Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | ||||||||||||||||
| 02V035000 | FORD MOTOR COMPANY | from 05/03/2001 to 01/28/2002 | V (Vehicle) | 1096 | 03/29/2002 | MFR | FORD MOTOR COMPANY | 02/04/2002 | 02/07/2002 | |||||||
| Defect Summary | On some manual transmission trucks equipped with the fx4 package, the rear axle differential case could fracture under a high torque event such as when customers accelerate rapidly from a stop or when a spinning tire suddenly gains traction. | |||||||||||||||
| Consequence Summary | Differential fractures could potentially result in wheel lock-up. | |||||||||||||||
| Corrective Summary | Dealers will replace the rear axle assembly. owner notification began march 29, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673. | |||||||||||||||
| Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN | |||||
| 0332 | 02/17/2003 | 10002479 | Thump type noise/vibration heard on light acceleration from a stop or when braking and coming to a stop. *tt | 09/03/2003 | |
| 0283 | 04/29/2002 | 637924 | Some vehicles equipped with a 2.3l, 3.0l or 4.0l engine and 5r44e or 5r55e automatic transmission may exhibit a fluid leak at the transmission servo covers in cold climates. *tt | 12/09/2002 | |
| 0282 | 04/29/2002 | 637922 | Some vehicles built prior to 9/15/2001 may exhibit low line pressure readings while in drive, no 2nd gear, no 3rd gear, no engine braking in manual 1st and slipping shifts and / or delayed engagements. *tt | 12/09/2002 | |
| 15887 | 05/01/2002 | 637755 | Some vehicles may exhibit a no 1-2 upshift, no 2-3 upshift, a no engine braking condition in manual 1 or diagnostic trouble code p0732 (gear 2 incorrect ratio) or p0733 (gear 3 incorrect ratio). *tt | 12/04/2002 | |
| 02109 | 05/27/2002 | 636085 | A thump or bump sensation felt immediately on acceleration from a stop or upon braking when coming to a complete stop. *tt | 11/05/2002 | |
| 0258 | 11/25/2002 | 02234 | 636052 | Inoperative or inacurrate speedometer, 4x4 lamp illuminatd, and / or diagnostic trouble code p1635 or p1639. *tt | 11/04/2002 |
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| 02191 | 09/30/2002 | 10008586 | Thump/bump on acceleration from a stop or when braking from driveshaft area-4x2 automatic transmission super cab edge models only. *mj | 08/06/2004 | |
| 02222 | 11/11/2002 | 10008305 | Noise-gear whine noise in 1st and 2nd gear only-vehicles equipped with 5r55e transmission and 4.0l engine only. *mj | 07/27/2004 | |
| 15785 | 04/01/2002 | 637478 | Some vehicles equipped with 5r55e/5r44e transmission may exhibit a whine noise in 1st gear that goes away after the 1-2 or 1-3 shift is completed. *tt | 11/26/2002 | |
| 16148 | 08/01/2002 | 636170 | Some vehicles may an automatic transmission may exhibit a shift lever that will not release out of the park position. *tt | 11/06/2002 | |
| 16038 | 07/01/2002 | 636233 | Some vehicles equipped with a 5r55e automatic transmission may exhibit a gear whine type noise in 1st and / or 2nd gears only. *tt | 11/06/2002 | |
| 15625 | 02/01/2002 | 630672 | Concerns with 5r44e automatic transmission fluid leak. *tt | 04/19/2002 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
| 042107 | 12/13/2004 | 042414 | 10014086 | General (pcm) power train control module programming procedures. *tt | 04/28/2005 |
| 04217 | 11/01/2004 | 10013369 | General power train control module (pcm) programming procedures. *tt | 04/15/2005 | |
| 16396 | 11/01/2002 | 10008329 | No start/no communication-contact request. *mj | 07/27/2004 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||||
| 03148 | 07/21/2003 | 10003748 | New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt | 10/29/2003 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||||
| 16064 | 07/01/2002 | 636260 | Some vehicles with manual transmission may exhibit a difficult to engage into 4x4 low condition when the ambient temperature is 0 degrees f (-18 c) or colder. *tt | 11/07/2002 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - PARK/NEUTRAL START SWITCH | |||||
| 01181 | 09/17/2001 | 625715 | Brake shift interlock.*jb | 11/30/2001 | |
| POWER TRAIN - AXLE ASSEMBLY | |||||
| 030508 | 04/01/2005 | 05620 | 10017891 | Front axle leaks fluid from vent tube - vehicles equipped with 4x4 or awd. *tt | 12/06/2005 |
| 0358 | 03/17/2003 | 10001922 | Fluid may leak out of the front axle vent tube. *tt *jb | 07/25/2003 | |
| 0242 | 03/04/2002 | 636056 | Certain vehicles with 4x4 or all-wheel drive may have a fluid leak from the front axle vent tube. *tt | 11/04/2002 | |
