Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - IGNITION | ||||||||||||||||
96V071000 | FORD MOTOR COMPANY | from 08/01/1987 to 09/30/1992 | V (Vehicle) | 7900000 | 06/07/1996 | ODI | FORD MOTOR COMPANY | 04/25/1996 | 05/01/1996 | |||||||
Defect Summary | The ignition switch could experience an internal short circuit. | |||||||||||||||
Consequence Summary | This condition could cause overheating, smoke, and possibly fire in the steering column area of the vehicle. | |||||||||||||||
Corrective Summary | Dealers will replace the ignition switch. | |||||||||||||||
Notes | System: electrical; ignition switch. vehicle description: passenger and multi-purpose vehicles and light duty trucks. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact ford at 1-800-392-3673. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM | |||||
98246 | 12/07/1998 | 604059 | Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc | 03/16/1999 | |
ELECTRICAL SYSTEM - STARTER ASSEMBLY | |||||
97111097234 | 11/10/1997 | 53660 | Vehicles exhibiting a squeaking or chirping from the blower motor at low blower motor speeds. *yc | 03/30/1998 | |
ELECTRICAL SYSTEM - WIRING | |||||
99222 | 10/18/1999 | 6089681 | Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt | 02/11/2000 | |
96246 | 11/18/1996 | 50905 | Wiring - electrical diode identification and service replacements. *tw | 06/17/1997 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM | |||
12/21/2001 | 4 | 12/15/2001 | |
While driving 40mph and without warning, engine stalled, consumer applied brakes and vehicle did not stop resulting in a collision, which totaled vehicle. prior to the accident vehicle shut off 4 times, dealer replaced battery, alternator, plugs/wires, and starter but this did not correct the problem. | |||
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||
11/05/2000 | 0 | ||
Generator ignited a spark, and coating on roof caught on fire. mechanic said that it looked like ther was problem with harness connector. consumer felt its was a manufacturer' defect. *ak | |||
07/13/1993 | 8 | ||
Alternator replaced eight times due to shorting out. mjs | |||
Replace alternator 8 different time, possible due to design flaw causing it to short out. | |||
12/01/1996 | 1 | ||
Alternator wires burnt. | |||
08/10/1996 | |||
Electrical short, causing the alternator cable to melt.ak | |||
06/25/1996 | 5 | ||
Alternator failed, causing harness to melt 5 times. *sd | |||
11/22/1995 | |||
The vehicle has had two fires resulting from the alternator switch. please describe. tt | |||
10/05/1992 | |||
Alternator wiring harness is burning which causes the alternator to go bad. please describe. tt | |||
06/01/1995 | |||
Heavy wire 3 prong connector plug caught on fire, replace alternator and battery. tt | |||
ELECTRICAL SYSTEM - IGNITION | |||
10/13/2004 | 83000 | 7 | 06/11/2001 |
Car has repeatable problem of not starting...have had it towed, due to this, numerous times, spent thousands of dollars trying to get it fixed, etc. only to discover that it has two ignition defects...potentially... since the car was not new when i bought it 3 years ago, i have no recourse but to bear the cost of repairs myself. i am outraged that ford got away with not recalling these vehicles!!! | |||
08/01/2000 | 04/01/2000 | ||
No summary | |||
11/01/1998 | 3 | 11/01/1998 | |
Replaced seatbelt and they do the same thing lock in the buckle position when wife put in ditch she had to squeze to get outeven when open door would not release the heater control has been burnt 3 times and currently is burnt again then the ignition has been replaced under a recall and that dings now when the key isn't even in it nice recall i went to the dealer about the seatbelts they told me it would cost about 300.00 per door to fix my wife was quite upset about it wrote ford motor a letter they never ecnolledge it. she won't even let me replace the engine in it cause she says she will not drive that car that could go up in flames or doesn't have seatbelt that work cause ford don't know how to make something that works proper she feels the ford company has done nothing but endangered many adults and childrens lives with these problems and says someone otta take control over this matter sincerely darrell and laura johnson. *ak | |||
1 | 04/30/1999 | ||
96 v 071 000/electrical system ignition: vehicle would stall while driving at highway speed or while pulling off from a stop position. manufacturer was notified, and informed consumer that vehicle was covered under that recall. but, dealer refused to honor recall. *ak *slc | |||
07/13/2001 | 5 | 05/01/1990 | |
I had to have my ignition modual replaced because my car would stall on me while going down the road. i read in the paper today that ford is fighting the recall on this exact problem. i have e-mailed ford in hopes of rectifing this situation, but thought i would also contact you for help. thank you for your help.*ak | |||
05/01/2000 | 1 | 04/01/1999 | |
While making a left hand turn consumer came to stop and vehicle stalled resulting in being hit on left rear door and vehicle spun around. consumer was told by mechanic rear axle was bent due to this accident. consumer contacted ford, and was informed that they would pay for damage to vehicle, apprximately $1300. vehicle has been stalling for the last 30000 miles. *ak the consumer says the estimate for damage to the vehicle is much more. the consumer also states that this vehicle was lemon and had changed hands five times. *yh | |||
1 | 02/01/1998 | ||
This vehicle has a stalling problem when coming to a stop sign or intersection. dealer has been contacted.*ak the consumer says that ignition system was replaced and there is no more stalling problem. *yh | |||
