Bulletins

BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
ELECTRICAL SYSTEM
0417409/06/200410013116Malfunction indicator lamp (mil) illuminated - system lean diagnostic trouble codes (dtc's) - service tips. various models including 2004 f-series. *tt04/08/2005
0413612/27/200404251510009320Diagnostic trouble code b1342 (restraints control module (rcm) fault. *tt update. *tt09/22/2004
1789906/01/200410008272Malfunction indicator lamp (mil) on with multiple diagnostic trouble codes (dtcs). *tt07/23/2004
0411106/14/2004043110008252Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy.07/23/2004
047112/31/20040426210008201Warning indicators-parking aid-reverse sensing system (rss) and forward sensing system (fss)-false activation of warning tone-service tips. *mj update. *tt07/23/2004
1758503/01/200410007386Trailer tow electric brake switch/module connector may be difficult to locate in the vehicle and for certain 1999-2001 vehicles, the location is not clearly identified in the wiring diagram manual. *tt06/17/2004
0322301/26/2004043110007360Streamlined diagnostic procedure for vehicles with malfunction indicator lamp on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy. *tt06/16/2004
1727708/01/20041796510004921Beeping sound from the instrument panel when driving at/over 75 mph, traction control off indicator illuminate when vehicle is not equipped with traction control, and/or diagnostic trouble code b2477 (module configuration failure) stored in01/20/2004
0320310/13/2003039810004886Malfunction indicator lamp illuminated with diagnostic trouble codes (dtcs) p0442, p0455, p0456, p0457 or p1442 or a check fuel cap lamp illuminated with dtc p0457 for the evaporative emission system. *tt01/14/2004
0318109/15/200310004027Remote keyless entry (rke) - service tips. *tt11/14/2003
035403/17/200310001919Air bag warning lamp illuminated with the diagnostic trouble code b2290. *tt *jb07/25/2003
1571003/01/2002636348Information on vehicles with programmable modules. *tt11/07/2002
1543911/01/2001630460Concerns with the headlamps that turn on and a blower motor that will operate with the ignition switch in the off position. *tt04/17/2002
ELECTRICAL SYSTEM - BATTERY
024503/04/2002636065Information regarding discharged battery charging service tips and guidelines. *tt11/05/2002
0213907/08/2002636000Battery drain service tips. *tt11/04/2002
ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS
1519408/01/2001624604Some vehicles may exhibit a discharged battery after extended parking, over 30 days, if so, pull power drain full fuse number 6. *yd11/08/2001
ELECTRICAL SYSTEM - IGNITION - ANTI-THEFT CONTROLLER
1544011/01/2001630366Some vehicles may exhibit intermittent uncommanded activation of the perimeter anti-theft system. *tt04/16/2002
1496706/01/2001622759Some vehicles may exhibit intermittent uncommanded activation of the perimemter anti-theft system. *tt10/22/2001
016204/02/2001619266Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt05/22/2001
ELECTRICAL SYSTEM - IGNITION - MODULE
1587205/01/2002637728Subject regarding diagnostic trouble code p0156 - h02 / catalyst monitor sensor (cms) circuit failure) contamination. *tt12/04/2002
1582804/01/2002637571Some vehicles may exhibit diagnostic trouble code b1213, b1342, b1601, b2431. *tt12/03/2002
1544211/01/2001630464Some vehicles equipped with 3.8l engines may exhibit a diagnostic trouble code p0460 incontinuous memory. *tt04/17/2002
ELECTRICAL SYSTEM - IGNITION - SWITCH
01211310/29/2001627774Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control02/22/2002
ELECTRICAL SYSTEM - WIRING
0324212/08/200310008273Trailer tow service kit - service tip. *tt07/26/2004
ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH
1535010/01/2001630266Exhibiting instrument panel beeping sound, trac-control off lamp on, and code b2477 stored in the instrument cluster module. *tt04/15/2002

Investigations

NHTSA IDManufacturerDate openDate closeSubjectRecall campaign
ELECTRICAL SYSTEM
EA08021FORD MOTOR COMPANY09/17/200810/14/2009ENGINE COMPARTMENT FIRES09V399000
 Ea08-021 is closed with ford's actions in recall 09v-399 recalling approximately 4.5 million vehicles equipped with texas instruments speed control deactivation switches (scds).with this recall ford has now recalled all of the approximate 16 million ford model vehicles that were manufactured from my 1992 through 2003 with a texas instruments scds.nhtsa will continue to monitor the recalled vehicles to ensure remedies installed by ford tomitigate the potential for scds related fires are effective.the agency reserves the right to take further action if warranted by the circumstances.see attached closing report for further details.
PE08035FORD MOTOR COMPANY05/13/200809/17/2008ENGINE COMPARTMENT FIRES
 Odi has received 134 consumer complaints, 285 manufacturer complaints, and 137 manufacturer warranty claims alleging incidents of engine compartment fire in model year (my) 1995 thru 2003 ford windstar vehicles.two of the odi complaints allege the fires caused structural damage to the complainant's home.of the 134 odi complaints, 36 allege the fire occurred while the vehicle was parked, 72 allege the fire occurred while the vehicle was running and 26 of the complaints do not specify if the vehicle was running or not.further review of the odi complaints shows that 72 allege that the speed control deactivation switch (scds) caused the fire and 10 allege that the scds leaked brake fluid on to the abs module resulting in the fire.there were 52 that did not identify a cause or that identified miscellaneous other causes.odi has also received 89 complaints ( not counted in this resume) alleging that the scds developed a brake fluid leak.thirteen of these complaints say that the leak at the scds resulted in braked fluid reaching the abs module.this pe has been upgraded to an engineering analysis (ea) to further evaluate the cause of the fires and assess the scope, frequency, and safety consequences of the alleged defect.
ELECTRICAL SYSTEM - WIRING
PE08035FORD MOTOR COMPANY05/13/200809/17/2008ENGINE COMPARTMENT FIRES
 Odi has received 134 consumer complaints, 285 manufacturer complaints, and 137 manufacturer warranty claims alleging incidents of engine compartment fire in model year (my) 1995 thru 2003 ford windstar vehicles.two of the odi complaints allege the fires caused structural damage to the complainant's home.of the 134 odi complaints, 36 allege the fire occurred while the vehicle was parked, 72 allege the fire occurred while the vehicle was running and 26 of the complaints do not specify if the vehicle was running or not.further review of the odi complaints shows that 72 allege that the speed control deactivation switch (scds) caused the fire and 10 allege that the scds leaked brake fluid on to the abs module resulting in the fire.there were 52 that did not identify a cause or that identified miscellaneous other causes.odi has also received 89 complaints ( not counted in this resume) alleging that the scds developed a brake fluid leak.thirteen of these complaints say that the leak at the scds resulted in braked fluid reaching the abs module.this pe has been upgraded to an engineering analysis (ea) to further evaluate the cause of the fires and assess the scope, frequency, and safety consequences of the alleged defect.
EA08021FORD MOTOR COMPANY09/17/200810/14/2009ENGINE COMPARTMENT FIRES09V399000
 Ea08-021 is closed with ford's actions in recall 09v-399 recalling approximately 4.5 million vehicles equipped with texas instruments speed control deactivation switches (scds).with this recall ford has now recalled all of the approximate 16 million ford model vehicles that were manufactured from my 1992 through 2003 with a texas instruments scds.nhtsa will continue to monitor the recalled vehicles to ensure remedies installed by ford tomitigate the potential for scds related fires are effective.the agency reserves the right to take further action if warranted by the circumstances.see attached closing report for further details.

Consumer Complaints

Fail datemilesoccurencesPurchase date
ELECTRICAL SYSTEM
07/13/2012150000107/21/2011
 7/21/2011 bought van from private party. recall completed in march of 2011 regarding back axle. on 7/13/2012 8pm, my 18yr old son, while driving home from lacrosse practice, nearly killed. upon pulling out onto the main road, he lost all controls, no steering, no brakes and no power. he coasted and prayed it would stop. i arrived, we called aaa. flatbed to my home driver could not believe his eyes. the engine had fallen out. 7/16/12 called ford in mich and spoke to rep. to be towed 13 miles away to route 23 auto at our expense. really? route23 wanted nothing to do with me (they did recall). went back and forth then per rt23 it will be a month until we can look at it getting know where. 7/18-22 borrowed friend car for tournament. 8/1/12 called magarino ford and with great concern had a flatbed that night. this tow truck driver could not believe it. fluids raced out and double stabilized for engine sliding during transport. 8/2/12 magarino called 9am, pictures sent to ford and awaiting reply. 8/5/12 t/c from m stating ford refuses to buy back and sending a subframe. you mean a recalled one? magarino caught in middle i questioned whether he would put his children in this van. he softly replied, no what am i to do, out of work 2 years, single parent with no car to find work. 8/8/12 i questioned ford why this van ever left rt 23 auto, according to researched paper a part was waiting on. you mean to tell me that upon this fixed axle nobody noticed the subframe was rotted from inside out causing the engine to fall out the next summer nearly killing my son! but they signed it was fine! really? now we have case # 1373091992 8/10/12 picked up van. broke= a/c, r-window, heater engine, airbag, brake light on, runs hot steering= thumps makes noise (full fluid) skip gears, sways, barely can get up a hill. 11yr old scared to drive in it
05/16/20111080001
 The issue is caused by heat in the abs (anti-lock brake system) ecm (electronic control module) (2c219) module causing expansion of a large aluminum plate (heat sink) in the ecm which is attached to the ecm main circuit board at all points. the expansion occurs when the unit gets warm especially in the summer months and causes intermittent electrical connection in the unit because the fragile board is being stretched and malformed. the code most commonly scanned by professional mechanics is code c1185. seen by us owners as a yellow abs brake light. *tr
05/16/2011108000
 The issue is caused by heat in the abs (anti-lock brake system) ecm (electronic control module) (2c219) module causing expansion of a large aluminum plate (heat sink) in the ecm which is attached to the ecm main circuit board at all points. the expansion occurs when the unit gets warm especially in the summer months and causes intermittent electrical connection in the unit because the fragile board is being stretched and malformed. the code most commonly scanned by professional mechanics is code c1185. seen by us owners as a yellow abs brake light.
06/14/20111080001
 Abs brake light on brake light on the (mostly unserviceable) ecu master relay has a bad soldier joint which fails prematurely and causes the abs light and dtc c1185. it also causes the enhanced abs braking system to become inoperable. *tr
06/14/2011108000
 Abs brake light on brake light on the (mostly unservicable) ecu master relay has a bad soldier joint which fails prematurely and causes the abs light and dtc c1185. it also causes the enhanced abs braking system to become inoperable.
01/03/20121514571
 My abs light comes on and my abs doesn't work! also my vehicle has an issue with starting. it could happen once a week or once a month. it is so weird, i have replaced the starter, the sensors. tested everything else and nothing is bad. don't know what else to replace. *tr
08/27/20101080001
 One year ago, both the abs light and the brake light were turned on. sometimes they are on and off frequently. *tr
01/03/20121514571
 My abs light comes on and my abs doesn't work! also my vehicle has an issue with starting. it could happen once a week or once a month. it is so weird, i have replaced the starter, the sensors. tested everything else and nothing is bad. don't know what else to replace. *tr
08/27/20101080001
 One year ago, both the abs light and the brake light were turned on. sometimes they are on and off frequently. *tr
01/03/2012151457
 My abs light comes on and my abs doesnt work! also my vehicle has an issue with starting. it could happen once a week or once a month. it is so weird, i have replaced the starter, the sensors. tested everything else and nothing is bad. dont know what else to replace.
08/27/20101080001
 One year ago, both the abs light and the brake light were turned on. sometimes they are on and off frequently. *tr
08/27/2010108000
 One year ago, both the abs light and the brake light were turned on. sometimes they are on and off frequently.
08/08/20121130001
 My brakes and abs light stays on even after repairing brakes my abs system is not working, one day while raining i try to stop my vehicle and it kept on going. *tr
08/08/2012113000
 My brakes and abs light stays on even after repairing brakes my abs system is not working, one day while raining i try to stop my vehicle and it kept on going.
11/10/2010770001
 Abs, brake light and check engine light all on at the same time. vehicle shakes like it is going to cut off. despite numerous attempts at repairs, still does it as of today (2012). *tr
02/01/20121
 My abs and brake lights come on and go off randomly. i've had my brakes and fluids checked and everything is fine. *tr
11/10/201077000
 Abs, brake light and check engine light all on at the same time. vehicle shakes like it is going to cut off. despite numerous attempts at repairs, still does it as of today (2012)
02/01/20121
 My abs and brake lights come on and go off randomly. i've had my brakes and fluids checked and everything is fine. *tr
02/01/2012
 My abs and brake lights come on and go off randomly. i've had my brakes and fluids checked and everything is fine.
06/01/20101
 These lights stay on even after repairs are done. they go off for a couple days and then come back on. this has been going on for at least 2 years. i also have electrical problem with my speedometer and gauges. i also have been having a problem with my fuel vacuum causing the gas to spill out when pumping and tank is not full. *tr
06/01/2010
 These lights stay on even after repairs are done. they go off for a couple days and then come back on. this has been going on for at least 2 years. i also have electrical problem with my speedometer and gauges. i also have been having a problem with my fuel vacuum causing the gas to spill out when pumping and tank is not full.
01/11/2011110000
 Tl* the contact owns a 2001 ford windstar. the contact stated that while driving 70 mph, the vehicle stalled. the contact stated that there were no lights illuminated on the instrument panel. the vehicle was safely maneuvered to the shoulder and towed home. the vehicle was then taken to an authorized dealer and the contact was also informed that the actuators for the door locks were bad and needed to be replaced. the vehicle was repaired, but the failure recurred. the manufacturer was not notified. the failure mileage was 110,000. the vin was unavailable.