| 0186 | 04/30/2001 | 619276 | On some vehicles, including sport and sport trac, the front axle leaks fluid from the vent tube. *tt | 05/22/2001 | |
| POWER TRAIN - CLUTCH ASSEMBLY | |||||
| 16113 | 08/01/2002 | 636135 | Some vehicles built after 03/04/2002 and equiped with a manual transmission may exhibit a hard to shift condition. *tt | 11/05/2002 | |
| POWER TRAIN - CLUTCH ASSEMBLY - PEDAL/LINKAGE | |||||
| 15869 | 05/01/2002 | 637726 | Some vehicles may exhibit an intermittent soft clutch pedal which may cause difficulty in shifting gears (a notchy feel). *tt | 12/04/2002 | |
| 0255 | 03/18/2002 | 636047 | Hooting, eeking or moaning noise coming from the clutch when shifting gears. *tt | 11/04/2002 | |
| POWER TRAIN - DRIVELINE - DRIVESHAFT | |||||
| 04237 | 11/29/2004 | 10013414 | Driveshaft thump clunk on light acceleration from stop or when braking and coming to a stop. *eh | 04/18/2005 | |
| 02192 | 09/30/2002 | 10008587 | Driveshaft-thump/clunk heard on light acceleration from a stop or when braking and coming to a stop. | 08/09/2004 | |
| 03048 | 01/05/2003 | 03262 | 10008280 | Thump/clunk on light acceleration from stop or when braking and coming to a stop on certain 4x4 super cab equipped with automatic transmission and steel driveshaft. *tt | 07/26/2004 |
| 030302 | 02/01/2003 | 10002516 | Driveshaft - thump/clunk heard on light acceleration from a stop or when braking and coming to a stop. *tt | 09/04/2003 | |
| 0196 | 05/14/2001 | 620159 | Some 4x4 super cab vehicles may exhibit a low frequency thump type noise / vibration on light acceleration from a stop, and / or when coming to a stop with light to moderate braking. *tt | 07/19/2001 | |
| POWER TRAIN - MANUAL TRANSMISSION | |||||
| 022110 | 10/01/2002 | 10013088 | Manual shift lever outer boot detachment - fx4 models equipped with manual transmission only. *tt | 04/07/2005 | |
| 17127 | 09/01/2003 | 10004048 | Transmission whine in 5th gear. *tt | 11/17/2003 | |
| 0393 | 05/12/2003 | 10002776 | Buzz/howl in the transfer case shift lever while driving, and/or shift lever boot detachment due to insufficient retention of the boot(s). *tt | 09/17/2003 | |
| 02138 | 11/10/2003 | 032210 | 635998 | Low line pressure reading at wide open throttle (wot), slipping shifts and / or delayed engagements with possible diagnostic trouble codes p0732, p0733, p1762 set on vehicles built before 12/1/2001. *tt | 11/04/2002 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN | |||
| 01/09/2012 | 143000 | 1 | |
| I have a 2002 ford ranger 2.3l 4 cyl an when i start to drive my car will shift from 1st to 2nd so rough that my car jumps forward and then my overdrive light starts blinking and then everytime i press the gas from stopped it shifts very rough. i have been researching this problem and seems like a lot of people have this problem with this model. also when i take off there is a loud vibration sounding like it is coming from the dash or engine compartment i don't know what this is about but figured i would add that in. *tr | |||
| 01/09/2012 | 143000 | ||
| I have a 2002 ford ranger 2.3l 4 cyl an when i start to drive my car will shift from 1st to 2nd so rough that my car jumps forward and then my overdrive light starts blinking and then everytime i press the gas from stopped it shifts very rough. i have been resarching this problem and seems like a lot of people have this problem with this model. also when i take off there is a loud vibration sounding like it is coming from the dash or engine compartment i dont know what this is about but figured i would add that in. | |||
| 06/03/2011 | 100000 | ||
| Tl. the contact owns a 2002 ford ranger. the contact stated while driving 30 mph the rear differential cracked causing the rear axle to lock up. the contact towed the vehicle to a local mechanic. the local mechanic replaced the entire rear differential unit. the contact then notice a nhtsa campaign i.d. number: 02v035000 (power train:driveline:differential unit) and called the manufacturer. the manufacturer informed the contact due to the vin number the vehicle is not included in the recall. the contact stated this is a serious safety issue and identical to what's stated in the recall. the failure mileage was 100,000. jo | |||
| 11/10/2009 | 80000 | 1 | |
| I, among others own a ford ranger xlt 4.0 liter. i recently replaced my battery and lost my four wheel drive. after some involved research, i discovered that this is a recurring problem with fellow 2001, 2002 rangers. ford's refusal to claim responsibility for this engineering flaw is unsafe, unfair, and unacceptable. ford is making a fortune from this unfortunate situation and it needs to be addressed. this is criminal! *tr | |||
