Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
STRUCTURE - FRAME AND MEMBERS | ||||||||||||||||
98V323000 | FORD MOTOR COMPANY | from 10/14/1985 to 06/27/1995 | V (Vehicle) | 2697000 | 01/18/1999 | ODI | FORD MOTOR COMPANY | 12/16/1998 | 12/18/1998 | |||||||
Defect Summary | Vehicle description: passenger vehicles originally sold or currently registered in connecticut, delaware, district of columbia, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, nebraska, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, virginia, west virgnia, and wisconsin. the rear lower subframe mount plate nut can experience stress corrosion cracking if subjected to long term exposure to road salts. this can result in fracture and loss of the structural integrity of the subframe mount attachment. detachment of the body mounts at the rear corners of the subframe, which supports the engine and transmission, allows the rear corners of the subframe to drop. | |||||||||||||||
Consequence Summary | If both rear corners drop, steering would become suddenly very difficult, affecting vehicle control and increasing the risk of a crash. | |||||||||||||||
Corrective Summary | Dealers will install subframe rear mount bolts, reinforcement plates, and plate nuts. | |||||||||||||||
Notes | Note:this recall campaign supercedes recall campaign 93v-106.owner notification is expected to begin january 18, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
93V106000 | FORD MOTOR COMPANY | from 10/01/1985 to 09/01/1988 | V (Vehicle) | 1610000 | 07/22/1993 | ODI | FORD MOTOR COMPANY | 06/23/1993 | 06/23/1993 | |||||||
Defect Summary | Vehicle description: taurus and sables built from 10-14-85 through 8-19-88, and lincoln continentals built from 11-4-87 through 9-30-88 (except 1989 - 1991 2.5l taurus and 1989 - 1992 sho). the affected cars were originally sold or currently registered in the following states: connecticut, illinois, indiana, maine, massachusetts, michigan, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, and wisconsin. the body mounts at the rear corners of the subframe, which supports the engine and transmission, may become detached due to corrosion of the subframe mount retaining plate. this would allow the rear corners of the subframe to drop. | |||||||||||||||
Consequence Summary | If one of the rear corners drops, only minor indications of a malfunction such as a clunking noise or slight change in steering wheel alignment are noticeable. however, if both rear corners of the subframe drop, steering becomes very difficult, which could adversely affect vehicle control and possibly result in an accident. | |||||||||||||||
Corrective Summary | Install a corrosion-resistant reinforcing plate and a new bolt on both rear subframe mounts. this recall campaign has been superseded by recall 98v-323. | |||||||||||||||
Notes | This recall campaign has been superseded by recall 98v-323. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
STRUCTURE - BODY - BUMPERS | |||||
9832 | 02/16/1998 | 600586 | Front and rear bumpers made of xenoy plastic have had the conductive primer removed from service parts. *yc | 05/27/1998 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
STRUCTURE | ||||||
PE91036 | FORD MOTOR COMPANY | 01/22/1991 | 05/22/1991 | DOOR HANDLES BREAKAGE | ||
There is no summary currently available | ||||||
EA92040 | FORD MOTOR COMPANY | 11/30/1992 | 06/30/1993 | SUB-FRM/UNIBODY ABSOR.FAIL | 93V106000 | |
There is no summary currently available | ||||||
EA91042 | FORD MOTOR COMPANY | 10/28/1991 | 05/21/1992 | STORAGE COMPAR SUFFOCATION | 92V065000 | |
There is no summary currently available | ||||||
EA92040 | FORD MOTOR COMPANY | 11/30/1992 | 06/30/1993 | SUB-FRM/UNIBODY ABSOR.FAIL | 93V106002 | |
There is no summary currently available | ||||||
PE91108 | FORD MOTOR COMPANY | 08/01/1991 | 10/28/1991 | STORAGE COMPAR SUFFOCATION | ||
There is no summary currently available | ||||||
EA92040 | FORD MOTOR COMPANY | 11/30/1992 | 06/30/1993 | SUB-FRM/UNIBODY ABSOR.FAIL | 93V106001 | |
There is no summary currently available | ||||||
PE92056 | FORD MOTOR COMPANY | 07/01/1992 | 11/30/1992 | SUB-FRM/UNIBODY ABSOR.FAIL | ||
There is no summary currently available | ||||||
STRUCTURE - FRAME AND MEMBERS | ||||||
RQ97009 | FORD MOTOR COMPANY | 08/29/1997 | 02/16/1999 | REAR LOWER SUBFRAME ASSEMBLY | 93V106000 | |
To determine whether the cars that were not included in the safety recall 93v-106 should be recalled due to the same failure phenomenon, and to determine if there is remedy failure issue | ||||||
RQ97009 | FORD MOTOR COMPANY | 08/29/1997 | 02/16/1999 | REAR LOWER SUBFRAME ASSEMBLY | 98V323000 | |
To determine whether the cars that were not included in the safety recall 93v-106 should be recalled due to the same failure phenomenon, and to determine if there is remedy failure issue |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
STRUCTURE | |||
08/25/1997 | 1 | 07/11/1997 | |
Rear body mounts of the subframe corroded and failed. the subframe dropped, pulling apart the steering column. the driver lost all steering control while driving. the consumer found out a recall campaign 93v106001 and 93v106000, however the vehicle's vin number was not included in this particular recall. | |||
STRUCTURE - BODY | |||
Unusual peeling or fading of paint. | |||
04/08/1995 | 8 | ||
Rear subframe mounts failed, causing loss of control. *sd | |||
STRUCTURE - BODY - DOOR | |||
12/01/1998 | |||