05/03/2012670001
 Just recently, in the past couple months, the abs lights go on intermittently on the dashboard, warning that there is a problem. we took it to the ford dealership, and they said it may need a new ecu or computer module, but they said it was safe to use. however, the manual says when the lights are on, the abs system and traction control are disabled... there seems to be a recall, but no one at the dealership mentioned any issue. it seems strange for a car with 68,000 miles to have this go out - we want to make sure it is not a covered item before paying $ 1,400 for a new part. thank you. *tr
01/11/2011110000
 Tl-the contact owns a 2001 ford windstar. the contact stated that while driving 70 mph, the vehicle stalled. the contact stated that there were no lights illuminated on the instrument panel. the vehicle was safely maneuvered to the shoulder and towed home. the vehicle was then taken to an authorized dealer and the contact was informed that the actuators for the door locks were bad and needed to be replaced. the vehicle was repaired, but the failure recurred. the manufacturer was not notified. the failure mileage was 110,000. the vin was unavailable. sm.
05/03/2012670001
 Just recently, in the past couple months, the abs lights go on intermittently on the dashboard, warning that there is a problem. we took it to the ford dealership, and they said it may need a new ecu or computer module, but they said it was safe to use. however, the manual says when the lights are on, the abs system and traction control are disabled... there seems to be a recall, but no one at the dealership mentioned any issue. it seems strange for a car with 68,000 miles to have this go out - we want to make sure it is not a covered item before paying $ 1,400 for a new part. thank you. *tr
01/11/2011110000
 Tl- the contact owns a 2001 ford windstar. the contact stated that while going 70 mph, the vehicle stalled. the contact stated that there were no light illuminated on the instrument panel. the contact stated that he pulled the vehicle over to the side of the road and had to have the vehicle towed to the his residence. the contact stated that he took the vehicle to a dealer for inspection and they informed that the actuators for the door locks were bad and needed to be replaced. the vehicle was repaired but the failure recurred. the manufacturer was not notified. the failure mileage was 110,000. the vin was unavailable. ap
05/03/2012670001
 Just recently, in the past couple months, the abs lights go on intermittently on the dashboard, warning that there is a problem. we took it to the ford dealership, and they said it may need a new ecu or computer module, but they said it was safe to use. however, the manual says when the lights are on, the abs system and traction control are disabled... there seems to be a recall, but no one at the dealership mentioned any issue. it seems strange for a car with 68,000 miles to have this go out - we want to make sure it is not a covered item before paying $ 1,400 for a new part. thank you. *tr
05/03/201267000
 Just recently, in the past couple months, the abs lights go on intermittently on the dashboard, warning that there is a problem. we took it to the ford dealership, and they said it may need a new ecu or computer module, but they said it was safe to use. however, the manual says when the lights are on, the abs system and traction control are disabled... there seems to be a recall, but no one at the dealership mentioned any issue. it seems strange for a car with 68,000 miles to have this go out - we want to make sure it is not a covered item before paying $ 1,400 for a new part. thank you.
06/28/2012
 Abs light, air bag light and brake light keeps coming back on while car is on.
11/10/200579018
 The minivan is equipped with a button on the gear shift. this button enables you to shift out of overdrive when you do not want the vehicle to be in overdrive mode. about this time the fuse in the fuse box would blow. replaced the fuse a number of times but the problem is still there. the fuse may last for 5 to 10 miles and then it would blow. tried a larger amp fuse but it would also blow. transmission will leave the overdrive only if you accelerate going up a hill.
05/18/200538800
 The abs and the red brake light came on on the instrument panel. had the computer or something reset a couple of times but the lights keep coming on. been doing this for a number of years.
06/28/2012
 Abs light, air bag light and brake light keeps coming back on while car is on.
11/10/200579018
 The minivan is equipped with a button on the gear shift. this button enables you to shift out of overdrive when you do not want the vehicle to be in overdrive mode. about this time the fuse in the fuse box would blow. replaced the fuse a number of times but the problem is still there. the fuse may last for 5 to 10 miles and then it would blow. tried a larger amp fuse but it would also blow. transmission will leave the overdrive only if you accelerate going up a hill.
06/28/2012
 Abs light, air bag light and brake light keeps coming back on while car is on.
11/10/200579018
 The minivan is equipped with a button on the gear shift. this button enables you to shift out of overdrive when you do not want the vehicle to be in overdrive mode. about this time the fuse in the fuse box would blow. replaced the fuse a number of times but the problem is still there. the fuse may last for 5 to 10 miles and then it would blow. tried a larger amp fuse but it would also blow. transmission will leave the overdrive only if you accelerate going up a hill.
05/18/200538800
 The abs and the red brake light came on on the instrument panel. had the computer or something reset a couple of times but the lights keep coming on. been doing this for a number of years.
06/28/2012
 Abs light, air bag light and brake light keeps coming back on while car is on.
11/10/200579018
 The minivan is equipped with a button on the gear shift. this button enables you to shift out of overdrive when you do not want the vehicle to be in overdrive mode. about this time the fuse in the fuse box would blow. replaced the fuse a number of times but the problem is still there. the fuse may last for 5 to 10 miles and then it would blow. tried a larger amp fuse but it would also blow. transmission will leave the overdrive only if you accelerate going up a hill.
05/18/200538800
 The abs and the red brake light came on on the instrument panel. had the computer or something reset a couple of times but the lights keep coming on. been doing this for a number of years.
11/10/200579018
 The minivan is equipped with a button on the gear shift. this button enables you to shift out of overdrive when you do not want the vehicle to be in overdrive mode. about this time the fuse in the fuse box would blow. replaced the fuse a number of times but the problem is still there. the fuse may last for 5 to 10 miles and then it would blow. tried a larger amp fuse but it would also blow. transmission will leave the overdrive only if you accelerate going up a hill.
05/18/200538800
 The abs and the red brake light came on on the instrument panel. had the computer or something reset a couple of times but the lights keep coming on. been doing this for a number of years.
05/16/2012289221
 At approximately 16:45 after driving 6 miles that day, the windstar van was stopped and the ignition key turned off. the delivery driver went inside his destination for about 5 minutes. while loading his cargo, he smelled smoke. looking up, he noticed flames coming out of the engine compartment between the hood and the windshield wiper plastic shielding. using an onboard 5 lb fire extinguisher, he attempted to extinguish the flames but to no avail. he dialled 9-1-1 on his phone. employees at his destination also noticed the fire, and contacted the local fire department as well. the fire department extinguished the flames with severe damage to the rear portion of the engine, the fire wall, brake cylinder and glass windshield. the ambient temperature that day was in the 70 degrees range, windows were down in the van, and the a/c system was not in use.
11/15/201189000
 Brake and abs light go off and on could smell hot copper wire ....code like 11 brake codes all due to abs module
05/16/2012289221
 At approximately 16:45 after driving 6 miles that day, the windstar van was stopped and the ignition key turned off. the delivery driver went inside his destination for about 5 minutes. while loading his cargo, he smelled smoke. looking up, he noticed flames coming out of the engine compartment between the hood and the windshield wiper plastic shielding. using an onboard 5 lb fire extinguisher, he attempted to extinguish the flames but to no avail. he dialled 9-1-1 on his phone. employees at his destination also noticed the fire, and contacted the local fire department as well. the fire department extinguished the flames with severe damage to the rear portion of the engine, the fire wall, brake cylinder and glass windshield. the ambient temperature that day was in the 70 degrees range, windows were down in the van, and the a/c system was not in use.
11/15/201189000
 Brake and abs light go off and on could smell hot copper wire ....code like 11 brake codes all due to abs module
11/12/2011111698
 Abs warning light and brake warning light come on intermittently, after send in for the recall on speed control system modification... until to abs bulb blowed up... but parking brake light remained on... send it back to dealer... ask the service advisor why my both warning light on when i drive... and now my abs light off and parking brake light remain on and the service advisor told me your abs light never light out when turn on the ignition switch mean that this vehicle without abs thank you for the reply given by ford dealer service advisor of he best knowledge....i will not sending my vehicle for any recall in the future.....
05/09/200895000
 A few months after i bouht the car (may 2008) the abs and brake light started to come on, intermittently, every couple of days. it would come on when i went around a sharp curve or hit a pothole. i took the car to 3 different mechanics, when the lights were not on (no error codes) and when the lights were on (every abs error code came up). i was told by all 3 mechanics that the abs sensor board needed to be replaced. the part was going to cost over $300 plus labor to repair. they also told me that the car was ok to drive but that when the lights came on my abs was not working and that i should be careful when driving in rain or when road conditions were slick because i would need extra time to prepare for a full stop. i have researched on the internet for the same problem and found that there were many others who were experiencing the same problem and have tried many different fixes with no resolution, including the replacement of the abs sensor board. what do i need to do to ensure that my abs brakes will work correctly?
03/29/2012
 I currently keep getting grunting/popping/mouning noise from the front suspension when turning -brakeing-starting to move car forward . already replaced the sway bar links and bushings but the noise still comes and goes. also my brake-&-abs lights comes on and off for no reason. and the locks on the doors work when they want too. just had inspection done again 3 weeks ago but they can not find the problems. talk with ford about the noise to try to find out if there is any danger of a crash because of this and i keep getting the run around.
02/23/2010
 Vehicle was purchased in november 2009. i first began having problems with the abs/break light coming on, in febuary 2010. the next incident was the power windows on drivers side and back window would not role down. the next incident was the heater wont work. a recall and repair was done on the rear subframe 11s16 in april of 2010.vehicle repair was not complete now taking in for front under carriage repair on wed 21,2012.
02/01/201275000
 Driving on highway, the brakes slammed on, almost rear ended. when i got home by driving slowly, i noticed moisture and brake fluid was in the abs pump module, thank god my children were not in our so calledfamily van.
01/02/2012149750
 Abs, traction control, and brake lights come on shortly after starting the car. abs, traction control are 'off''. safety issue when driving in snow. this problem has occurred 3 times now,over last 2 years, each time i am told its a brake sensor, or the abs sensor. i pay several hundred each time to get it replaced, but problem returns within 6 months. concern is safety- abs and traction control critical in northern ohio area in heavy snow area- please look into this.
08/29/2011106000
 Tl* the contact owns a 2001 ford windstar. the contact stated that after having repairs under nhtsa campaign id number: 09v399000 (vehicle speed control), the vehicle experienced major electrical problems and brake fluid leaking. the fluid leaked on the abs modules, causing the electronic components to have a short, including the brakes. the contact took the vehicle to the dealer where the dealer advised that the abs module needed to be replaced. the failure mileage was 106,000. the vin was not available.
08/29/2011106000
 Tl-the contact owns a 2001 ford windstar. the contact stated that after having repairs under nhtsa campaign id number: 09v399000 (vehicle speed control), the vehicle experienced major electrical problems and brake fluid leaking. the fluid leaked on the abs modules, causing the electronic components to have a short, including the brakes. the contact took the vehicle to the dealer where the dealer advised that the abs module needed to be replaced. the failure mileage was 106,000. the vin was not available. kmj
08/29/2011106000
 Tl-the contact owns a 2001 ford windstar. the contact stated after having a nhtsa campaign i.d. 09v399000 (vehicle speed control) the vehicle experienced major electrical problems due brake fluid leaking. the fluid leaked on the abs modules causing the electric components to have a short including the brakes. this causes the vehicle to brake improperly and increases the risk of a crash and/or fire. the contact took the vehicle to the dealer. the dealer stated the abs module needed to be replaced. the failure mileage was 106,000. jo
09/01/2011160000
 While driving, the speedometer ,the odometer,the tachometer all stopped working.the abs light came on,the red brake light came on,and the o/d off light continues to flash.it is extremely difficult to operate this vehicle without at least a speedometer and i hope the brakes do not fail. this all occurred shortly after the brake master cylinder switch was replaced.
08/31/2011
 I turned in my ford windstar on to the john west ford diler , the abs, and brake lights came on 3 days before to brought it for been diagnosed. 2 days after they gave me an estimate for $ 2400.00 dollars. that really surprise me and i answer no thanks do not fix my car. they put my van together and since that moment my van i didn't start again is like a death . they said the pcm and abs module got burned. i think they made a mistake and kill my van pcm but i cant proved. i was reading the abs recall about and sounds like there is nothing releated wiht the pcm module. any way they sent my van back home onto a town truck and at this moment a can't find the problem yet. oh i almost forgot some for sure they charge me $ 200.00 for diagnosis. if you want to confirm my history you can call mr; tony albaniano telephone #; 775-745-1889 775-747-6923 reno nv.
09/01/2011160000
 While driving, the speedometer ,the odometer,the tachometer all stopped working.the abs light came on,the red brake light came on,and the o/d off light continues to flash.it is extremely difficult to operate this vehicle without at least a speedometer and i hope the brakes do not fail. this all occurred shortly after the brake master cylinder switch was replaced.
08/31/2011
 I turned in my ford windstar on to the john west ford diler , the abs, and brake lights came on 3 days before to brought it for been diagnosed. 2 days after they gave me an estimate for $ 2400.00 dollars. that really surprise me and i answer no thanks do not fix my car. they put my van together and since that moment my van i didn't start again is like a death . they said the pcm and abs module got burned. i think they made a mistake and kill my van pcm but i cant proved. i was reading the abs recall about and sounds like there is nothing releated wiht the pcm module. any way they sent my van back home onto a town truck and at this moment a can't find the problem yet. oh i almost forgot some for sure they charge me $ 200.00 for diagnosis. if you want to confirm my history you can call mr; tony albaniano telephone #; 775-745-1889 775-747-6923 reno nv.