| 10/02/2002 | 6 | 04/05/2002 | |
| The consumer states that vehicle rocks while driving. the consumer had taken the vehicle to the dealer, and the dealer suggested that the spark plugs needed replacing. *mr the consumer sates that the vehicle goes at a rate of 2500+3000 rpm 202 ranger, shakes in the net or park. the engine cuts out and jerks at high speeds, also when passing vehicles or trucks on the freeways-cuts out, its very unsafe, and the brakes pulsate/shake when applied at highway speeds. (6000 rpm, plus the speedometer shows 120 mph) certified mechanic(s) have stated that there's something wrong with the vehicle. *scc | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 06/25/2011 | 95696 | ||
| 2002 ford ranger, automatic, extended cab. slowing down to pull into parking spot and rear tires lock up, sending truck into skid. once stopped, cannot move truck, even in neutral. | |||
| 03/23/2010 | |||
| It shifts the first gear extremely hard, once this happens, the overdrive light blinks..after doing some research i understand this a common problem with this year ford ranger | |||
| 01/12/2010 | 59825 | 1 | |
| 2002 ford ranger od light flashes and transmission shifts hard and inconsistently. *tr | |||
| 01/15/2009 | 5000 | 1 | |
| My ford 2002 ranger edge pick ups automatic transmission fails to shift gears under acceleration such as taking off from a light or merging on into traffic. the transmission will shift from one gear than not go into gear leaving vehicle on of gear and without forward motion. i have had problems getting across interceptions and onto the highway. have to remove foot from accelerator for several seconds for transmission to find a gear to shift into. ford motor company has some service bulletins regarding shifting issues but fall way short of correcting this safety issue. this has and is an on going issue since the vehicle was new. *tr | |||
| 11/24/2008 | 97000 | 1 | |
| I have a 2002 ford ranger, shortly after i purchased it the air bag light started flashing and then the o/d light started flashing and the transmission started shifting really hard into second gear. i took it to the dealership and they said the transmission needed replaced and the airbag switch was bad.. from what i have read this has been an ongoing problem with this type of transmission since it came out. it is a sealed transmission, in that,the fluid cant be checked. it's very poorly designed and ford doesn't want to do a recall even they are aware of the problem.... *tr | |||
| 05/05/2008 | 75000 | 1 | |
| Transmission shift problems on 2002 ford ranger. delayed shifts; rough shifts; overdrive light blinks indicating transmission fault; servo cover blown off allowing transmission fluid loss - inoperative vehicle. *tr | |||
| 12/29/2005 | 90125 | 3 | 09/21/2002 |
| Truck still not shifting properly after complete overhaul by ford on 5/22/04 ( complaint odi no. 10215891). ford service department road test truck and verified problem. called hotline (5lsb2012) r&r to overhaul, found sticking valve in main control(7a100), resealed trans.,replaced main control and torque converter,flushed cooler lines. but i returned the truck complaining that there was a grinding wining noise and still not shifting right. service manager road tested and said there was nothing wrong. work was performed at 60,206 miles and now at 90,125 miles i can't drive the truck because the transmission s broken again. the problem is he transmission was never fixed properly at the first over haul or the second time it was overhauled by ford. now i have a truck with a transmission overhauled twice by fore and needs overhauled again. now ford informed me that the warranty is out and they can not help me. *tr | |||
| 01/02/2006 | 1 | ||
| Rough or delayed shift 2nd to 3rd, 3rd to 4th. been to dealer and charged 800.00 for updated valve body. no better. independent shop showed me a seal that fails on many rangers causing same problem. vibration at 65-70 and grinding sound when accelerating hard from stop. *jb | |||
| 02/24/2006 | 1 | 08/15/2004 | |
| 02 ranger 4x4. ford is using jucky valve body on there auto transmission!!! this problem make the transmission slip & slow shift. on the ranger station this is the biggest problem on ranger& a big one on explorer. *jb | |||
| 01/10/2004 | 2 | ||
| Transmission in 2002 ford ranger is a piece of junk,my transmission has done it all,failed completly with only 12,000 miles,then the dealer gets it and the parts changers,not mechanics don't change enough parts(left torque converter full of garbage) i was a ford man for years now i will never ever buy another piece of ford junk!!!!!*ak | |||
