Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
EXTERIOR LIGHTING | ||||||||||||||||
06E065000 | AJ MOTORSPORT | E (Equipment) | 3593 | 07/31/2006 | OVSC | FORD MOTOR COMPANY | 07/17/2006 | 07/17/2006 | 571 | 108 | ||||||
Defect Summary | Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. | |||||||||||||||
Consequence Summary | Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash. | |||||||||||||||
Corrective Summary | Aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026. | |||||||||||||||
Notes | This recall only pertains to aj motorsport aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled | |||||||||||||||
EXTERIOR LIGHTING - BRAKE LIGHTS | ||||||||||||||||
11V352000 | FORD MOTOR COMPANY | V (Vehicle) | 26715 | MFR | FORD MOTOR COMPANY | 07/13/2011 | 07/13/2011 | 571 | 108 | |||||||
Defect Summary | Ford is recalling certain model year 2011 ranger trucks built from january 25, 2011, through april 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250, f-350, f-450, and f-550 trucks for failing to comply with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. the multi-function switch was shipped with a subcomponent (slider) that may experience deformation. a multi-function switch with a deformed slider may malfunction causing the turn signal, tail lights, hazard warning signal flashers and/or brake lights not to activate. | |||||||||||||||
Consequence Summary | Non-functioning lights could increase the risk of a crash. | |||||||||||||||
Corrective Summary | Dealers will replace the switches free of charge. the safety recall is expected to begin on or about august 15, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332. | |||||||||||||||
Notes | Ford's safety recall no. 11c18.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
EXTERIOR LIGHTING - HEADLIGHTS | ||||||||||||||||
09E025000 | DOPE, INC. | E (Equipment) | 42540 | 07/28/2009 | OVSC | FORD MOTOR COMPANY | 05/11/2009 | 05/11/2009 | 571 | 108 | ||||||
Defect Summary | Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment. these lamps do not contain the required amber side reflectors. | |||||||||||||||
Consequence Summary | Decreased lighting visibility may result in a vehicle crash. | |||||||||||||||
Corrective Summary | Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798. | |||||||||||||||
Notes | This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under document search located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
EXTERIOR LIGHTING - BRAKE LIGHTS | |||||
05619 | 04/01/2005 | 10017889 | Brake lamp concerns. *tt | 12/06/2005 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
EXTERIOR LIGHTING | ||||||
PE05066 | FORD MOTOR COMPANY | 12/05/2005 | 03/24/2006 | BRAKE LIGHTS INOPERATIVE | ||
This pe was opened based on technical service bulletin (tsb) #05-6-19 issued by ford motor company and service bulletin #09-008/5 issued by mazda motor corporation to address concerns of the center high mounted stop light (chmsl) wiring harness chaffing. the tsb's affected the ford super cab and mazda cab plus vehicles only.service technicians contacted the ford hotline because it was difficult for the technicians to diagnose and locate the cause of the inoperative brake lights.ford and mazda issued the tsb's to aid technicians in the identification and repair of the wire chafe condition.of all warranty claims submitted to ford for brake lamp failure, ford identified only 120 that were related to wire chafe near the chmsl, and most (115 of the 120) were reported for the super cab chmsl. odi's review of ford's warranty claims and complaint data reveals a declining trend for the super cab and that trend closely parallels the trend for the standard cab as well.a safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances. | ||||||
EXTERIOR LIGHTING - BRAKE LIGHTS | ||||||
PE05066 | FORD MOTOR COMPANY | 12/05/2005 | 03/24/2006 | BRAKE LIGHTS INOPERATIVE | ||
This pe was opened based on technical service bulletin (tsb) #05-6-19 issued by ford motor company and service bulletin #09-008/5 issued by mazda motor corporation to address concerns of the center high mounted stop light (chmsl) wiring harness chaffing. the tsb's affected the ford super cab and mazda cab plus vehicles only.service technicians contacted the ford hotline because it was difficult for the technicians to diagnose and locate the cause of the inoperative brake lights.ford and mazda issued the tsb's to aid technicians in the identification and repair of the wire chafe condition.of all warranty claims submitted to ford for brake lamp failure, ford identified only 120 that were related to wire chafe near the chmsl, and most (115 of the 120) were reported for the super cab chmsl. odi's review of ford's warranty claims and complaint data reveals a declining trend for the super cab and that trend closely parallels the trend for the standard cab as well.a safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances. | ||||||
EXTERIOR LIGHTING - TAIL LIGHTS | ||||||
PE05066 | FORD MOTOR COMPANY | 12/05/2005 | 03/24/2006 | BRAKE LIGHTS INOPERATIVE | ||
This pe was opened based on technical service bulletin (tsb) #05-6-19 issued by ford motor company and service bulletin #09-008/5 issued by mazda motor corporation to address concerns of the center high mounted stop light (chmsl) wiring harness chaffing. the tsb's affected the ford super cab and mazda cab plus vehicles only.service technicians contacted the ford hotline because it was difficult for the technicians to diagnose and locate the cause of the inoperative brake lights.ford and mazda issued the tsb's to aid technicians in the identification and repair of the wire chafe condition.of all warranty claims submitted to ford for brake lamp failure, ford identified only 120 that were related to wire chafe near the chmsl, and most (115 of the 120) were reported for the super cab chmsl. odi's review of ford's warranty claims and complaint data reveals a declining trend for the super cab and that trend closely parallels the trend for the standard cab as well.a safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
EXTERIOR LIGHTING - HEADLIGHTS - SWITCH | |||
03/19/2007 | 8200 | 2 | 02/02/2005 |
Headlamp switch knob breaks and falls off. 2nd replacement in 2005 ford ranger with 8000 miles. without knob, impossible to turn headlamps on and off without pliers. had to buy new switch knobs. |