07/18/201179000
 The abs and brake light began coming on intermittantly a couple of months ago. it seems that the abs ecu module is the problem as multiple abs codes were read. now, two months later my cruise control no longer works. if you do the research online as well as in your complaint section for 2001 winstar it is an all too common problem. it seems to be a problem that was not addressed properly on an earlier recall by ford (09s09) which included a scds wiring harness replacement only caused by brake fluid leaking onto wiring and causing a potential fire hazard. many owners believe the fluid not only ran down the wiring continuing to run onto the abs connector causing parts to short out and fail and also onto the cruise control connector causing it to fail. i truly believe this is the reason all these abs modules are failing...it's amazing how many complaints with my same problem are on your website these are very expensive parts to replace (over $1000) plus labor. the absence of the abs system does cause braking problems and can cause the brakes to lock up and skid...this happened to me...just missed having a wreck! the connector to the cruise is also being effected causing it to fail as well. i think ford should be required to at least check these vehicle and replace these parts if they are found to be faulty before someone gets in an accident. they may have already.
09/01/2011160000
 While driving, the speedometer ,the odometer,the tachometer all stopped working.the abs light came on,the red brake light came on,and the o/d off light continues to flash.it is extremely difficult to operate this vehicle without at least a speedometer and i hope the brakes do not fail. this all occurred shortly after the brake master cylinder switch was replaced.
08/31/2011
 I turned in my ford windstar on to the john west ford diler , the abs, and brake lights came on 3 days before to brought it for been diagnosed. 2 days after they gave me an estimate for $ 2400.00 dollars. that really surprise me and i answer no thanks do not fix my car. they put my van together and since that moment my van i didn't start again is like a death . they said the pcm and abs module got burned. i think they made a mistake and kill my van pcm but i cant proved. i was reading the abs recall about and sounds like there is nothing releated wiht the pcm module. any way they sent my van back home onto a town truck and at this moment a can't find the problem yet. oh i almost forgot some for sure they charge me $ 200.00 for diagnosis. if you want to confirm my history you can call mr; tony albaniano telephone #; 775-745-1889 775-747-6923 reno nv.
07/18/201179000
 The abs and brake light began coming on intermittantly a couple of months ago. it seems that the abs ecu module is the problem as multiple abs codes were read. now, two months later my cruise control no longer works. if you do the research online as well as in your complaint section for 2001 winstar it is an all too common problem. it seems to be a problem that was not addressed properly on an earlier recall by ford (09s09) which included a scds wiring harness replacement only caused by brake fluid leaking onto wiring and causing a potential fire hazard. many owners believe the fluid not only ran down the wiring continuing to run onto the abs connector causing parts to short out and fail and also onto the cruise control connector causing it to fail. i truly believe this is the reason all these abs modules are failing...it's amazing how many complaints with my same problem are on your website these are very expensive parts to replace (over $1000) plus labor. the absence of the abs system does cause braking problems and can cause the brakes to lock up and skid...this happened to me...just missed having a wreck! the connector to the cruise is also being effected causing it to fail as well. i think ford should be required to at least check these vehicle and replace these parts if they are found to be faulty before someone gets in an accident. they may have already.
09/01/2011160000
 While driving, the speedometer ,the odometer,the tachometer all stopped working.the abs light came on,the red brake light came on,and the o/d off light continues to flash.it is extremely difficult to operate this vehicle without at least a speedometer and i hope the brakes do not fail. this all occurred shortly after the brake master cylinder switch was replaced.
08/31/2011
 I turned in my ford windstar on to the john west ford diler , the abs, and brake lights came on 3 days before to brought it for been diagnosed. 2 days after they gave me an estimate for $ 2400.00 dollars. that really surprise me and i answer no thanks do not fix my car. they put my van together and since that moment my van i didn't start again is like a death . they said the pcm and abs module got burned. i think they made a mistake and kill my van pcm but i cant proved. i was reading the abs recall about and sounds like there is nothing releated wiht the pcm module. any way they sent my van back home onto a town truck and at this moment a can't find the problem yet. oh i almost forgot some for sure they charge me $ 200.00 for diagnosis. if you want to confirm my history you can call mr; tony albaniano telephone #; 775-745-1889 775-747-6923 reno nv.
07/18/201179000
 The abs and brake light began coming on intermittantly a couple of months ago. it seems that the abs ecu module is the problem as multiple abs codes were read. now, two months later my cruise control no longer works. if you do the research online as well as in your complaint section for 2001 winstar it is an all too common problem. it seems to be a problem that was not addressed properly on an earlier recall by ford (09s09) which included a scds wiring harness replacement only caused by brake fluid leaking onto wiring and causing a potential fire hazard. many owners believe the fluid not only ran down the wiring continuing to run onto the abs connector causing parts to short out and fail and also onto the cruise control connector causing it to fail. i truly believe this is the reason all these abs modules are failing...it's amazing how many complaints with my same problem are on your website these are very expensive parts to replace (over $1000) plus labor. the absence of the abs system does cause braking problems and can cause the brakes to lock up and skid...this happened to me...just missed having a wreck! the connector to the cruise is also being effected causing it to fail as well. i think ford should be required to at least check these vehicle and replace these parts if they are found to be faulty before someone gets in an accident. they may have already.
07/25/2011125000
 Tl-the contact owns a 2001 ford windstar. the contact stated that the rear center brake lights would illuminate for hours at a time and would not shut off. the vehicle was inspected by an independent mechanic and the mechanic stated that the failure may be due to a sensor, but he was not sure. the vehicle was not repaired. the manufacturer was not made aware of the failure. the failure mileage was approximately 125,000. sm.
08/31/2011
 I turned in my ford windstar on to the john west ford diler , the abs, and brake lights came on 3 days before to brought it for been diagnosed. 2 days after they gave me an estimate for $ 2400.00 dollars. that really surprise me and i answer no thanks do not fix my car. they put my van together and since that moment my van i didn't start again is like a death . they said the pcm and abs module got burned. i think they made a mistake and kill my van pcm but i cant proved. i was reading the abs recall about and sounds like there is nothing releated wiht the pcm module. any way they sent my van back home onto a town truck and at this moment a can't find the problem yet. oh i almost forgot some for sure they charge me $ 200.00 for diagnosis. if you want to confirm my history you can call mr; tony albaniano telephone #; 775-745-1889 775-747-6923 reno nv.
07/18/201179000
 The abs and brake light began coming on intermittantly a couple of months ago. it seems that the abs ecu module is the problem as multiple abs codes were read. now, two months later my cruise control no longer works. if you do the research online as well as in your complaint section for 2001 winstar it is an all too common problem. it seems to be a problem that was not addressed properly on an earlier recall by ford (09s09) which included a scds wiring harness replacement only caused by brake fluid leaking onto wiring and causing a potential fire hazard. many owners believe the fluid not only ran down the wiring continuing to run onto the abs connector causing parts to short out and fail and also onto the cruise control connector causing it to fail. i truly believe this is the reason all these abs modules are failing...it's amazing how many complaints with my same problem are on your website these are very expensive parts to replace (over $1000) plus labor. the absence of the abs system does cause braking problems and can cause the brakes to lock up and skid...this happened to me...just missed having a wreck! the connector to the cruise is also being effected causing it to fail as well. i think ford should be required to at least check these vehicle and replace these parts if they are found to be faulty before someone gets in an accident. they may have already.
07/25/2011125000
 Tl-the contact owns a 2001 ford windstar. the contact stated that the rear center brake lights would illuminate for hours at a time and would not shut off. the vehicle was inspected by an independent mechanic and the mechanic stated that the failure may be due to a sensor, but he was not sure. the vehicle was not repaired. the manufacturer was not made aware of the failure. the failure mileage was approximately 125,000. sm.
07/18/201179000
 The abs and brake light began coming on intermittantly a couple of months ago. it seems that the abs ecu module is the problem as multiple abs codes were read. now, two months later my cruise control no longer works. if you do the research online as well as in your complaint section for 2001 winstar it is an all too common problem. it seems to be a problem that was not addressed properly on an earlier recall by ford (09s09) which included a scds wiring harness replacement only caused by brake fluid leaking onto wiring and causing a potential fire hazard. many owners believe the fluid not only ran down the wiring continuing to run onto the abs connector causing parts to short out and fail and also onto the cruise control connector causing it to fail. i truly believe this is the reason all these abs modules are failing...it's amazing how many complaints with my same problem are on your website these are very expensive parts to replace (over $1000) plus labor. the absence of the abs system does cause braking problems and can cause the brakes to lock up and skid...this happened to me...just missed having a wreck! the connector to the cruise is also being effected causing it to fail as well. i think ford should be required to at least check these vehicle and replace these parts if they are found to be faulty before someone gets in an accident. they may have already.
07/25/2011125000
 Tl-the contact owns a 2001 ford windstar. the contact stated that the rear center brake lights would stay on for hours at a time and woulkd not shut off. the vehicle was inspected by an independent mechanic and they advised him that it may be a sensor but he wasn't sure. the vehicle has not been repaired. the manufacturer was not contacted. the failure mileage was approximately 125,000. tb
07/04/2011110000
 The abs and brake lights on the dashboard light up and stay lit. they will only go off after the key is turned off. it took several trips to the ford dealership for them to diagnose these: perform q test abs system found multiple dtc's cmdtc c1185 abs pwr relay output circuit failure, c1194 lf outlet valve coild circuit fail, c1198 lf inlet valve coil circuit fail, c1210 rf outlet valave coil circuit fail, c1246 rr outlet valave coil circuit fail, c1250 lf inlet valve coil circuit fail, c1254 rr inlet valve coil circuit fail, c1446 brake switch circuit failure open or shorted to ground, u1262 scp data link fault, fail speed deactivation switch.
09/15/200990000
 Abs and brake lights willcome on after just a few minuts i start driving, is this a fire hazzard? plesa help.
07/04/2011110000
 The abs and brake lights on the dashboard light up and stay lit. they will only go off after the key is turned off. it took several trips to the ford dealership for them to diagnose these: perform q test abs system found multiple dtc's cmdtc c1185 abs pwr relay output circuit failure, c1194 lf outlet valve coild circuit fail, c1198 lf inlet valve coil circuit fail, c1210 rf outlet valave coil circuit fail, c1246 rr outlet valave coil circuit fail, c1250 lf inlet valve coil circuit fail, c1254 rr inlet valve coil circuit fail, c1446 brake switch circuit failure open or shorted to ground, u1262 scp data link fault, fail speed deactivation switch.
09/15/200990000
 Abs and brake lights willcome on after just a few minuts i start driving, is this a fire hazzard? plesa help.
07/04/2011110000
 The abs and brake lights on the dashboard light up and stay lit. they will only go off after the key is turned off. it took several trips to the ford dealership for them to diagnose these: perform q test abs system found multiple dtc's cmdtc c1185 abs pwr relay output circuit failure, c1194 lf outlet valve coild circuit fail, c1198 lf inlet valve coil circuit fail, c1210 rf outlet valave coil circuit fail, c1246 rr outlet valave coil circuit fail, c1250 lf inlet valve coil circuit fail, c1254 rr inlet valve coil circuit fail, c1446 brake switch circuit failure open or shorted to ground, u1262 scp data link fault, fail speed deactivation switch.
09/15/200990000
 Abs and brake lights willcome on after just a few minuts i start driving, is this a fire hazzard? plesa help.
07/04/2011110000
 The abs and brake lights on the dashboard light up and stay lit. they will only go off after the key is turned off. it took several trips to the ford dealership for them to diagnose these: perform q test abs system found multiple dtc's cmdtc c1185 abs pwr relay output circuit failure, c1194 lf outlet valve coild circuit fail, c1198 lf inlet valve coil circuit fail, c1210 rf outlet valave coil circuit fail, c1246 rr outlet valave coil circuit fail, c1250 lf inlet valve coil circuit fail, c1254 rr inlet valve coil circuit fail, c1446 brake switch circuit failure open or shorted to ground, u1262 scp data link fault, fail speed deactivation switch.
09/15/200990000
 Abs and brake lights willcome on after just a few minuts i start driving, is this a fire hazzard? plesa help.
07/22/2011120000
 Abs and brake light come on intemittently. will not pass inspection on a 2001 ford windstar van.
08/18/2007139000
 Tl-the contact owns a 2001 ford windstar. the contact stated that the constant-velocity joints on the passenger side were repeatedly replaced and the speedometer was also broken. the vehicle was taken to an authorized dealer, who stated that there were no recalls addressing the failures. the manufacturer was notified and offered no other assistance. the failure mileage was 139,000. sm.
08/18/2007139000
 Tl-the contact owns a 2001 ford windstar. the contact stated the cv joints on the passenger side has to be replaced constantly. the speedometer gauges was also broken. the vehicle was taken to the dealer who stated there are no recalls and ran a diagnostic test but the codes that are showing are the same failure codes each time the vehicle was taken to the dealer. the manufacturer was contacted and offered no other assistance. the failure mileage was 139,000. mw
07/30/201197000
 We have a 2001 ford windstar and we had recall 09s09 done. now we are having problems with the # 10 fuse blowing. which contributes to no a/c, no speedometer or odometer and o/d light flashing. also the abs light, brake light and traction control light come on all the time. i am afraid my van is going to catch on fire while i am travelling for soccer games. please look into this situation. there are many windstar owners in the same boat.
07/01/200995000
 Abs module malfuntios. abs warning lights. brake warning lights. traction control warning lights. was told by ford dealer that unit overheats - common problem.
03/03/2009100000
 Tl- the contact owns a 2001 ford windstar. the contact stated that while driving the air condition failed, the speedometer stayed stuck on zero and the abs light illuminated on the instrument panel. the dealer diagnosed that the vehicle would need a new electrical system. the manufacturer was contacted, but did not assist the contact with the failure. the failure was not remedied. the failure mileage was 100,000 and the current mileage was unavailable. nw
12/19/2000100
 Repeated failure and replacement of various parts of the electrical system including wiper motor, rear wiper motor, fuel pump, fuel pump fuses, alternator, repeated replacement of battery, repeated replacement of brake lights and light sockets and brake light switch, repeated failure and replacement of electric door locks, repeated replacement of coil wire, replacement of egr valve. constant stalling of vehicle in rain or humid weather. vehicle stall when air conditioner is in use. rough idle and stalling when vehicle is stopped and engine is running. all of these complaints have been constant and ongoing despite repeated replacement of electrical components since delivery of the vehicle in december of 2000.