| 03/29/2004 | 11000 | 2 | 11/16/2002 |
| Brake and rotor problems on ford ranger. rotors had to be turned and front tires had to be replaced at 12000 miles because the rotors became warped and vehicle shook violently. same condition is occurring again at 35000 miles and dealer refuses to fix under warranty. transmission has also been overhauled twice due to malfunction.*ak | |||
| 11/05/2003 | 28866 | 1 | 10/07/2002 |
| Buzz from front while going slow/ thump/clicking noise from under truck it's been replaced 3 times,thump feeling when tacking off. *ak | |||
| 06/30/2003 | 51000 | 1 | 12/18/2002 |
| Replacement of transmission in a 2002 ford edge ranger. this transmission went bad with no indication of a problem until the day of failure. the vehicle had 51000 miles on it at the time of failure and the truck was maintained according to manufacturers suggested maintenance. according to the dealer where the repair/ replacement was made, the torque converter had been seizing for some time throwing shrapnel into the transmission and the entire unit needed replacing.*ak | |||
| 01/19/2002 | 1 | 12/22/2001 | |
| The transmission disengaged while driving. checked the transmission fluid level, and noticed that it was very low. i brought the fluid level to normal levels, and noticed that it leaks transmission fluid very badly. | |||
| 10/26/2002 | |||
| Consumer states that vehicle was on a slight incline, lifter feet off of brake, vehicle drifted backward, with vehicle in drive gear. contacted dealer. ts | |||
| 02/18/2002 | 1 | 02/19/2002 | |
| At 55 to 60 mph vehicle jerks and lunges. took vehicle to dealer,and they stated this was normal. *ak consumer believes that the vehicle is defective. *yh | |||
| 02/03/2002 | 1 | 02/01/2002 | |
| I get 14 miles to the gal on the freeway the sticker said 19. the engine shakes at idle. it has a lean idle miss. the shaking is very bad at times. transmission does not shift right, causing bad gas mileage. i have taken it to three different dealers they all say there is no problem. but 14 miles to the gal is not acceptable.*ak | |||
| 04/24/2002 | |||
| A grinding noise would come from transmission when gear changes from 1st to 2nd, and severe vibration would occur when driving 65 -70 mph. vehicle been to dealer on several occasions, and no correction could be found at this time. feel free to provide any further information.*ak | |||
| 05/14/2002 | |||
| Transmission will jump gears while in park and surge forward with no warning. cause unknown. dealer notified.*ak | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - GEAR POSITION INDICATION (PRNDL) | |||
| 05/01/2004 | 50000 | 1 | 11/03/2001 |
| Car would not shift into overdrive. gear indicator stuck in drive, even if vehicle is in parked. preliminary ford inspection revealed 3d gear failure.*ak | |||
| 21000 | 1 | 05/01/2002 | |
| Vehicle locked up in second and third gears. this caused the rear brakes to lock up. as a result, driver lost control and hit a fence. *ak | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||
| 10/02/2002 | 6 | 04/05/2002 | |
| The consumer states that vehicle rocks while driving. the consumer had taken the vehicle to the dealer, and the dealer suggested that the spark plugs needed replacing. *mr the consumer sates that the vehicle goes at a rate of 2500+3000 rpm 202 ranger, shakes in the net or park. the engine cuts out and jerks at high speeds, also when passing vehicles or trucks on the freeways-cuts out, its very unsafe, and the brakes pulsate/shake when applied at highway speeds. (6000 rpm, plus the speedometer shows 120 mph) certified mechanic(s) have stated that there's something wrong with the vehicle. *scc | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - TORQUE CONVERTER | |||
| 03/29/2006 | 43000 | 1 | 01/04/2003 |
| Auto transmission on 2002 ford ranger edge with 43000 miles failed due to torque converter failure. vehicle not used for towing or hauling. required complete overhaul of transmission. *nm | |||
| POWER TRAIN - AXLE ASSEMBLY | |||
| 12/30/2004 | 39177 | 1 | 03/29/2002 |
| Correction to my original copmplaint my 2002 ranger rear tires got stuck in a lil snow on the street and as they hit pavment while moving foward i heard a pop from the rear then heard a few more while turning corners and had a rear end lock up. took to dealer on flat bed and they told me that my rear differential carrier had snapped (rear axle housing) and they will not fix it. rear axle housings do not break like this and there was a recall on the 2002 fx4 manual trans rangers for this same reason and feel the autos need to be recalled before someone gets killed or hurt. consequence is rear end lockup.*ak | |||
