Recalls

CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
EXTERIOR LIGHTING
06E065000AJ MOTORSPORT E (Equipment)359307/31/2006OVSCFORD MOTOR COMPANY07/17/200607/17/2006571108
Defect SummaryCertain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence SummaryLack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Corrective SummaryAj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.
NotesThis recall only pertains to aj motorsport aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled
09E012000SABERSPORT E (Equipment)1627005/11/2009OVSCFORD MOTOR COMPANY04/07/200904/07/2009571108
Defect SummarySabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. these lamps do not contain the required amber side reflectors.
Consequence SummaryDecreased lighting visibility may result in a vehicle crash.
Corrective SummarySabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
NotesThis recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under document search located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
06E049000CK MOTORSPORT, INC. E (Equipment)2717607/01/2006OVSCFORD MOTOR COMPANY05/24/200606/05/2006571108
Defect SummaryCertain ck motorsports combination headlights, clear corner, bumper, and side marker lights sold as replacement lamps for use on the passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence SummaryWithout the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
Corrective SummaryCk motorsport will notify owners and replace the noncompliant lamps free of charge. the recall began on july 1, 2006. owners may contact ck motorsport at 1-909-610-7211.
NotesThis recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.for more information on the lamp model numbers, click on document search and view document titled
EXTERIOR LIGHTING - HEADLIGHTS
09E025000DOPE, INC. E (Equipment)4254007/28/2009OVSCFORD MOTOR COMPANY05/11/200905/11/2009571108
Defect SummaryDope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. these lamps do not contain the required amber side reflectors.
Consequence SummaryDecreased lighting visibility may result in a vehicle crash.
Corrective SummaryDope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
NotesThis recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under document search located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .

Bulletins

BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
EXTERIOR LIGHTING - BRAKE LIGHTS
0561904/01/200510017889Brake lamp concerns. *tt12/06/2005

Investigations

NHTSA IDManufacturerDate openDate closeSubjectRecall campaign
EXTERIOR LIGHTING
PE05066FORD MOTOR COMPANY12/05/200503/24/2006BRAKE LIGHTS INOPERATIVE
 This pe was opened based on technical service bulletin (tsb) #05-6-19 issued by ford motor company and service bulletin #09-008/5 issued by mazda motor corporation to address concerns of the center high mounted stop light (chmsl) wiring harness chaffing. the tsb's affected the ford super cab and mazda cab plus vehicles only.service technicians contacted the ford hotline because it was difficult for the technicians to diagnose and locate the cause of the inoperative brake lights.ford and mazda issued the tsb's to aid technicians in the identification and repair of the wire chafe condition.of all warranty claims submitted to ford for brake lamp failure, ford identified only 120 that were related to wire chafe near the chmsl, and most (115 of the 120) were reported for the super cab chmsl. odi's review of ford's warranty claims and complaint data reveals a declining trend for the super cab and that trend closely parallels the trend for the standard cab as well.a safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances.
EXTERIOR LIGHTING - BRAKE LIGHTS
PE05066FORD MOTOR COMPANY12/05/200503/24/2006BRAKE LIGHTS INOPERATIVE
 This pe was opened based on technical service bulletin (tsb) #05-6-19 issued by ford motor company and service bulletin #09-008/5 issued by mazda motor corporation to address concerns of the center high mounted stop light (chmsl) wiring harness chaffing. the tsb's affected the ford super cab and mazda cab plus vehicles only.service technicians contacted the ford hotline because it was difficult for the technicians to diagnose and locate the cause of the inoperative brake lights.ford and mazda issued the tsb's to aid technicians in the identification and repair of the wire chafe condition.of all warranty claims submitted to ford for brake lamp failure, ford identified only 120 that were related to wire chafe near the chmsl, and most (115 of the 120) were reported for the super cab chmsl. odi's review of ford's warranty claims and complaint data reveals a declining trend for the super cab and that trend closely parallels the trend for the standard cab as well.a safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances.
EXTERIOR LIGHTING - TAIL LIGHTS
PE05066FORD MOTOR COMPANY12/05/200503/24/2006BRAKE LIGHTS INOPERATIVE
 This pe was opened based on technical service bulletin (tsb) #05-6-19 issued by ford motor company and service bulletin #09-008/5 issued by mazda motor corporation to address concerns of the center high mounted stop light (chmsl) wiring harness chaffing. the tsb's affected the ford super cab and mazda cab plus vehicles only.service technicians contacted the ford hotline because it was difficult for the technicians to diagnose and locate the cause of the inoperative brake lights.ford and mazda issued the tsb's to aid technicians in the identification and repair of the wire chafe condition.of all warranty claims submitted to ford for brake lamp failure, ford identified only 120 that were related to wire chafe near the chmsl, and most (115 of the 120) were reported for the super cab chmsl. odi's review of ford's warranty claims and complaint data reveals a declining trend for the super cab and that trend closely parallels the trend for the standard cab as well.a safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances.

Consumer Complaints

Fail datemilesoccurencesPurchase date
EXTERIOR LIGHTING - BRAKE LIGHTS
 Vehicle's brake lights also function as the turn signals indicators. consumer feels this design is very unsafe because if your are braking and signaling for a turn, you lose 1/2 of braking visibility to alert other traveling vehicles. this design defect increased the risk of rear-end collisions.
EXTERIOR LIGHTING - FOG LIGHTS
02/03/2005203/08/2004
 Fog lamp lenses on 2003 ford ranger pick-up truck keep cracking. dealer claims roadside debris is the cause. however, both lenses have cracked twice at the same time. complaints have been made twice to ford motor co. which has no recall record for this type of incident. *nm
EXTERIOR LIGHTING - HEADLIGHTS
10/23/20031
 I was blinded by oncoming head lights not set to high beam and distraction from very bright head lights in rear view mirror (also not on high beam). the source is ford ranger pickups built in the last 5 years. other makes of trucks and suv's can be bad, but the ranger is the worst of the bunch. *la
EXTERIOR LIGHTING - TURN SIGNAL
 Vehicle's brake lights also function as the turn signals indicators. consumer feels this design is very unsafe because if your are braking and signaling for a turn, you lose 1/2 of braking visibility to alert other traveling vehicles. this design defect increased the risk of rear-end collisions.

Some parts © 2024 Advameg, Inc.
Based on public records. Inadvertent errors are possible.
This web site is not associated with, endorsed by, or sponsored by and has no official or unofficial affiliation with the vehicle's manufacturer.