06/26/2010
 Tl*the contact owns a 2001 ford windstar. the contact stated the sliding doors on the vehicle would not open. the contact took the vehicle to the dealer and was told the failure was a electrical. the vin was unknown. the current and failure mileage was unknown.
06/26/2010
 Tl- the contact owns a 2001 ford windstar. the contact stated the sliding doors on the vehicle do not open. the contact took the vehicle to the dealer and was told the failure was an electrical problem. the contact did not remember what the part was that failed. the vin was unknown. the current mileage and failure mileage was unknown. rl
04/07/2011110000
 My abs lights brake lights on the instrument panel come on and stay on and the odometer has no reading and the speedometer does not work. the vehicle drives fine.
06/26/2010
 Tl- the contact owns a 2001 ford windstar. the contact stated the sliding doors on the vehicle do not open. the contact took the vehicle to the dealer and was told the failure was an electrical problem. the contact did not remember what the part was that failed. the vin was unknown. the current mileage and failure mileage was unknown. rl
04/07/2011110000
 My abs lights brake lights on the instrument panel come on and stay on and the odometer has no reading and the speedometer does not work. the vehicle drives fine.
02/09/201163000
 I bought my windstar used from a dealership.i was soooo happy to finally have a safe and big enough vehicle for my family.after purchasing my van i had to have some work done witch estimated at 1,000.mechanic said it was normal wear and tear.after picking my van up from mechanic, i was driving home and the check engine light came on.i had several mechanics look the code up and they clear it(most likley what the dealership did to sell me the van).each time it is cleared it still comes back on,and about 2 weeks after the last cleared code my abs and brake lights keep coming on after only a few min of driving.i now see others are having the same problem as me.the new recall 01/27/11 i am sure that issue had not been fixed.i am pretty sure my subframe is bad too since i have been hearing a knocking noise for the last week.after reading everyone elses same issues with their windstar i promise i will not drive this vehicle and i am not going to go down without a fight.ford please note i will not allow your company to take advantage of me and put my family in danger for your money hungry company.you will be hearing from me!i thought i purchased a safe van and now i will be stuck in my house with no transportation! i will have my van taken to a ford dealership and it will not sit for six months due to there being no parts!i can not belive their can be sooo many recalls on this van and ford still thinks it is safe!
04/21/201187000
 Automobile leaking oil and smoking. engine, abs and brake lights constantly illuminated until they were removed by the dealer i informed him the vehicle would not pass inspection and told him of my saftey concerns regarding the same.
02/09/201163000
 I bought my windstar used from a dealership.i was soooo happy to finally have a safe and big enough vehicle for my family.after purchasing my van i had to have some work done witch estimated at 1,000.mechanic said it was normal wear and tear.after picking my van up from mechanic, i was driving home and the check engine light came on.i had several mechanics look the code up and they clear it(most likley what the dealership did to sell me the van).each time it is cleared it still comes back on,and about 2 weeks after the last cleared code my abs and brake lights keep coming on after only a few min of driving.i now see others are having the same problem as me.the new recall 01/27/11 i am sure that issue had not been fixed.i am pretty sure my subframe is bad too since i have been hearing a knocking noise for the last week.after reading everyone elses same issues with their windstar i promise i will not drive this vehicle and i am not going to go down without a fight.ford please note i will not allow your company to take advantage of me and put my family in danger for your money hungry company.you will be hearing from me!i thought i purchased a safe van and now i will be stuck in my house with no transportation! i will have my van taken to a ford dealership and it will not sit for six months due to there being no parts!i can not belive their can be sooo many recalls on this van and ford still thinks it is safe!
04/21/201187000
 Automobile leaking oil and smoking. engine, abs and brake lights constantly illuminated until they were removed by the dealer i informed him the vehicle would not pass inspection and told him of my saftey concerns regarding the same.
02/09/201163000
 I bought my windstar used from a dealership.i was soooo happy to finally have a safe and big enough vehicle for my family.after purchasing my van i had to have some work done witch estimated at 1,000.mechanic said it was normal wear and tear.after picking my van up from mechanic, i was driving home and the check engine light came on.i had several mechanics look the code up and they clear it(most likley what the dealership did to sell me the van).each time it is cleared it still comes back on,and about 2 weeks after the last cleared code my abs and brake lights keep coming on after only a few min of driving.i now see others are having the same problem as me.the new recall 01/27/11 i am sure that issue had not been fixed.i am pretty sure my subframe is bad too since i have been hearing a knocking noise for the last week.after reading everyone elses same issues with their windstar i promise i will not drive this vehicle and i am not going to go down without a fight.ford please note i will not allow your company to take advantage of me and put my family in danger for your money hungry company.you will be hearing from me!i thought i purchased a safe van and now i will be stuck in my house with no transportation! i will have my van taken to a ford dealership and it will not sit for six months due to there being no parts!i can not belive their can be sooo many recalls on this van and ford still thinks it is safe!
04/21/201187000
 Automobile leaking oil and smoking. engine, abs and brake lights constantly illuminated until they were removed by the dealer i informed him the vehicle would not pass inspection and told him of my saftey concerns regarding the same.
02/09/201163000
 I bought my windstar used from a dealership.i was soooo happy to finally have a safe and big enough vehicle for my family.after purchasing my van i had to have some work done witch estimated at 1,000.mechanic said it was normal wear and tear.after picking my van up from mechanic, i was driving home and the check engine light came on.i had several mechanics look the code up and they clear it(most likley what the dealership did to sell me the van).each time it is cleared it still comes back on,and about 2 weeks after the last cleared code my abs and brake lights keep coming on after only a few min of driving.i now see others are having the same problem as me.the new recall 01/27/11 i am sure that issue had not been fixed.i am pretty sure my subframe is bad too since i have been hearing a knocking noise for the last week.after reading everyone elses same issues with their windstar i promise i will not drive this vehicle and i am not going to go down without a fight.ford please note i will not allow your company to take advantage of me and put my family in danger for your money hungry company.you will be hearing from me!i thought i purchased a safe van and now i will be stuck in my house with no transportation! i will have my van taken to a ford dealership and it will not sit for six months due to there being no parts!i can not belive their can be sooo many recalls on this van and ford still thinks it is safe!
04/08/2011110000
 The brake fluid at the master cylinder is leaking on the wires under it. causing the abs and brake light to stay on. i am afraid this will cause a fire, due to the fluid being flammable. now i have a repair to pay for that i have never seen happen in a car. i am almost 55 and been driving 40 years and this is a first
04/21/201187000
 Automobile leaking oil and smoking. engine, abs and brake lights constantly illuminated until they were removed by the dealer i informed him the vehicle would not pass inspection and told him of my saftey concerns regarding the same.
04/08/2011110000
 The brake fluid at the master cylinder is leaking on the wires under it. causing the abs and brake light to stay on. i am afraid this will cause a fire, due to the fluid being flammable. now i have a repair to pay for that i have never seen happen in a car. i am almost 55 and been driving 40 years and this is a first
04/19/201194000
 My 2001 fordwindstar abs emergency parking break and over drive ,speedometer , van cought a minor fire , had the abs module changed when it had warranty still had problems reported it to ford two years ago before the recall fixed again out of pocket. this time need to take action.
06/01/2010
 Recall 09s09 was completed by ford last year. this recall should have fix brake light warning sign and also brake fluid leakage. but unfortunately my 2001 ford windstar showing brake warning sing and also leaking brake fluid in recent days.
03/05/200560000
 I have a 2001 ford windstar and the abs/brake warning lights on the dash keep coming on.
06/01/2010
 Recall 09s09 was completed by ford last year. this recall should have fix brake light warning sign and also brake fluid leakage. but unfortunately my 2001 ford windstar showing brake warning sing and also leaking brake fluid in recent days.
03/05/200560000
 I have a 2001 ford windstar and the abs/brake warning lights on the dash keep coming on.
03/30/201187087
 2001 ford windstar abs lights and brake light constantly comes on and won't go off, i'm starting to worrry is this dangerous. also there is a major concern over the back up lights come on when the vehicle is turned off
01/02/2011
 My 2001 ford windstar has issues with wiring up under dash .the plugs dont want to make good connection loses all fuctions on instrument panel.
07/04/201055000
 There has not been an incident or crash, but the abs, trac off, and brake! light all come on at once. anti-lock brakes and traction control do not function when this happens. it has occured intermittently for about a year, but happens almost constantly now. the lights would go off after restart, but now come on almost immediately, and stay on in spite of a restart in cold or hot weather. the ford dealership says their diagnostic code indicates a need to replace the abs module at a cost of nearly $1300.00 with labor on my 2001 ford windstar lx minivan which now only has 60,000 original miles. i googled this problem and found a site at www.fordwindstarrecall.info that discussed my problem.
05/15/2009
 Brake and abs lights up at operating temp. computer shows several unrelated trouble codes. dealer stated a bad module.
01/01/2007100000
 Tl-the contact owns a 2001 ford windstar. while driving at various speeds the contact stated if she hit a bump in the road the abs light and brake light illuminated on the dashboard. she stated the failure was intermittent. the contact stated she received a recall letter in the mail for the failure. she referenced recall nhtsa campaign id number: 09v399000, vehicle speed control and stated the recall work was performed in june 2010. after the recall work was performed the failure continued. she stated the dealer did not replaced the abs control modular. she called the manufacture and the dealer and was advised that they only had to repair the fuse wiring harness not the abs control modular and that was separate from the recall. she stated the abs control modular was part of the recall. she stated the vehicle abs and brake light came on before the recall and continued to come on after the recall was performed. she stated the failure had been ongoing for 4 years. the failure mileage was 100,000 and the current mileage was 160,000. vwb
05/15/2009
 Brake and abs lights up at operating temp. computer shows several unrelated trouble codes. dealer stated a bad module.
01/01/2007100000
 Tl-the contact owns a 2001 ford windstar. while driving at various speeds the contact stated if she hit a bump in the road the abs light and brake light illuminated on the dashboard. she stated the failure was intermittent. the contact stated she received a recall letter in the mail for the failure. she referenced recall nhtsa campaign id number: 09v399000, vehicle speed control and stated the recall work was performed in june 2010. after the recall work was performed the failure continued. she stated the dealer did not replaced the abs control modular. she called the manufacture and the dealer and was advised that they only had to repair the fuse wiring harness not the abs control modular and that was separate from the recall. she stated the abs control modular was part of the recall. she stated the vehicle abs and brake light came on before the recall and continued to come on after the recall was performed. she stated the failure had been ongoing for 4 years. the failure mileage was 100,000 and the current mileage was 160,000. vwb
05/15/2009
 Brake and abs lights up at operating temp. computer shows several unrelated trouble codes. dealer stated a bad module.
01/01/2007100000
 Tl-the contact owns a 2001 ford windstar. while driving at various speeds the contact stated if she hit a bump in the road the abs light and brake light illuminated on the dashboard. she stated the failure was intermittent. the contact stated she received a recall letter in the mail for the failure. she referenced recall nhtsa campaign id number: 09v399000, vehicle speed control and stated the recall work was performed in june 2010. after the recall work was performed the failure continued. she stated the dealer did not replaced the abs control modular. she called the manufacture and the dealer and was advised that they only had to repair the fuse wiring harness not the abs control modular and that was separate from the recall. she stated the abs control modular was part of the recall. she stated the vehicle abs and brake light came on before the recall and continued to come on after the recall was performed. she stated the failure had been ongoing for 4 years. the failure mileage was 100,000 and the current mileage was 160,000. vwb
04/20/2009100000
 The dash lights for the abs and breaks keep coming on while driving. there has not been an accident yet, i would like to prevent this from occuring.
05/04/200862100
 Interior lights come on at random , driving at night causes problem.
04/15/2010130248
 Driving ford windstar van in warm weather. abs failure light illuminates on dash on a daily basis in summer. downloaded error codes; cleaned ecu for abs.
05/10/201081000
 I have a 2001 ford windstar that has problems with the brake and abs lights coming on 95% of the time. the issue has been checked by no less than 2 shops and both have determined that the issue is a faulty abs module. after some online research i have found this to be a very common issue and i believe that it should be investigated. the abs not working properly can result in issues when trying to stop in inclement weather.
10/26/2010147000
 Tl- the contact owns a 2001 ford windstar. the contact stated that she saw smoke coming from the dash board of her vehicle. she also stated that the brake light and abs signal illuminated. the dealer advised contact that the vehicle was not included in the recall. the manufacturer was contacted, but offered no assistance. the vehicle had not been repaired. the current mileage was approximately 148,000. the failure mileage was approximately 147,000. bw
05/10/201081000
 I have a 2001 ford windstar that has problems with the brake and abs lights coming on 95% of the time. the issue has been checked by no less than 2 shops and both have determined that the issue is a faulty abs module. after some online research i have found this to be a very common issue and i believe that it should be investigated. the abs not working properly can result in issues when trying to stop in inclement weather.
10/26/2010147000
 Tl- the contact owns a 2001 ford windstar. the contact stated that she saw smoke coming from the dash board of her vehicle. she also stated that the brake light and abs signal illuminated. the dealer advised contact that the vehicle was not included in the recall. the manufacturer was contacted, but offered no assistance. the vehicle had not been repaired. the current mileage was approximately 148,000. the failure mileage was approximately 147,000. bw
05/10/201081000
 I have a 2001 ford windstar that has problems with the brake and abs lights coming on 95% of the time. the issue has been checked by no less than 2 shops and both have determined that the issue is a faulty abs module. after some online research i have found this to be a very common issue and i believe that it should be investigated. the abs not working properly can result in issues when trying to stop in inclement weather.