The rear driver's and passenger's door handles broke. doors cannot be opened from the outside or inside of the vehicle. also, buckle broke on the shoulder belt of the passenger's side, which won't protect the occupant in event of an accident. please provide further information. *ak | |||
09/28/1998 | 1 | ||
Plastic door and window handles break too easily. headlight reflector faded causing dimmer headlights. | |||
12/20/1996 | 5 | 11/25/1987 | |
Engine failure; also replaced transmission/steering rack/alternator/power locks. *ak | |||
05/02/1997 | 05/15/1985 | ||
Right rear door locks when using power locks due to a broken solenoid mounting bracket. also, when using the air conditioner during acceleration the dash vents close. *ak | |||
Vehicles drivers door handle is constantly breaking and passengers door handle also. tt | |||
01/01/1993 | 2 | ||
Front driver/passenger and rear seat plastic inside door handle broke, making it impossible to open door in emergency. tt | |||
Driver/passenger side plastic inside door handles break making impossible to open from inside, has replaced door handles several times. tt | |||
STRUCTURE - BODY - HOOD - HINGE AND ATTACHMENTS | |||
03/08/1997 | |||
While driving the hood flew up and broke both hinges on the hood. this happened without any warning. *ak | |||
STRUCTURE - BODY - TRUNK LID | |||
01/05/1996 | 5 | ||
Trunk stops excessively rusted, causing trunk lid to close further than designed, severing owners finger. (attorney for client) *dsh | |||
STRUCTURE - FRAME AND MEMBERS | |||
10/01/2011 | 1 | ||
1987 ford taurus. consumer states sub frame both left side and right side of the front end broke off while driving *tgw the dealer informed the consumer his model year had been recalled for the exact problem he experienced. ford motor co. stated they would assume no responsibility. *jb | |||
09/12/1999 | 04/01/1998 | ||
Consumer received nhtsa recall letter98v323000/manufacturer's recall 98s36 for the subframe rear plate nut needing to be replaced. dealer has been contacted, and refused to do the work. manufacturer also has been contacted.*ak | |||
After recall was performed for subframe corrosion, the condition of the vehicle became worse. manufacturer has been notified. *ak | |||
Subframe which supports the engine and the transmission may become detached due to corrosion. vehicle not included in recall. please give any further details. | |||
01/01/1999 | 1 | ||
Recall repairs on (98v-323) not completed due to scheduling problems with dealership. mjs | |||
02/01/1999 | 1 | ||
Dealer refused to perfprm recall 98s36 on rear lower submount plate nut. | |||
03/26/1999 | 1 | 01/01/1987 | |
Vehicle taken to dealership to have subframe rear plate nut recall work performed, however when consumer picked vehicle up, recall repairs were not done. (98v-323) | |||
01/01/1999 | 1 | ||
Recall notice received (98v-323,sub-frame mounts), however vehicle denied due to vin #. | |||
11/24/1998 | 2 | ||
Cradle mounts broke due to defective parts. | |||
02/20/1999 | 2 | 02/01/1999 | |
Two mounting bolts for front sub-frame rear corner were split break from the stress. | |||
02/13/1999 | |||
Took vehicle into the shop for a recall service, and when consumer came back to pick up vehicle, he noticed a leakage coming from the radiator. dealer refused to fix the problem because consumer had the vehicle in for the rear motor mounts to be fixed. but, fluid was leaking all over the place. *ak | |||
02/11/1999 | 01/01/1998 | ||
Nhtsa recall campaign 98v32300. the subframe mounts failed and steering became very difficult. we took the car to a ford dealer, who told us that the part that failed was subject to a recall, but could not perform the service on my car because ford had blocked the vin. i called ford. i was told that the recall did not apply to my vehicle. i have researced the recall 98v323000 which states that prolonged exposure to salt cause this part to fail. however, my state was not included in the list, even though salt is regularly put down on snowy roads in utah. i would like this saftey problem to be fixed by ford at no cost. can you help me? | |||
06/02/1998 | |||
Experiencing rear lower subframe mount plate nut broke off while driving on highway at approx. 40-45 mph, causing damages to engine and transmission while vehicle was out of control. consumer was able to move vehicle to the side of the road. dealer/manufacturer were not notified at this time. *ak | |||
06/20/1998 | 1 | ||
Recall notice on the body mounts (#92s61) was not received by consumer prior to failure. | |||
08/27/1997 | 50 | 07/11/1997 | |
Rear subframe body mounts failed, causing steeering column to pull apart prior to recall. recdall repairs refused due to vin (93v-106.01). | |||
01/14/1998 | |||
Recall # 94e036000; when traveling the body mounts which support the engine and transmission rusted which caused poor steering control. consumer has contacted the dealer. please provide any further details. *ak | |||
09/24/1997 | |||
Rear sub-frame body mounts which support the engine and transmission failed. *ak | |||
05/22/1997 | 1 | 08/04/1987 | |
Rear mounts failed and the sub frame fell off. | |||
1 | 10/18/1993 | ||
Frame failed before recall repair causing motor to drop. | |||
04/29/1997 | 10/10/1995 | ||
Rear sub-frame mounts disconnected due to corrosion prior to recall (93v-106.001). *ak | |||
11/01/1996 | 1 | 08/21/1996 | |
Owner notes that steering bushings came apart, resulting in loss of control while driving, or total steering failure. *ak *jb |