranger every month while it sits.anf ford,this little plastic piece with about a 12 inch tube comming off it.ford wants 200.00 for plastic and our government bails these bastards out.i hope alkida targets ford next,i will root for them,all management and people who make these decisions including you and your corrupt organisation.i hope they get you all. | |||
| 11/29/2005 | 108000 | 1 | 05/01/2000 |
| Dt*: the contact stated the check engine light illuminated, even though the vehicle drove normally. the vehicle was taken to a dealer because it would not pass the state inspection. the dealer discovered the flexible fuel sensor deteriorated which may be due to the road salts used in the state of new york. it was taken to an independent repair shop for replacement of the flexible fuel sensor. this vehicle was manufactured by the california emission standards.*ak updated 01/25/06. *jb | |||