| 12/30/2004 | 1 | ||
| While driving vehicle got stuck in the snow. consumer was able to get out of the snow when all of a sudden a loud pop noise was heard from the rear, causing the vehicle not to move. took vehicle to the dealer for check up, and results showed that the rear axle needed to be replaced.*ak | |||
| 09/08/2004 | 3 | ||
| A loud knocking and grinding noise was head coming from the front of the vehicle. consumer took vehicle to the dealer for inspection, and mechanic informed determined that front driver's side and passenger's side axles/tires, and other parts needed to be replaced. consumer informed the mechanic that problem recurred. *ak | |||
| POWER TRAIN - CLUTCH ASSEMBLY | |||
| 02/07/2008 | 66680 | 3 | 02/28/2006 |
| I have a 2002 ford ranger that when i got the truck it had to have the slave cylinder for the clutch replaced which the dealer did, and the truck only had 18,000 miles, but then again before my extended warranty ran out, it went out again at about 52000 miles, and now it has happened again, at 66,000 miles, the slave cylinder again for the clutch, and i am not new to driving manual transmissions, i am 47 and learned to drive on a manual transmission when 16, it also upsets me that ford said my extended warranty for the second repair did not cover the clutch slave cylinder, and i do not believe a vehicle should require this part to be replaced approximately every twenty or thirty thousand miles. i also believe since i purchased a manual with an extended warranty it should have been covered, my son also has a 2000 ford ranger and he recently had the same problem and we both have the v6 with 5 speed manual transmission. *tr | |||
| 04/22/2002 | 15000 | 75 | 02/25/2002 |
| I took my 1 year and 2 month old ranger to the dealership to correct a problem i had been having with it not going into gear. the condescending man at the dealership told me after a 5 minute look at my truck that i needed to have my clutch replaced, and that it was out of warranty by 2 months. in calling around to get prices on the replacement of the clutch, i was almost unanimously told that it was next to impossible to have a clutch go out in a vehicle in that short of a time period, when it has not been abused, which mine has not. in researching this, i have found that a lot of people have had similar problems with the clutch on the 2002 ford ranger 3.0. *jb | |||
| 06/01/2003 | 52000 | 1 | 01/30/2002 |
| Clutch slave cylinder failed on a 16 month old ford ranger 5 speed, 4 cylinder. *jb | |||
| 10/16/2002 | 1066 | 0 | 10/16/2002 |
| I am having multiple problems with my 6 month old truck. a strange oil loss that was loosing 1-2 quarts of oil a week, now fixed for the moment. the clutch disengages if any pressure is applied to the clutch pedal and will not engage until the pedal is fully released, dealer claims its normal. various electrical problems with this heap, including failing sensors, interior light coming on when it wants to, and the check engine light comes on occasionally. this truck has starting problems sometimes, you have to crank the engine for a long time(up to 30 seconds sometimes) before it will start. had to have a tire replaced with 1066 miles on the vehicle because some of the tread was beginning to come off, vehicle was realigned at the same time to cure a pull to the right which did nothing still pulls to the right. i have tried to get in contact of ford motor company to get this vehicle replaced under a lemon law to no avail. i get told a story and put off, the dealership i bought this thing from does the same thing tries to fix it to no avail and puts me off. i paid 15 thousand dollars for this truck and now may lose my job because it is not dependable! something must be done this is not how to treat a repeat customer, this being my 4th ford product and my last. *nlm | |||
| 12/15/2001 | 1 | 12/13/2001 | |
| The clutch failed with less than 100 miles, would not disengage. towed to dealer. *yd | |||
| 12/15/2001 | 2 | 12/01/2001 | |
| Dealer presented vehicle as repaired 12-22-1 (replaced slave cylinder for clutch). was still not disengaging. still at willey ford. | |||
| POWER TRAIN - DRIVELINE | |||
| 01/12/2011 | 73000 | ||