10/26/2010147000
 Tl- the contact owns a 2001 ford windstar. the contact stated that she saw smoke coming from the dash board of her vehicle. she also stated that the brake light and abs signal illuminated. the dealer advised contact that the vehicle was not included in the recall. the manufacturer was contacted, but offered no assistance. the vehicle had not been repaired. the current mileage was approximately 148,000. the failure mileage was approximately 147,000. bw
05/10/201081000
 I have a 2001 ford windstar that has problems with the brake and abs lights coming on 95% of the time. the issue has been checked by no less than 2 shops and both have determined that the issue is a faulty abs module. after some online research i have found this to be a very common issue and i believe that it should be investigated. the abs not working properly can result in issues when trying to stop in inclement weather.
10/26/2010147000
 Tl- the contact owns a 2001 ford windstar. the contact stated that she saw smoke coming from the dash board of her vehicle. she also stated that the brake light and abs signal illuminated. the dealer advised contact that the vehicle was not included in the recall. the manufacturer was contacted, but offered no assistance. the vehicle had not been repaired. the current mileage was approximately 148,000. the failure mileage was approximately 147,000. bw
07/04/200980000
 The abs light and brake light both came on simultaneously. after turning engine off and on, indications returned to normal. happened again a few months later. dealer's service writer dismissed it. now is happening regularly; sometimes multiple times per day. checked brake fluid level and it appears to be okay. brakes appear to function normally; no squeals, grabbing or sponginess, no apparent loss of braking ability. car stops in a straight line. brakes have been serviced.
01/01/2010
 I have a 2001 ford windstar. when i received recall notice 09v399000 i brought my vehicle in for the repair. the issue that i was experieincing in regards to the abs/brake lights going on while the car is in use has not been fixed. i believe that there is still and issue that needs to be addressed. this is an ongoing problem.
10/01/200972000
 Abs light is o in my 2001 ford windstar even after the recall in 2009 for abs ecm failure - abs brake light. the light continues to stayon for the past year almos adn it is causing other defects in my vehicle. my vehicle will shut down on me completely and nothing in my vehicle will work until i get a jump ad itiscausing issues with my brake system and transmission!
01/01/2010
 I have a 2001 ford windstar. when i received recall notice 09v399000 i brought my vehicle in for the repair. the issue that i was experieincing in regards to the abs/brake lights going on while the car is in use has not been fixed. i believe that there is still and issue that needs to be addressed. this is an ongoing problem.
10/01/200972000
 Abs light is o in my 2001 ford windstar even after the recall in 2009 for abs ecm failure - abs brake light. the light continues to stayon for the past year almos adn it is causing other defects in my vehicle. my vehicle will shut down on me completely and nothing in my vehicle will work until i get a jump ad itiscausing issues with my brake system and transmission!
10/10/201096966
 Abs and brake light come on when driving a few miles after starting car, anti lock brakes do not work. if you shut car off and start back up the lights will go off , they will come back on sometime or stay of for several several hndred miles. there were no codes stored to bring up . the speed contro; deactiction switch has been change .
02/12/200990000
 My 2001 ford windstar has broken through 2 rear axles! also the interior lights blink on and off as i am driving and sometimes come on and stay on and while turned off will sometimes drain the battery and the headlights and hazzard lights will blink on and off and the horn will beep. also at times my power windows will not function.
12/16/2009
 We bought van used... from beginning abs and brake lights on dash are constantly on. i believe this is causing the also constant beeping. we have gotten a tune up, changed the brakes, oil, airfilter and had the codes checked... lights are still on and still lots of warning beeps going off !!
05/15/200997000
 Abs and brake lights turn on during summer months on my ford windstar 2001 minivan.
03/15/201060000
 The brake pressure differential deactivation switch (scds) (2b264) located under the master cylinder (behind the air filter) developed a leak. this caused a short and a fuse trip, fuse #10 if the engine is on. this leak also caused brake fluid to wick down two wires to the abs brake module (2c219). the fluid accumulated on the (always on) power connectors for the abs brake system which are powered by fuses 101 and 102 and are both 40 amp. the fluid attacts moisture, road salt and leads to a fire when the fluid and moisture act as conductor between the hot leads and ground. lights that stay on are: abs,and brake, od flashes. speedometer and odometer do not work. also there is no heat or ac.
05/15/200997000
 Abs and brake lights turn on during summer months on my ford windstar 2001 minivan.
03/15/201060000
 The brake pressure differential deactivation switch (scds) (2b264) located under the master cylinder (behind the air filter) developed a leak. this caused a short and a fuse trip, fuse #10 if the engine is on. this leak also caused brake fluid to wick down two wires to the abs brake module (2c219). the fluid accumulated on the (always on) power connectors for the abs brake system which are powered by fuses 101 and 102 and are both 40 amp. the fluid attacts moisture, road salt and leads to a fire when the fluid and moisture act as conductor between the hot leads and ground. lights that stay on are: abs,and brake, od flashes. speedometer and odometer do not work. also there is no heat or ac.
07/15/201020500
 2001 ford windstar se sport, 20,000 miles abs, brake, & tire pressure lights come on after first starting car and running for a while.. abs and brake lights go on and off, tire pressure light stays on even with all 4 new tires equally filled at 35psi. just bought this van. transmission slips, had it drained and serviced 1 month ago with no problem reported.
06/18/2010120000
 My 2001 has a brake light, abs traction control lights and electric circuit board problem. the windshield wipers come on the door chime comes on when i turn the key off. the abs and traction control light and brake lights comes on and off while i am driving all the time. the check engine light came on simultaneously with the brake light and i lost brake power. no fluid leaked out and the transmission works fine. i almost crashed into three cars while driving with the brake failure.
03/15/201060000
 The brake pressure differential deactivation switch (scds) (2b264) located under the master cylinder (behind the air filter) developed a leak. this caused a short and a fuse trip, fuse #10 if the engine is on. this leak also caused brake fluid to wick down two wires to the abs brake module (2c219). the fluid accumulated on the (always on) power connectors for the abs brake system which are powered by fuses 101 and 102 and are both 40 amp. the fluid attacts moisture, road salt and leads to a fire when the fluid and moisture act as conductor between the hot leads and ground. lights that stay on are: abs,and brake, od flashes. speedometer and odometer do not work. also there is no heat or ac.
07/15/201020500
 2001 ford windstar se sport, 20,000 miles abs, brake, & tire pressure lights come on after first starting car and running for a while.. abs and brake lights go on and off, tire pressure light stays on even with all 4 new tires equally filled at 35psi. just bought this van. transmission slips, had it drained and serviced 1 month ago with no problem reported.
06/18/2010120000
 My 2001 has a brake light, abs traction control lights and electric circuit board problem. the windshield wipers come on the door chime comes on when i turn the key off. the abs and traction control light and brake lights comes on and off while i am driving all the time. the check engine light came on simultaneously with the brake light and i lost brake power. no fluid leaked out and the transmission works fine. i almost crashed into three cars while driving with the brake failure.
08/10/201092000
 Abs light on 2001 ford windstar stays on & all odometer functions & radio cease operation & freeze in place!
03/15/201060000
 The brake pressure differential deactivation switch (scds) (2b264) located under the master cylinder (behind the air filter) developed a leak. this caused a short and a fuse trip, fuse #10 if the engine is on. this leak also caused brake fluid to wick down two wires to the abs brake module (2c219). the fluid accumulated on the (always on) power connectors for the abs brake system which are powered by fuses 101 and 102 and are both 40 amp. the fluid attacts moisture, road salt and leads to a fire when the fluid and moisture act as conductor between the hot leads and ground. lights that stay on are: abs,and brake, od flashes. speedometer and odometer do not work. also there is no heat or ac.
07/15/201020500
 2001 ford windstar se sport, 20,000 miles abs, brake, & tire pressure lights come on after first starting car and running for a while.. abs and brake lights go on and off, tire pressure light stays on even with all 4 new tires equally filled at 35psi. just bought this van. transmission slips, had it drained and serviced 1 month ago with no problem reported.
06/18/2010120000
 My 2001 has a brake light, abs traction control lights and electric circuit board problem. the windshield wipers come on the door chime comes on when i turn the key off. the abs and traction control light and brake lights comes on and off while i am driving all the time. the check engine light came on simultaneously with the brake light and i lost brake power. no fluid leaked out and the transmission works fine. i almost crashed into three cars while driving with the brake failure.
08/10/201092000
 Abs light on 2001 ford windstar stays on & all odometer functions & radio cease operation & freeze in place!
07/15/201020500
 2001 ford windstar se sport, 20,000 miles abs, brake, & tire pressure lights come on after first starting car and running for a while.. abs and brake lights go on and off, tire pressure light stays on even with all 4 new tires equally filled at 35psi. just bought this van. transmission slips, had it drained and serviced 1 month ago with no problem reported.
06/18/2010120000
 My 2001 has a brake light, abs traction control lights and electric circuit board problem. the windshield wipers come on the door chime comes on when i turn the key off. the abs and traction control light and brake lights comes on and off while i am driving all the time. the check engine light came on simultaneously with the brake light and i lost brake power. no fluid leaked out and the transmission works fine. i almost crashed into three cars while driving with the brake failure.
08/10/201092000
 Abs light on 2001 ford windstar stays on & all odometer functions & radio cease operation & freeze in place!
06/18/2010120000
 My 2001 has a brake light, abs traction control lights and electric circuit board problem. the windshield wipers come on the door chime comes on when i turn the key off. the abs and traction control light and brake lights comes on and off while i am driving all the time. the check engine light came on simultaneously with the brake light and i lost brake power. no fluid leaked out and the transmission works fine. i almost crashed into three cars while driving with the brake failure.
08/10/201092000
 Abs light on 2001 ford windstar stays on & all odometer functions & radio cease operation & freeze in place!
10/01/200980000
 Own a 2000 windstar. after the last recall thought it would fix the problem. the abs light, brake light, check engine are constantly on. the speedometer, odometer, air conditioning not working. have not taken to a garage yet. but will be.
08/17/201096000
 I hacce a 2001 ford windstar that was just cleared from the serv. dept ford dealership about the abs and od warning lights flashing (they said due to a blown fuse). now the lights are back on, the remaing dash lights are going crazy and the headlights are cutting off while driving down the road. went to start the car from work and the battery is dead. these lights come on when the van heats up or hits a bump. i have small children and work thrid shift so this problem needs to be corrected before something serious happens as a result in faulty equiptnment.
10/01/200980000
 Own a 2000 windstar. after the last recall thought it would fix the problem. the abs light, brake light, check engine are constantly on. the speedometer, odometer, air conditioning not working. have not taken to a garage yet. but will be.
08/17/201096000
 I hacce a 2001 ford windstar that was just cleared from the serv. dept ford dealership about the abs and od warning lights flashing (they said due to a blown fuse). now the lights are back on, the remaing dash lights are going crazy and the headlights are cutting off while driving down the road. went to start the car from work and the battery is dead. these lights come on when the van heats up or hits a bump. i have small children and work thrid shift so this problem needs to be corrected before something serious happens as a result in faulty equiptnment.
10/01/200980000
 Own a 2000 windstar. after the last recall thought it would fix the problem. the abs light, brake light, check engine are constantly on. the speedometer, odometer, air conditioning not working. have not taken to a garage yet. but will be.
08/17/201096000
 I hacce a 2001 ford windstar that was just cleared from the serv. dept ford dealership about the abs and od warning lights flashing (they said due to a blown fuse). now the lights are back on, the remaing dash lights are going crazy and the headlights are cutting off while driving down the road. went to start the car from work and the battery is dead. these lights come on when the van heats up or hits a bump. i have small children and work thrid shift so this problem needs to be corrected before something serious happens as a result in faulty equiptnment.
06/23/201084340
 2001 ford windstar with problem of abs brake light, brake light, or tire pressure lights come on intermittently during extreme cold or extreme heat. restart of engine usually resets lights. error code c1185 abs power relay circuit seen by shop. expansion of relay switch aluminum plate causing short circuit of module or leakage from speed control connector possible causes. repair cost of over $600.
02/13/2010155000
 Speedometor and odometer quit working , now air and cruise dont work , also abs brake light stays on. the vehicle is a 01 ford winstar, also leaking brake fluid, thanks for any help.
04/15/2010110000
 I have a 2001ford windstar sel which was currently serviced for the brake switch recall. please note the switch was fine and no fluid was found on connectors.the abs unit in the van has issue with activation and deactivation primarily in warm weather. when temp exceed 70 degrees. complete failure of the abs unit, speedometer, odometer, and emissions system results. the fuse located in the number 10 slot will continue to fail, and in my case wont allow another fuse to work properly until the temps outside are cooler. here is the major problem in this when the fuse will accept, while iam driving and the weather starts to warm up the abs ecm starts to expand thus creating contacts or breaking contacts inside the ecm. when talking to the service dept at currie ford illinois they are completely unaware of the problem. this is serious safety issue that need to be addressed by ford and included in their current recall. as i stated before, the recalled item in my case was in perfect working order.. i believe this is the heart of the real problem and this shouldn't have to come from the wallets of the consumers. the real issue is poorly designed electronic were place in their vehicles.
04/28/2010
 Had ford motor company recall 09s09 that was issued in october of 2009 performed on my vehicle. wire harness was replace, no leaks found, however the yellow abs and red brake dash lights remain on. research indicates that the yellow and red lights on the dash indicate a possible ecm failure which has resulted in fires in several instances.
04/14/2010
 Tl* the contact owned a 2001 ford windstar. the contact stated that while the vehicle was parked it exploded and burst into flames. as a result, the contacts home also caught fire. the police and fire department were called and were able to extinguish the fire. the contact did not report any injuries. a police and fire report were filed accordingly. the manufacturer was contacted but no assistance was provided. the failure and current mileages were unavailable.
