Four Winds Dutchmen Express 2003
Model Dutchmen Express made in 2003 by Four Winds got 1 investigation as well as 4 recalls. The car had one investigation (fuel system, gasoline). There were some recalls concerningelectrical system and engine and engine cooling.
Model 2003
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM - WIRING | ||||||||||||||||
| 04V513000 | FOUR WINDS INTERNATIONAL | from 09/01/2002 to 01/31/2004 | V (Vehicle) | 1107 | MFR | FOUR WINDS INTERNATIONAL | 10/28/2004 | 10/28/2004 | ||||||||
| Defect Summary | On motor homes built on ford e-series chassis , a diode in the anti-lock braking system (abs) module may experience an electrical short. | |||||||||||||||
| Consequence Summary | The electrical short may cause an abs malfunction that would illuminate the abs warning light, or the module may overheat resulting in a burning odor, smoke, and/or fire. this condition may occur while the vehicle is being driven or unattended. | |||||||||||||||
| Corrective Summary | Ford motor company is conducting the owner notification and remedy for this campaign. dealers will install a new fuse in the abs circuit and install a heat shield over the abs module. owners should contact ford at 1-800-392-3673 or four winds at 937-295-2983. | |||||||||||||||
| Notes | Customers can also contact the national highway traffic safety administration | |||||||||||||||
| ENGINE AND ENGINE COOLING | ||||||||||||||||
| 04V529000 | FOUR WINDS INTERNATIONAL | from 09/01/2002 to 07/31/2004 | V (Vehicle) | 1380 | MFR | FOUR WINDS INTERNATIONAL | 10/27/2004 | 11/03/2004 | ||||||||
| Defect Summary | On motor homes built on ford e-series chassis, the air filter element material process resulted in an air filter paper element that can smolder or burn. this change in filter paper composition combined with the configuration of the air induction system, may allow hot carbon particles to contact the air filter element during certain driving conditions that create hot particles. | |||||||||||||||
| Consequence Summary | These hot particles may ignite the air filter element with the potential for air induction system damage or underhood fire. | |||||||||||||||
| Corrective Summary | Ford is conducting the owner notification and remedy for this campaign. dealers will inspect and replace the air filter element. owners should contact ford at 1-800-392-3673 or four winds at 937-295-2983. | |||||||||||||||
| Notes | Customers can also contact the national highway traffic safety administration | |||||||||||||||
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
| 03V449000 | FOUR WINDS INTERNATIONAL | from 06/19/1999 to 06/30/2002 | V (Vehicle) | 12918 | ODI | FOUR WINDS INTERNATIONAL | 11/04/2003 | 11/05/2003 | ||||||||
| Defect Summary | On certain travel trailers equipped with samsung microwave ovens, these ovens were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a jumper or jump wire. this may cause the oven to activate without pressing any key pads. | |||||||||||||||
| Consequence Summary | An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire. | |||||||||||||||
| Corrective Summary | Samsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or four winds at 1-219-266-1111. | |||||||||||||||
| Notes | Customers can also contact the national highway traffic safety administration | |||||||||||||||
| FUEL SYSTEM, GASOLINE | ||||||||||||||||
| 04V148000 | FOUR WINDS INTERNATIONAL | from 09/01/2002 to 02/28/2003 | V (Vehicle) | 99 | 04/05/2004 | ODI | FOUR WINDS INTERNATIONAL | 03/25/2004 | 03/29/2004 | |||||||
| Defect Summary | Certain motorhomes were manufactured with generators that could receive excess fuel supply pressure when the chassis engine is in operation. | |||||||||||||||
| Consequence Summary | This could result in rough generator engine operation due to flooding and potential gasoline leakage which could result in a fire causing death or injury to the occupants. | |||||||||||||||
| Corrective Summary | Dealers will mount a regulator bracket and reroute the fuel line to the back side of the generator. the recall began april 5, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact four winds at 1-574-266-1111. | |||||||||||||||
| Notes | Four winds recall no r030005.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE | ||||||
| PE04029 | FOUR WINDS INTERNATIONAL | 03/15/2004 | 05/07/2004 | FUEL LEAKAGE | 04V148000 | |
| In late may 2003, four winds international notified owners of certain class | ||||||