| Tl-the contact owns a 2002 ford ranger. while driving approximately 35 mph on an icy road, the vehicle skidded, followed by a loud sound of spinning tires. suddenly, the vehicle began to lurch forwardly. the contact was able to gain control and resumed to her destination. after the vehicle was parked for six hours and restarted, there was no response when pressure was applied to the accelerator pedal because the wheels locked. a mechanic came to the scene to inspect the vehicle and unlocked the wheels. the brakes would not function effectively after the wheels were unlocked. also, the four wheel drive would not operate upon engagement. the vehicle had not been repaired. the failure was related to a recall defect under nhtsa campaign id number 02v035000 (power train: driveline: differential unit). the recall pertained to manual transmissions which resulted to the vehicle not being included. the failure mileage was 73,000. the vin was unavailable. js | |||
| 11/25/2008 | 88066 | 1 | |
| The right rear axle flange separated from | |||
| 10/10/2008 | 26500 | 1 | |
| At approx. 26,500 miles vehicle made popping/clunk sound accompanied by a jerking movement when turning. especially slow turns after making a stop. sound came from rear end. 1 or both rear tires would bind in slow corners and skid. ford dealer confirmed broken gears in differential. 2002 ranger ext. cab with manual trans, 4 cyl, 2wd. $1,650 to repair. ford will not assist in paying for any part of this. evidently ford is satisfied with their bread and butter trucks failing so quickly. this is how they lose a customer for life, by not standing behind their vehicles. too many reports of this failure for it not to be taken care of by ford. very angry, ford, your huge losses are well deserved. *tr | |||
| 01/30/2003 | 6643 | 2 | 10/12/2002 |
| Truck pulls to the right especially at highway speeds. at times severe vibration and rubbing noise. safety definetly an issue when driving vehicle. more recently 4x4 engaged & truck tilted to front right and made loud grinding noise, could only drive 5mph or so. put in reverse and was able to drive it at highway speeds but still pulls, vibrates and is getting worse. now, a oil leak found. also, anti lock brakes are locking up. fan motor cooler not working correctly. *ak | |||
| POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||
| 12/14/2007 | 111000 | 1 | 11/15/2001 |
| 1) events leading up to the failure: normal everyday mode of transportation via highway and surface streets. 2)failure and consequences: the rear limited slip differential unit of my 2002 ford ranger fx4 automatic transmission vehicle broke causing the truck to stop abruptly nearly causing an accident. the rear limited slip differential unit exploded causing the gears to break and stop the vehicle from driving. i had contacted the manufacturer (torsen) of the differential unit and stated the unit i had was recalled according to the serial number. ford motor company negelantly did not recall all vehicles with the recalled differential units. 3) the truck's rear differential unit and gear was replaced with oem ring and pinion gears, bearings and similar type limited slip differential unit from a different manufacturer (detroit truetrac) from which was orginally installed in the vehicle. cost $1,400.00.*cn | |||
| 10/10/2007 | 35000 | 2 | 06/01/2002 |
| Tl*the contact owns a 2002 ford ranger. while driving 2 mph, the contact heard a loud grinding and clunking noise. he also noticed fluid leaking from the rear differential unit. the dealer stated that there was a fracture in the rear differential case. the dealer and manufacturer stated that his vin was not included in nhtsa campaign id number 02v035000 (power train: driveline: differential unit). the contact felt that his vehicle should be included in the recall. the failure mileage was 35,000 and current mileage was 80,000. | |||
| 11/01/2006 | 50000 | 1 | 10/15/2006 |
| Dt*: the contact stated the rear axle differential was damaged and needed to be replaced. the service dealer determined the rear axle differential could be changed at a charge. the contact expressed concern that this was a defect. updated 11/30/2006 - while driving the rear of the truck shook profusely. an independent repair facility determined that the rear axles were cracked and the entire rear differential should be replaced. the consumer was informed of a recall related to this problem. the consumer contacted the dealer who admitted there was a recall but stated that it had expired. the consumer contacted the manufacturer. the customer service rep explained that the recall hadn't expired it just didn't exist for the consumer's ranger. the service rep when on to tell the consumer that the recall was fir 2002 ranger 4x4 with manual transmission. the consumer's vehicle has an automatic transmission. *nm | |||