05/27/200580000
 My ford 2001 windstar has had the abs/brake warning lights come on for five years now. i have been living with it. is there any recall/
03/07/20101
 I have a 2001 ford windstar and the brake light and abs light come on and go off intermittently. i smell a burning smell in the car. i t comes on and goes off at different times, lights not always on. *tr
01/18/20101500001
 2001 ford windstar beginning in summer of 2009, abs and brake light sometimes lit on dashboard. dashboard controls either stopped working, going on and off and controls such as rpm, gas ind, speedometer either not working or going back and forth rapidly. the rpm indicator pin actually snapped off. now it is stuck and doesn't move at all. drivers side window stopped working, replaced motor. had ford dealer replace switch as indicated in recall 09s09 in november 2009. thought problem was fixed.as of jan 18, 2010, abs and brake lights come on after engine has warmed up. before i was notified of the recall i had full brake service on front and rear brakes in october 2009. also, not sure if related or not, i turned the car off at a red light and attempted tp restart it to turn off lights and the alternator died, had to replace. *tr
04/14/2007650001
 My abs and brake light come on when the electronic control module gets heated by the engine. it has been doing it from the time i bought it as has my neighbors windstar. no one could tell me what was causing the problem, but i found an explanation on the web at http://www.fordwindstarrecall.info/#problem2. the vehicle started doing this about a year after i bought it and is doing it today. the temp has warmed up. we had some freezing temperatures and during that period of time the lights were out and the braking system i assume was working. if this isn't a defect, why is it so widespread?? *tr
04/13/2008950001
 Brake light & abs light come on and stays on even after latest recall was done on my vehicle. this is an unsafe condition and is related to the original complaint. the recall (09s09) didn't go far enough. these vehicles continue to be a hazard for the owners & other motorists. please expand this recall to cover the entire problem before someone gets hurt or killed. *tr
09/15/200996521
 Tl* the contact owns a 2001 ford windstar. while driving 45 mph the vehicle stalled without any prior warnings. the vehicle was towed to the dealer, and the dta module was repaired at the owners expense . after a couples months, the vehicle experienced an identical failure. the dealer was contacted and the technician repaired a fuse that blew. however the over-drive warning light was illuminated on the instrument control panel, and then the odometer failed. the failure mileage was 96521. the current mileage was 98000.
10/12/20091000001
 The brake pressure differential deactivation switch located under the master cylinder developed a leak. my ford dealer told me this will cause a short and a fire!!!!!!!!. from what i hear this leak causes brake fluid to wick down two wires to the abs brake module. the fluid accumulates on the power connectors for the abs brake system which are powered by fuses 101 and 102 and are both 40 amp. the fluid attracts moisture, road salt and leads to a fire when the fluid and moisture act as conductor between the hot leads and ground. ford wants me to pay them $2000 to fix this. i hear you are looking into this fire issue. *tr
06/20/20081050001
 My 2001 windstar has never been in any accident. last summer while standing and running it all of a sudden had smoke rising on the exterior of the van on the driver side, most likely due to the low brake fluid sensor leaking at the bottom of the brake master cylinder. my cruise control became intermittent and my abs light came on after hitting a bump. a local shop stated that a wire was loose and it would cost a $1000 to find the problem. today i learned that the switch is leaking and the connector to the wiring harness is burned and has been shorted by leaking brake fluid. thankfully that i did shut down the car when the smoke appeared and i did not have a fire. i understand that the nhtsa is investigating windstars that have had fires or problems like this. *tr
10/04/20091050001
 Abs warning light goes on intermittently on 2001 ford windstar. light goes off and stays off if motor is shut off and then re-started. sometimes it stays off after restarting van and other times it comes back on. i understand there are several complaints by concerned owners and that in some cases a fire hazard has been exposed or feared. please add my vehicle to those others who have submitted complaints. i understand a recall may be in the works. i intend to have the car inspected by a reliable mechanic soon. *tr
09/25/20091140001
 We could smell smoke in our van, and the instrument panel was going crazy (warning lights coming on, speedometer fluctuating between speeds). we took it in and found that the abs module had shorted out because of brake fluid dripping onto the module and was slowly shorting out other wires and sensors, which could have caught fire. they are charging us to replace the abs module and the engine wire harness because of the fried wires. *tr
07/01/2006500001
 In my ford windstar 2001 the yellow abs brake light and red brake light turns on after few minutes worm weather or after approximately 10 minutes in cold weather. looks like the fault is related to thermal expansion in the abs control module. the problem started in 2006 and is getting worse. *tr
04/12/20081070001
 2001 ford windstar - recurring abs & e-brake lights on while driving in 2001 ford windstar. lights come on intermittently and stay on until vehicle is turned off. after restarting, lights will come on again once driving has started. mechanic unable to determine problem. possible fire damage. *tr
09/07/20091
 Abs and brake light came on and then speed thing stopped working so i didn't know what speed i was going. my mechanic said after searching for 2 days that is probably brake pressure switch. i looked it up online and saw many ford windstars had same problem that have even caused fires! thanks *tr
08/16/2009850001
 Drove from albany, new york to virginia beach on august 15-16, 2009. as we pulled into our destination, abs light and brake light went on, o/d light flashed, speedometer and odometer readings went to --------, and we smelled smoke. was able to drive car to beach ford in virginia beach where we were told that brake deactivation switch was leaking fluid damaging wiring harness and many other components. was told that wiring harness part needed was obsolete. husband was shown burned up wiring harness and abs unit by mechanic. the wiring harness plug was melted into the abs unit. these parts remain in the car, unplugged. we have been told by ford that there is no such recall for our vehicle, although we have researched on the internet and believe this to be untrue. we have spent $500 getting the leak repaired so we could drive home, and an additional $200 from our local dealer to tell us that we need to spent $3000 more in order to repair the problem. currently, we have no speedometer and odometer, abs light and brake light are on due to burned parts, o/d light flashes. *tr
07/15/2009710001
 Failure of speedometer, odometer, a/c compressor switch and blown fuse (#10 in fuse panel, 15 amp). failure of front passenger seat belt to remain engaged when holding a occupant. *tr
08/15/2008980001
 No speedometer readout :& abs lights are on. *tr
07/23/20091067201
 Brake pressure deactivation switch leaks, causing loss of brake fluid and illumination of brake warning light. replenished fluid, but before switch could be replaced it shorted burning out fuse #10. this caused loss of function of speedometer , tachometer, odometer and ac; abs and brake warning lights illuminated and overdrive off indicator flashes. replacing switch and fuse #10 resolved issue. research on the internet found that failure of this component has led to fires due to brake fluid leaking on other electrical components, though no additional evidence of damage was found in this case. *tr
07/21/2009980001
 Loss of odometer,speedometer, cruise control, all functions associated with #10 fuse. happened 1 time. disconnected abs deactivation switch from master cylinder. connection was contaminated with brake fluid causing a short and blowing fuse #10. *tr
07/17/20091550001
 2001 ford windstar abs light and brake light comes on while driving, when i turn vehicle off and restart the lights come on again while driving i have noticed brake fluid on the switch below the master cylinder and also on another switch bank in the area below. i am currently researching how to repair and if there is a recall on this view ford tsb 15682. *tr
07/16/2009870001
 I have a 2001 ford windstar se van where the brake, abs and traction control lights intermittently come on. when this happens, my understanding is that the abs and traction control systems will not function normally. to me this is a safety concern. i have had a mechanic look at the problem and run the computer codes but was unable to determine the cause. i will have to bring this vehicle to the ford dealer and spend a bunch of money to have them fix it i'm sure. in the meantime, i understand that some vehicles experiencing this problem have started on fire (mine hasn't) but this is a ticking time bomb as this is the car my wife and children ride in. i believe that ford should have to perform a recall to fix or replace the faulty part(s). *tr
11/09/2008956131
 Brake light on after brake service speedometer and odometer stopped working abs brake light stays on defective cruise control. *tr
07/01/2009944651
 I have a2001 ford windstar lx ,i went to the store and parked my car was in the store aprox 40 mins when i came out there was smoke coming from under the drivers side, car was taken to united car care my all time car repair place , abs had burn the connector harness .van not usable i am a 77 year old widow now without transport for my medical appoints, and no money to get van fixed or buy another car ford needs to repair this as many others have had this happen the van should have been recalled please make ford fix this , i was lucky i could have been driving and been hurt thank you x *tr
10/05/2008910001
 The cruise control stopped working and i thought it was a fuse blown. however, my wife was at a traffic light and a big puff of smoke came from under the hood of the car. we took it to a friend who worked for a ford dealership. he stated that the brake fluid from the reservoir had leaked onto the modules below and they had shorted out. he had seen this many times before and told us it would be about $1300 to get it fixed. as of today, we have not been able to afford the repair. we feel it is unsafe to drive; consequently, the car awaits a recall or a lottery win by us to get it repaired. i am thankful that my wife and other drivers were not injured when this happened. engineers pride themselves on having an engineering solution for every problem. my hope is that this complaint will help them see the need, along with the others, to bear the burden of this repair, and probably engineer cars that are not slow-ticking time bombs. *tr
07/07/20091802001
 Wires melt down. strip my fuse number 10. my kilometer, speedometer, brake and abs lights are on in my dash. *tr
07/07/20011406851
 Abs switch below master cylinder caught on fire leaking fluid on wires then blew fuse to speedometer and odometer and overdrive dealer says no recall had to buy fuse and take to garage to fix other problems caused fix wiring badly burnt. *tr
05/26/20091
 One day the dashboard lights, headlights went out. i have taken it in for service twice. they replaced the number ten fuse. but it blow again. now the lights ac radio stay on even when the key is out. *tr
07/08/2008686001
 On a very hot day i went over a bump and the red brake light and yellow abs light came on in my 2001 ford windstar. i was panicked that the brakes would fail, but after parking the van and restarting it, the lights were gone. they came back on intermittently over the next couple months. i took it to the dealer a couple times before they told me it needed a new abs module. i research the internet to understand the problem, and why it only happens when it is hot out. we decided to postpone the $700 repair, since it doesn't occur when it is cold out. we had no problems this winter, but now that it hot again, the lights are again coming on intermittently. my understanding is that we won't have abs only when the lights are on. but this is a big safety concern in that we don't know if we will be able to count on the abs system working when we need it. ford should be responsible for fixing this problem since it is definitely a safety issue that results from a defective part they designed. at this point we have not replaced the part, it is still in the van, but i anticipate that we will have to replace it soon as the weather gets warmer and the lights become more frequent. *tr
03/06/20091030001
 Outrageous ,i have been researching the possible problem of an abs/brake light ,that keeps coming on in my 2001 ford wind star lx van. statement is 1999- 2003 ford windstar vans could have this and the problems that could occur. my oh my .. i have 3 children that ride in that van daily, i'm a low income parent. why would one take this chance with humans. i bought the van in march of 2009. 2 days later abs/ brake light came on. at the time i was told that i have an eagle warranty ..that might i add not even the ford dealer ship would except. i don't take chances where my children are involved. *tr
05/10/20091
 2001 ford windstar brake pressure differential deactivation switch fire. replaced with part that has been a recall for f150's. burnt part kept. previous problems. abs module malfunction causing loss of speedometer, odometer, abs light, brake light, od light, loss of headlamp, cruise control, seatbelt warning bell, ac/heat/defrost. *tr
06/01/2009123000
 Tl*the contact owns a 2001 ford windstar. while driving at an unknown speed, the emergency brake and abs lights illuminated on the instrument panel. in addition, the speedometer and odometer gauges blanked out and other gauges began to sporadically flash simultaneously. the vehicle was taken to the dealer and a diagnostic was performed. the failure codes indicated that the braking system was faulty due to water or fluid entering the abs connector. brake fluid was found leaking onto the abs module as well as fluid build-up in the connector. the abs module and pump were replaced. the dealer also attempted to reprogram the abs module, but was unsuccesful. the vin was unable to be entered into the system. the current and failure mileages were less than 123,000.