04/30/2000 | 4 | ||
While driving about 20 mph engine stalled without prior warning while making a left turn, and was side crashed by another vehicle from the upcoming traffic. currently, problem was coming back. 2 transmissions have been replaced on this vehicle. vehicle experiencing an oil leak. *ak *slc | |||
08/01/2000 | 04/01/2000 | ||
No summary | |||
08/25/2000 | 5 | 04/01/1990 | |
Veh. stops unexpectedly (california recall problem symptoms) while climbing in mountains and under warm conditions. after a few minutes, veh. will run again but then repeats the stopping problem. engine stops and power-assisted braking/steering is lost in highway driving. *ak | |||
Vehicle will stall intermittently. vehicle will shut off which could cause accident.consumer had igniton idle sensor replaced every year .*ak | |||
11 | |||
Stalls without warning. once on expressway, most on 4 lane 55 mph roads. many situations could have caused serious accidents. after sitting at roadside for about 2 hours it would start right up. tried a number of remedies before hearing of the possible recall in california. it was a used functional car so we did all of the do it yourself remedies like dry gas, new starter, etc. all of the situations in the articles about the recalls described my instances to a t.*ak | |||
08/01/2000 | |||
There were safety recalls on this vehicle that were for the ignition switch. how do i find out if this recall was ever done and the switch replaced? *ak | |||
04/01/1997 | |||
Car contantly stalls, have had service 3 times to correct, nothing works, no one knows what is wrong. | |||
No parts, the consumer received a recall notice, the dealer said that he would call or send a letter when the parts are in and it has been a month and still no parts. please explain in detail *ak | |||
08/04/1995 | |||
The vehicle quits while driving. it will not run again unless you let it sit. happens when its hot outside. please describe. tt | |||
06/15/1990 | 1 | ||
Intermittent stalling. *ak | |||
06/12/1995 | 1 | ||
While driving, low to high speeds, engine suddenly shuts down, causing loss of power steering and brakes, no prior warning. tt | |||
01/04/1993 | 4 | ||
Ignition wires corroded at coil connection, preventing vehicle from starting. *skd | |||
ELECTRICAL SYSTEM - IGNITION - SWITCH | |||
1 | |||
Ignition switch failed. mjs | |||
04/10/1999 | |||
Key broke off in the ignition switch, and consumer couldn't turn the steering wheel which locked up. consumer had to call out a lock smith to get the key out of the ignition. *ak | |||
10/15/1998 | |||
Ignition switch will start the car, but when the switch is returned to the original position, it will not keep the car running. repairs done to previous recall 95s28 on 12/17/96. dealer and manufacturer contacted, and cannot repair the work because of time frame limitations on recall. *ak | |||
Ignition switch had to be repaired earlier, after breaking. | |||
02/22/1998 | 0 | ||
Vehicle parked in driveway. horn was blaring & owner looked out window & noticed vehicle in flames. was told fire occurred near ignition switch area. called dealer & informed under recall (#96v071000). will repair ignition switch & wiring harness only & nothing else. owner never received notice. had owned vehicle since new. *ak | |||
07/12/1996 | 1 | ||
Ignition switch fire. | |||
01/11/1997 | |||
Electrical:ignition switch recall#96v071. vehicle parked in driveway, walked about 6 houses down .people started screaming that vehicle was smoking,suddenly burst into falmes. vehicle totaled. *ak | |||
06/20/1996 | 1 | ||
Owner states that her vehicle caught on fire while it was parked ,she then received a recall notice for the ignition switch, also the fire department said that it started from the passenger's side. *ak *jb | |||
07/12/1996 | 1 | ||
Ignition switch fire. | |||
06/03/1994 | 1 | 10/09/1989 | |
Was driving vehicle, stopped at train station to meet someone, another person came in the station to report vehicle was on fire. *ak | |||
07/16/1996 | 1 | 11/10/1989 | |
While driving, an electrical short in the ignition switch caused the vehicle to catch on fire in the steering column. *ak recall 96v071 was never received, consumer heard of recall through a customer service rep. *slc | |||
02/02/1996 | 2 | ||
Ignition switch shorted, causing fire. *dh | |||
03/19/1996 | |||
Vehicle caught on fire while siting in the driveway,caused by ignition switch. please describe. *ak | |||
10/21/1995 | |||
Under the dash fire, steering column, electrical short in ignition switch, vehicle was parked for period of 9 hrs. tt | |||
ELECTRICAL SYSTEM - WIRING | |||
08/02/2004 | 1 | ||
Just after pulling into the driveway, the consumer smelled smoke . he opened the hood and noticed the top of the alternator plug was burning followed by wiring burning across to the battery. the terminal block on the left fender began burning and melting. *jb *nm | |||
03/19/1995 | 1 | 04/07/1990 | |
Electrical short under between seats console caused vehicle fire. | |||
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||
12/26/1998 | 1 | ||
Improper wire repairs cause the vehicle engine to catch on fire. | |||
While traveling smoke came from under the hood, vehicle was engulfed in flames, resulting in a fire. *ak | |||
12/05/1995 | |||
Underhood fire caused by faulty electrical wiring. lights go on/off while driving; impairs vision. tt | |||
ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||
06/26/1993 | 1 | ||
Wiring harness shorted, causing fire. *dh | |||
An electrical short caused the vehicle to catchon fire under the dash. please describe. *ak |