| 06/23/2006 | 65000 | 1 | |
| 2002 ford ranger fx4- automatic transmission. vehicle had approx. 65k miles at the time of incident. drove vehicle normally, started noticing clunking sound coming from the rear. mechanic diagnosed as a cracked rear differential unit that was very close to causing axle to lock up. parts replaced by my mechanic at the cost of approx. $1500. sounds very similar to recall #02v035000 concerning manual transmission version. *nm | |||
| 11/15/2004 | 46000 | 1 | 07/20/2002 |
| Nhtsa campaign 02v035000; ford issued an rear axle differential case recall. this vehicle is not included in the recall, but has a bent axle in which it could break. the vin is outside the remedy scope. *nm *nm | |||
| 01/24/2004 | 38000 | 1 | 01/09/2002 |
| I purchased a 2002 ranger edge 4x4 , it had 4 miles on it. i have since replaced the airbag sensor, abs sensor, front end had tobe realigned due to a bad alignment at the factory,the tires in the front had to be replaced at 4500 miles. now at 38000 miles the 4x4 drivetrain was leaking at the front cover. the breathing tube was throwing oil out onto the engine . i was told by ford company and a ford tech. that this was a e4nginnering problem. it was replaced at my cost of 796.00. the cover was replaced with a part that was used previous to 1995, part number is fof6tz-4033-ba. my complaint is why is this not a recall and can i expect future problems. *jb | |||
| 08/01/2003 | 14500 | 1 | |
| The differential housing leaked fluid. a recall was issued, however this vehicle was not included in the recall due to vin. *ak | |||
| Recall 02v035000; while driving the vehicle consumer noticed a low hum coming from the back of the vehicle. hum starts to get louder. took vehicle to the dealer, dealer stated rear end was bad. please provide any further information.*ak | |||
| POWER TRAIN - DRIVELINE - DRIVESHAFT | |||
| 11/11/2004 | 43131 | 1 | 12/21/2001 |
| 2002 ford ranger stalled. *bf the drive shaft jerked and slammed when accelerating in drive or reverse. the drive shaft assembly was replaced but that did not solve the problem. *nm | |||
| 01/30/2003 | 6643 | 2 | 10/12/2002 |
| Truck pulls to the right especially at highway speeds. at times severe vibration and rubbing noise. safety definetly an issue when driving vehicle. more recently 4x4 engaged & truck tilted to front right and made loud grinding noise, could only drive 5mph or so. put in reverse and was able to drive it at highway speeds but still pulls, vibrates and is getting worse. now, a oil leak found. also, anti lock brakes are locking up. fan motor cooler not working correctly. *ak | |||
| 08/07/2001 | 1000 | 1 | 06/11/2002 |
| Slight jerking coming from drive train when lightly accelerating and braking. dealer replaced driveshaft in aug. 2002, problem went away temporarily, came back and returned to dealer. was told there is no repair available. called ford motor to complain and got no satisfaction.*ak | |||
| POWER TRAIN - MANUAL TRANSMISSION | |||
| 1 | |||
| While shifting and decelerating the consumer heard a clunking noise. the dealer denied any problem with the vehicle. *nlm | |||
| When pulling up to a stop truck rattles with an awkward sound. dealership has made several attempts to correct, but with no success. ford has sent out a tsb on this, but even that has not corrected the problem. a factory representative spoke with the owner and basically told him that the truck was like that. the engine is 3.0 litre w/5 speed transmission, edge series model pickup. please describe details. *ak | |||
| POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||
| 01/01/2004 | 20000 | 1 | 07/31/2002 |
| (1) grinding noise coming from front transfer case on 4x4 drivetrain, noticeable at 30 to 40 mph..precent at all speeds more apparent at speeds described, at high speeds 40 to 80mph grinding noise masked by wind/road noise. noise started at under 20000 miles on vehicle, vehicle currently has 27k miles and grinding/noise is more pronounced. (2) no apparent component failure yet, several ranger 4x4 owners have this problem.(member of a ranger forum of 1000+ members). will it cause premature failure of front drive line components leading to crash and or death? (3) dealership is aware of the problem, only way to correct it is to use harder tires; dealer will not recommend goodyears which is what is installed by the factory. *ak | |||