06/04/20091500001
 The #10 fuse on my 2001 ford windstar keeps blowing. this disables speedometer and a/c, and causes abs and brake lights to come on. it also disables several other monitoring systems. i have determined that the switch under the brake master cylinder is leaking brake fluid. i am confident that this issue is the same one that has been reported by numerous windstar owners. i am going to buy the replacement part. i shall keep the receipt, in hopes that i may be reimbursed, eventually. *tr
05/10/20091100001
 Ford windstar 2001. the brake pressure differential deactivation switch located under the master cylinder over time leaked. this caused a short and a fuse trip. this leak also caused brake fluid to wick down two wires to the abs brake module. the fluid accumulated on the (always on) power connectors for the abs brake system causing the abs (anti-lock brake system) ecm (electronic control module) module to expand in the ecm which is attached to the ecm main circuit board at all points. this could have caused a fire in the automobile if it was not corrected. cost $1500.00 at ford dealership to correct. replaced ecm, brake pressure differential deactivation switch, and servo cruise control part. brake pressure differential deactivation switch that caused all the trouble is available. *tr
04/20/20091
 The abs and brake lights come on, the brake deactivation switch is bad and has caused brake fluid to leak and the switch, the a/c has stopped working as well as the odometer and speedometer. *tr
02/13/2009474351
 On my 2001 ford windstar i noticed all at once my abs, brake, and o/d lights are on along with my odometer has no numbers in it just ------ dashes, and my speedometer stopped working, it is stuck on 0 miles/hour... *tr
03/31/2009900001
 2001 ford windstar speedometer/odometer went out while driving. fuse 10 was blown. have replaced the brake pressure switch once and the fuse several times. fuse is still blowing out. *tr
04/18/20091580001
 Fire - speed control pressure switch the abs and emergency brake indicators have been illuminating on the dash off and on, but no problems have been found with either system. yesterday, while driving less than a mile, i was stopped by a neighbor who had noticed smoke coming from underneath my hood. the lights were not on at that time. when we opened the hood, a small fire had started but extinguished itself rather quickly, resulting in the scps completely separating from the brake fluid reservoir. the car has not been repaired as of yet, as the part is a special order item. the car has not been driven since the incident. *tr
04/08/2009700001
 2001 ford windstar once the engine is warmed up, the abs and brake light come on and stay lit until i turn off the engine. sometimes when i restart the engine they are off but other times they are not. sometimes they don't come on at all. as time goes on it is happening more frequently. *tr
10/09/20081290001
 I have a 2001 ford windstar. i started encountering lose of cruise control about 7 months ago. then about 3 months ago, the odometer and speedometer just quit working. i paid $400.00 to have the speed sensor replaced but that still didn't work. *tr
01/28/20091010001
 Brake pressure differential deactivation switch leaked brake fluid down wires to the abs module, shorting the module and causing a brief but non-sustained fire with resulting smoke and melting of abs module and wiring harness components. this disabled the speedometer, odometer, abs system, cruise control, and activated abs lights and brake system lights. appears to have occurred while driving and smoke and smell was present when parked in garage after occurrence. *tr
01/11/20091100001
 Abs and traction control light on and system not working. *tr
02/10/20081
 In our ford windstar our abs system has completely gone out and the ford place told us that was going to cause us electrical problems. then our abs light and brake light comes on, everyday. the airbag light has come on and then off. the check fuel cap came on and then went off. the rpm's almost hit zero when the abs light and brake light come on. the ford dealership told me that they keep extra abs parts because windstars have had problems with the abs system. *tr
07/01/2007800001
 1. event leading up to failure: leaky brake pressure switch at the base of the master cylinder caused brake fluid to leak into the switch, wire harness, and abs ecm. this eventually caused failure in the brake pressure switch and abs ecm wiring. 2. the symptom of the failure is intermittent yellow abs and red brake warning lights in dash that come on and remain on shortly after drive off. this also causes loss of cruise control functionality as cruise control can not be activated. 3. nothing has been done to correct this problem yet. at my earliest opportunity, i'll have the brake pressure switch and abs ecm replaced. according to numerous automotive forums, this failure has led to spontaneous fire under the hood. *tr
12/12/20081000001
 2001 ford windstar brake,abs brake,cruise control, and speedometer/odometer electrical problem-causing my brakes to almost fail with my two 2 year old twins in my van. *tr
10/15/20081102311
 Many electrical problems over the last 4 years ..the latest was smoke coming from the abs unit. had the mass air sensor burn up about 9 months ago. *tr
03/01/20071000001
 I have a 2001 ford windstar sel. the following problems occur when the #10 fuse blows, which is everytime we replace it. the anti-theft system, interior illumination on dash board(speedometer, a/c, radio lights), and the day runners/auto headlights. sometimes the car does not turn off....even with the keys out of the ignition and the car door open; the radio and a/c will continue working and then the headlights come on. i purchased this car in february of 07 and these things began happening shortly afterward. also, the brake light will come on occasionally. *tr
10/02/20081040001
 Abs light come on every know and then for months prior to this incident, know, speedometer-odometer ac has stop working and abs light is on constantly, when i check fuse box, fuse 10 was blown proceed to replace and kept burning them. i have replaced the fuse now for the 3rd time in as many days and fuses are still blowing. *tr
09/10/2008901001
 Abs lights, brake light on dash is on, odometer does not work, speedometer, air conditioning/heater does not work, cruise control does not work. i'm looking for parts to fix problem. *tr
09/24/2008926121
 1. electrical short in engine bay of 2001 ford windstar lx caused blown fuse #10, loss of speedometer, cruise control, abs and brake warning lights, odometer, a/c and temperature controls. replaced fuse, blew again. 2. replaced fuse twice, same results. 3. searched online, found many posts and instructions on repair. purchased a brake repair kit from local ford dealer, replaced the brake pressure switch under the nose of the brake master cylinder; cleaned brake fluid off the wires and re-connected the old connector to the new wire connector. replaced #10 fuse. *tr
12/20/2007985001
 Ford windstar 2001 with brake, abs brake, cruise control, and speedometer/odometer electrical problems. *tr
09/11/20081300001
 2001 ford windstar -brake light indicator, abs light indicator, odometer inop, squealing brake noise during turns, air conditioning just stopped working. *tr
09/04/20081
 My 2001 windstar was giving off intermittent brake light warning. after about 1 week of this going on and i couldn't find out why this was occurring, my van had the abs light, brake light on constant. my overdrive light was flashing continuously. my speedometer, odometer and air conditioning stopped all at once. blown #10 15a fuse. i looked into see what has gone wrong and noticed that the brake pressure relief switch that is connected to the bottom of the brake master cylinder was defective and leaking brake fluid onto the transmission range sensor and into the wiring harness that contains the wires for the brake pressure switch. this accumulation of fluid into the wiring harness has caused a short. i caught this fairly early for if i had not, this surely would have caused a fire. i have replaced the brake pressure relief switch and have not traced the short as of yet. *tr
01/01/2008840001
 Both abs and brake warning lights come on intermittently and stay on until engine is turned off. has occurred when starting engine, or while driving. on several occasions, 15amp fuse #10 has blown out, causing instrument panel gauges (speedometer and odometer) to turn off. replacing fuse has not stopped problems from occurring. running diagnostic tool on abs module displayed codes c1185, c1194, c1210, c1214, c1242, c1246, c1250, and c1254. other owners have reported that identical problem resulted in engine fires. *tr
07/15/2008924231
 Abs and brake lights on, no speedometer, odometer or cruise . *tr
08/21/20081270001
 Vehicle blew the #10 15 amp fuses twice, after that electrical smoke poured into the cab and stopped when vehicle was turned off. also, the low brake fluid light was on. on august 22,2008 i put 1/2 a bottle of brake fluid in. upon inspection i found the brake pressure differential deactivation switch(replacement part #sw-6351) was leaking into the electrical connector and onto the wire harness below. on august 27, 2008 i purchased replacement part (sw-6351) for $22 from my local ford dealer. old part is available. *tr
08/09/20081192001
 On 08/09/2008, the emergency brake light and the abs light illuminated on the dashboard while driving at 60 mph under normal conditions. the vehicle then had to be jump-started, and i noticed a faint burning smell while driving. upon exiting the vehicle, i noticed the burning scent was extremely strong. the vehicle is now inoperative. the battery, purchased at sears on 06/04/2005, can no longer hold a charge. the electrical system has gone haywire. for example, the headlights now come on, dimly, when the switch is in the off position. the mileage at the time of this incident was 119,200. i had one prior experience with the emergency brake light and the abs light illuminating on the dashboard. in june 2007, both warning lights came on intermittently only when the vehicle was in reverse and were accompanied by a loud squealing sound in the brakes. twice, on wet pavement, my brakes did not function normally. although i avoided any collision, on one occasion i was forced to proceed through an intersection where the traffic light had just turned red. an independent garage inspected the brakes and could find nothing wrong. the computer diagnostic was code c1185. as a precaution, they flushed the brake system. thereafter, the brakes functioned normally. the emergency brake light and the abs light came back on intermittently again in may 2008. again, this happened when the vehicle was in reverse and was accompanied by squealing brakes. i had a ford dealership go over the vehicle and received a written report in may 2008 that showed the brakes to be in acceptable condition. there were no further incidents until august 2008. because of the complaints i've read on the nhtsa website, i will mention that the cruise control deactivation switch on this vehicle has not worked in quite some time. i must use the brake pedal to turn off the cruise control. i urge you to continue your investigation into this dangerous situation. *tr
08/18/2008890001
 2001 ford windstar sport se # drove vehicle 2 hours, parked car for approx 2 hrs, returned and then unable to start vehicle, battery would fail then car needed jumped. this happened 3 times. turn car on, abs yellow light, e-brake red light on constantly when driving (intermittent) and will go off when car is turned off. cruise control does not work any longer. pulling e-brake from floor does not trigger red e-brake light. looked behind air filter, brake fluid saturated on abs brake module and wiring below the brake pressure deactivation switch, leaking coming from the brake pressure switch. looked at the switch under drivers side door (below car), verified sticker on cover (next to abs ecm module) indicated ford (kelsey-hayes). checked fuse #10 & #14 (was not blown). the failure lights continue to come on sporadically. ford needs to make this a recall on the windstar.. why is it that this is a recall on other ford vehicles with the same parts and failures. this is a huge fire safety hazard. please make ford make this a recall. *tr
06/01/2008650001
 My 2001 ford windstar abs and brake warning lights have come intermittent on and my cruise control is intermittent. searching the internet revealed that there is a problem with the speed control deactivation switch that is mounted on the front of the master cylinder. i have inspected my switch and it does have a fluid leak that is running down the wires. this has not caused any other problems yet. *tr
07/18/2008833001
 Abs light is on, brake light is on, a/c is blowing out warm air, odometer is not working, o/d off light is blinking. replaced fuse #10 twice, but keeps blowing. we have not had it fixed yet. *tr
07/18/200879000106/07/2002
 Tl*the contact owns a 2001 ford windstar. while the vehicle was parked, it ignited into flames without warning. the vehicle was destroyed. the fire department was called to the scene and a report was filed. the fire representative stated that the cause of the failure was electrical, consisting of the air conditioner unit. the failure and current mileages were 79,000. updated 10/03/08 *bf the engine light had also been on. updated 10/06/08. *jb
07/11/2008114000
 Fuse #10 keeps blows, abs and parking brakes lights are on, o/d off light is flashing, speedometer, a/c, and odometer are not functional. *tr
06/25/2008610001
 I just recently brought my ford windstar (2001) to the repair shop due to some unexpected electrical malfunction. at first, both abs and brake light on the dashboard turned on then the odometer counter went blank, o/d light was constantly blinking and the air conditioning compressor will not engage. my mechanic told me about what he discovered under the dashboard, the abs mechanism damaged the electrical harness due to abs control fluid leak. i decided to look for the replacement parts on the internet due to a very costly repair and discovered that there is a lot out there having the same issues i had experienced. luckily my vehicle did not set on fire. i am surprised that ford company never took action on this issue knowing that this could lead to a very serious accident. kindly inform me if there is any recall from ford company regarding this problem. *tr
06/24/20081100001
 Brake pressure diff switch is leaking brake fluid on the wires under it and fuses and popping. odometer, speedometer, a/c, abs and o/d have all posted as not working. *tr
06/13/20081
 Ford windstar brake, abs brake, cruise control, and speedometer/odometer electrical problems * brake light (red) stays on * 15 amp fuse #10 blowing out * fire or smoke coming from under the van abs ecm area while off. * melted abs ecm wiring connector. * speedometer and odometer stop working. * cruise control will not activate or deactivates without warning. * abs brake light (yellow). *tr
01/17/20011
 Dash lights on; engine, abs, brake, overdrive blinks, speedometer and odometer stopped working, cruise control stopped working. this turned into an expensive ecm repair caused aby a leaking brake fluid which shorted out wiring and fuses. *tr
05/31/20081090001
 Tl*the contact owns a 2001 ford windstar. the contact noticed smoke and sparks underneath the hood and from the doors of the vehicle. she stated that the smoke and electrical sparks occurred once on may 31, 2008. the failure occurred after driving 40 mph, at which time the vehicle shut off and failed to restart. the weather was dry and sunny. on june 3, 2008, the vehicle was taken to the dealer and they stated that there was circuit failure. ford is aware of the failure, but will not provide assistance. the contact left the vehicle at the dealer and is waiting on ford to issue a recall so that her vehicle can be remedied. the current and failure mileages were 109,000. updated 07/09/08 *bf
12/14/200301
 Smoke started coming out from the car. the cable and plug from the cruise control to the abs control module short circuited. the mechanic cut the cables to further prevent any other electrical problem. i having replaced this part due to trouble in finding it. i complained about an electrical problem to the dealer but they never found the problem. a month after the guarantee expired this incident occurred. i tried to claim this to the dealer since it was reported but they said there was nothing they could do. i have a 6 year old boy we were lucky the car didn't caught on fire. maybe ford motors is waiting for a tragic accident to occur before taking any action. *tr
03/15/20081240001
 Tl*the contact owns a 2001 ford windstar. occasionally, the contact has to spend time maneuvering the gear shift out of park. the dealer stated that there was a related safety recall; however, it was performed on the vehicle with the first owner. the current mileage was 129,500 and the failure mileage was 124,000. updated 06/25/08 *cn the consumer requested to withdraw his complaint, since the dealer said the problem was originating from somewhere else and the recall problem was not the issue. updated 06/25/08
03/09/20071480006
 My 2001 windstar has been blowing driver side headlights. not only does the light blow but the entire glass part of bulb blows completely off. this is the 6th time we have changed bulb. this time i was 60 miles from home on a road full of 18 wheelers. when the head light blows so does my tail lights. so i must drive home with 4 way flashers on. the only reason i have this van is because we have 5 children and have to use a van to go anywhere. which means my children are always in it when it messes up. this time ,also, when trying to get the van back home, my interior lights kept going on and off by there self. and as always the motor stutters and makes it hard to go up any hill. we live in alabama. every road i take is nothing but hills. *jb
01/10/20062011/18/2002
 1) none. 2) multiple occasions failure of the brakes occurred after the vehical came to a compete stop. car shutters at 40,50 and 60 mph. several mis-accidents occured. these were diverted as our habits were altered to stop a minimum 10 feet from traffic and travel 10-15 mph less that posted. 3) replacement of the complete break system, pads, cylinders, lines, rotors and all computers to include fuses. all factory parts. *nm
05/04/20061
 Foia request any reports, notices complaints/ information, mfg violations, warning/ regulatory ltrs re electrical and/or air bag fires in 2004-2004 ford windstar minivans. *ts the consumers daughter died and the son was injured when their vehicle caught on fire. *jb
06/24/20061301
 While driving down the road, i pressed my brakes to stop and the pedal went to the floor. i had no brakes until i pumped my brakes several times. while doing this my brake light and abs light came on and stayed on. my o/d light was flashing and my speedometer stopped working along with odometer. and my a/c stopped working. we stopped to work on it and found fuse number 10 was blown. we replaced fuse. when we turned to key to start the motor blue smoke came up from motor area and fuse instantly blew. upon further inspection found that the sensor under master cylinder was leaking brake fluid into electrical harness. have not fixed sensor yet. *jb
04/08/2005111/17/2001
 While driving my 2001 ford windstar the entire dashboard lit up. then the abs, odometer, and engine light remained on. speedometer stopped working, and the odometer went blank. the van was taken to apple valley ford, where we were told that abs system had been leaking for sometime with no warning indication , and shorted out the entire electrical system. the repair bill was $4500 as the front electrical module was shot due to the leakage. dealer and ford corporation could not explain cause of leak, why warning system did not work, why the extreme damage or why the front electrical module was located so close to the abs system, that allowed this to happen. i questioned if this was a manufacturing or latent defect. repair was being done at this time. *ak
01/06/200570090210/01/2001
 I have had problems with my 2001 windstar passenger rear automatic door since the day i bought the car brand new. the door would constantly close and reopen. i have had it checked at least 3 times for this problem. most recently the door would not close all the way and has been rattling. the problem now is the door has closed and locked and will not open. my ford dealer needs to pry it open with some device just to check the problem. minimum cost for this is $250.00. i cannot drive this vehicle with a jammed door because i have two small children. if i ever needed to get them out in an emergency i would not be able to. i have contacted ford motor company to see if there has been any recalls of this nature. ford did not acknowledge this problem and dismissed it and me. i think ford should investigate this further and i think they should be responsible to fix the problem for free. an automatic door malfunctioning seems like a recall situation to me even if there is only one person whom its happened to so far there may be others.*ak
08/21/2004301/31/2001
 Questions: my husband and i own a 2001 ford windstar minivan which has been causing us trouble lately. two months ago, the car engine stopped suddenly in the middle of the street while i was driving. after letting the car sit for half an hour, i was able to restart the car. when i took the car to the local ford muzi dealer, however, they weren't able to find a problem with it, so i called ford corporation concerning the issue of safety, and we agreed that i co-pay $100.00 to replace the cam-sensor, which they said would solve. *jb the problem. two weeks after replacing the cam-sensor, however, my car stopped again in the middle of the road when i was driving my younger daughter to school. the car was later towed to muzi ford dealer and fixed again. today, around 5 p.m., the engine stopped abruptly again while my husband was driving. fortunately, there were no cars behind him, or our car might have been run into and our four-year-old son in the back seat would have been killed. since the ford dealer could not find a problem with the car, we requested for a partial refund or an exchange. however, ford corporation refused both options and is ignoring our calls. we are very concerned about the safety of our entire family; if the engine stopped in the middle of the highway, we could all be killed. *jb
11/19/20031
 Driver side window inoperable, engine light stays on, and interior lights flickers on. motor was replaced in driver's side window, cost: 294.00. made appt. to have diagnostic check - charging $90.00 to do so. *nm
7
 Vehicle experiencing problems with transmission, brake lights and head light equipment. *mr the light kept blowing out. the driver's side twice, rear driver and passenger brake light once and the rear center brake light twice. *sc the consumer stated the transmission failed. *jb
04/04/2003105/01/2001
 An electrical connector seal had to be installed, the seat buckles and rear wiper motor cover were replaced, the abs failed, and right before the engine shut down all the lights on the dash board illuminated, after the vehicle was repaired the intake manifold, speed sensor and brake sensor failed. *ph *jb rq04011.*pco
02/01/20031
 There was an electrical shortage, which caused the vehicle to have no lights inside the vehicle.*jb
03/22/2001103/20/2001
 Only method of opening vehicle door from outside using a key is through drivers side door or using remote entry system. consumer complaint is that if driver's door is inoperable ,and electrical system is inoperable, there is no way to open vehicle from outside. *ak there should be an option to manually open each of the doors. eliminating this option was just to save a few dollars on the part of the manufacturee. *yh
ELECTRICAL SYSTEM - BATTERY
750002
 Any time that vehicle was on the battery light came on. vehicle was put on a diagnostic machine, which found three different codes on the vehicle. mechanic was able to extinguish the battery light, but two weeks later it was back on again.*ak
ELECTRICAL SYSTEM - IGNITION
07/17/2002503/01/2002
 While driving theft light on dash comes on rear wiper comes on by it self and engine turns off leaving vehicle moving with no power, no steering, no brakes. after stopping vehicles ignition is locked out with no power/no crank.*ak
01/15/2002601/01/2001
 This vehicle has died while driving at various speeds, at different times of trips (long and short/hot engine normally). while driving at 55 mph it died one time, causing us to enter the oncoming traffic lanes around a curve. this is not good for a family vehicle when there is an entire family in the vehicle. we have notified the dealer and have taken in for service, but it continues to die. we had the same problem with our 1998 windstar that was totalled in a collision (not problem related). i do not know if it is the ignition system or the fuel system. this vehicle has multiple recalls to date. *ak
ELECTRICAL SYSTEM - IGNITION - MODULE
02/22/2002310/01/2001
 Brakes failed on three different occasions (repair dates: 3/22/02, 4/1/02 and 4/15/02). first, my wife noted the brake pedal was going all the way to the floor before there was any response. the dealership advised that this was normal. we insisted that it wasn't, until there lead technician found and replaced a faulty hcu. the second failure came while i was driving my wife and 6 month old baby from mo to va. while on the west virginia turn pike, the anti-lock brakes failed again and eventually the brakeing system failed all togoether by the time we reached our destination of suffolk virginia. barton ford, in suffolk va, replaced the hcu and the ecu and repaired a brake fluid leak. the third incident occurred while driving back to mo. once again the brakes did not respond normally. once back in o'fallon, mo. the dealership found a air bubble in the brake line and they reprogrammed the abs module. each brake failure also affected the traction control system and the speedometer. we have also had to have one window replaced, the drivers side sliding door adjusted, a seal inserted in the rear of the vehicle due to a recall item, and bolts tightened at the engine cradle mounts. recently, the fuel cap indicator light illuminated for a period of 5 days for unknown reasons and we are currently unable to fill the gas tank to its normal capacity. this vehicle is unsafe and hardly worth the $27,220 that we are paying for it.
ELECTRICAL SYSTEM - STARTER ASSEMBLY
04/14/2004850002011/08/2002
 When the windshield wipers are engaged they will either work for a few seconds and quit or not work at all. dealership replaced the wiper motor twice, and the front electronic control module. but problems still exists. recall 01v261000 was issued, but this vehicle was not covered under the recall due to vin. *ak also, clunking on the front driver side at low speed or when turning left. dealership checked the vehicle and later replaced the brake rotor. starter were also replaced. *la
06/28/2003
 Consumer called complaining about having problems with starter. vehicle was taken into the dealer, and they stated that there was something wrong with the starter, and some interior damage was done. consuemr was involved in a collision, and she felt that it had something to do with the starter. manufacturer was contacted, and they were not responsible for anything because there was no recalls. *ak
ELECTRICAL SYSTEM - WIRING
08/08/200792000010/13/2006
 My family and i were exiting the new york state thruway at exit 25a on wed 8/8 at approximately 8:30pm. sparks were noticeable on the passenger side of our 2001 ford windstar. the sparks were coming from under the left side of the hood. as we went through the toll booth and onto the exit ramp to route 7, smoke began coming in the air vents. at that time i pulled to the shoulder of the ramp and looked in the rear of the car for a fire extinguisher. unfortunately i did not have one in the car. i then went to assist my wife with getting our 5 year old son out of the back seat. at that time i noticed flames coming from under the hood on the left side. we exited the vehicle and another person assisted me with getting various belongings out. we then waited for help to arrive. the car was totally destroyed by the fire. the insurance company took care of what they considered the value (this value was lower than the nada value). i protested this but was told they could not consider nada due to its accessibility online. their value resulted in my having to pay $1000 to fulfill my loan obligation and release the lien to the insurance company. i then contacted ford and reported the incident to which their reply was the insurance company could pursue restitution but not myself. why is it that i am the one that suffers this great loss? we have spent $2000 to satisfy this loan and put a down payment on a new car. this clearly is the responsibility of ford. cars do not just catch on fire for no reason. there are many recalls on ford products. lawyers have not responded to my messages regarding this matter because no one was injured. i am only seeking for ford to take responsibility for this or the insurance company to pay the proper value of my vehicle. *tr
02/08/20071380001
 Tl* - the contact called regarding the 2001 ford windstar. the contact stated when he started the vehicle the contact began to smell wires burning. the contact stated that he saw smoke coming out from under the driver's front seat and exited the vehicle. the engine was located under the driver's front seat. the failure mileage was 138,000. the fire went out by itself. the contact did not take the vehicle to dealer for repairs. the vehicle was drivable. there were no warning indicators. the failure and current mileages were 138000.
11/13/200665000105/01/2006
 Dt*: the contact stated while driving 35mph on a street in rainy weather, the brake warning light illuminated. a bystander alerted the contact that the rear brake lights were inoperative. upon initial inspection the contact determined the rear brake wiring harness was wet and corroded from rainwater and it needed to be replaced. the dealer and manufacturer were alerted.
09/18/200687000106/28/2006
 Dt*: the contact stated while the vehicle was parked in an idle position, smoke began coming out from under the hood. there were no warning signals prior to the incident. upon inspection, the cruise control deactivation switch and the brake master cylinder were observed to be completely burnt. the service dealer was contacted, and determined that the fire began in the deactivation switch. the dealer refused to offer a new cruise control deactivation switch and wiring for the electrical system. the manufacturer alerted the contact that replacement parts that were available were defective.
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD
06/19/200787850111/10/2001
 Upon starting the 2001 ford windstar van tuesday morning several of the warning lights stayed on, including the brake and abs lights. the digital odometer display changed from numbers to dashes and the speedometer remained at 0 when driving. also, the air conditioning (a/c ) stopped working. i took it to the ford dealership for repair. it took them 2 days to find the problem which turned out to be a defective cruise control deactivation switch. the service dept. manager said we were fortunate that the van did not catch on fire. he told us that the switch had completely melted and had charred the surrounding wires. this problem is very similar to the problem which caused the massive ford recall in 2005, but ford claims that this has never been a problem in their minivans. the ford dealership did repair the damage at a cost of about $700. i did not think to ask at the time if i could have the burned switch. i would like this to go on record in case there are other vans out there with the same problem. perhaps the ford recall needs to be extended to include the windstars as well. i contacted ford by email and was told that there were currently no safety recalls involving this van.*ak
05/02/200768000110/26/2000
 On may 2, 2007 we detected an odor of burning plastic in the house. after searching the house i opened the garage and a large amount of smoke filled the house. the occupants left through the front door, and i proceeded to open the garage door and went out with phone in hand. while i was standing outside a friend's son indicated that there were flames under the van. i went back into the house, got the keys and made an attempt of pushing the van out of the garage. as i took the vehicle out or park i noticed flames coming from the engine compartment at the windshield. i decided that i was not going to be a hero, and i got out of the van and garage. we were afraid of an explosion since the gas tank was filled that day. i called the fire department which extinguished the fire before it spread to the house. i attempted to get a water hose to try to contain the fire, but after four steps, my right knee on which i had surgery three weeks before it gave out on me and i ended up having to go to the emergency room. the van was totaled by the insurance company. my daughter and i did extensive research of the ford web site , and in all cases involving fires ford motor company has not even blinked an eye to pay one cent. why can't the government go after this company that knowingly produced a product that was defective and continued to produce over and over again without taking safety into consideration. we have been fortunate that there were no deaths involved. what is it going to take? *ak
12/03/2003590001
 Within five minutes of turning the vehicle off, a fire started under the hood. *ak
ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH
11/22/2004360001
 Consumer's vehicle was parked with children inside. when one of the children exited the vehicle it was on fire. consumer removed the second child and noticed that fire spread from the dashboard to the rear of the vehicle.*ak
09/24/2004520003
 While driving dashboard lights illuminated intermittently. the odometer went out. consumer stopped the vehicle to look under the hood. there were little sparks of fire under the hood. the wiring that were connected to the master cylinder melted. there was brake fluid leaking down on the wiring. *ak
07/05/20044600025
 Driver side electric window stopped working a couple of weeks ago. at first i was annoyed at having to open the door at toll booths etc, then it occurred to me that its also a big safety problem if i am ever in an accident. i will have it fixed at my next service soon, but if there are similar problems with other owners then perhaps nhtsa and ford should put out a recall notice. *ak
12/19/2003375003011/01/2001
 Over thirty separate warranty repairs over two years. faulty electrical door locks (kids couldn't exit), transmission leakage, transmission failure, front-end defects with loud thumping noises and several body problems. most notable body problems are wind noise and water leakage through doors and windows. most recently, the fuel pump failed (@ 37,000 miles). ford has all along refused to acknowledge the problems. now that the vehicle is out of warranty, they have again said they will not doing anything. the vehicle is unreliable and unsafe to operate.*ak
12/10/200257000007/17/2001
 The dash shorted out. causing the heater, fan, and radio to staop working. i had already taken the van in for the earlier recall and the seal was replaced. then it shorted again and this time i had to pay for it.

Some parts © 2024 Advameg, Inc.
Based on public records. Inadvertent errors are possible.
This web site is not associated with, endorsed by, or sponsored by and has no official or unofficial affiliation with the vehicle's manufacturer.