Freightliner Argosy 2000
Model Argosy made in 2000 by Freightliner got 7 recalls as well as 1 service bulletin. Technical service bulletines regarding engine and engine cooling. There were some recalls concerningelectrical system and service brakes, air.
Model 2000
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | ||||||||||||||||
00V082000 | FREIGHTLINER CORPORATION | from 11/01/1998 to 02/28/2000 | V (Vehicle) | 1073 | 06/30/2000 | MFR | FREIGHTLINER LLC | 03/17/2000 | 03/22/2000 | |||||||
Defect Summary | Vehicle description: heavy duty trucks equipped with certain 12 volt power outlets. an unplugged hole in the floorboard can allow road salts and moisture into an area where a 12 volt power outlet is mounted. | |||||||||||||||
Consequence Summary | A short between the outlet terminals could develop causing an electrical fire. | |||||||||||||||
Corrective Summary | Dealers will inspect all vehicles to determine if a floorboard plug was installed. on vehicles found without a plug, a new outlet and plug will be installed. | |||||||||||||||
Notes | Owner notification began june 30, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
SERVICE BRAKES, AIR - ANTILOCK | ||||||||||||||||
00V232002 | FREIGHTLINER CORPORATION | from 02/13/1998 to 08/03/2000 | V (Vehicle) | 35405 | 08/29/2000 | MFR | FREIGHTLINER LLC | 08/07/2000 | 08/09/2000 | |||||||
Defect Summary | Vehicle description: heavy duty trucks and school bus chassis built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal. | |||||||||||||||
Consequence Summary | This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. this could result in extended braking distances and a possible crash. | |||||||||||||||
Corrective Summary | Dealers will replace the abs ecu. | |||||||||||||||
Notes | Owner notification began august 29, 2000, to school buses and emergency vehicle customers. owners of the remaining population were sent letters on september 9, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
SERVICE BRAKES, AIR - CONTROLS | ||||||||||||||||
01V189001 | FREIGHTLINER CORPORATION | from 09/19/2000 to 02/10/2001 | V (Vehicle) | 4400 | 10/17/2001 | MFR | FREIGHTLINER LLC | 06/14/2001 | 06/14/2001 | |||||||
Defect Summary | Vehicle description: vehicles equipped with certain haldex brake system two and four port relay valves. the valve may stick open when a high-pressure application is released. | |||||||||||||||
Consequence Summary | When the valve sticks open, it can result in a total loss of air from either the service or the park brake system. the driver may lose braking ability under a service application, possibly resulting in a vehicle crash. | |||||||||||||||
Corrective Summary | Dealers will replace these valves. owner notification began october 17, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712. | |||||||||||||||
Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
STEERING - LINKAGES - TIE ROD ASSEMBLY | ||||||||||||||||
01V140007 | FREIGHTLINER CORPORATION | from 04/30/2000 to 06/30/2000 | V (Vehicle) | 75000 | 11/08/2001 | MFR | FREIGHTLINER LLC | 09/17/2001 | 10/17/2001 | |||||||
Defect Summary | Vehicle description: heavy duty trucks equipped with trw tie rod ends on certain meritor axles. the tie rod and drag link ball stud ends contain bearings that are below the specified case depth and/or hardness. | |||||||||||||||
Consequence Summary | This can lead to premature wear with possible separation of the ball stud from the socket, increasing the risk of loss of control of the vehicle. | |||||||||||||||
Corrective Summary | Dealers will remove and replace all affected tie rods and drag links with different designed ends. owner notification began november 8, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712. | |||||||||||||||
Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
SUSPENSION - FRONT - HUB | ||||||||||||||||
03V112000 | FREIGHTLINER CORPORATION | from 08/01/1998 to 02/28/2001 | V (Vehicle) | 5716 | 09/20/2003 | ODI | FREIGHTLINER LLC | 03/21/2003 | 03/26/2003 | |||||||
Defect Summary | On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely. | |||||||||||||||
Consequence Summary | Seizure of the bearings can cause wheel separation or wheel end fire. | |||||||||||||||
Corrective Summary | Dealers will replace both front hubs. owner notification is expected to begin on or before september 20, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712. | |||||||||||||||
Notes | Freightliner recall no. fl-407.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
SUSPENSION - REAR - SPRINGS - AIR SUSPENSION SYSTEM | ||||||||||||||||
00V081000 | FREIGHTLINER CORPORATION | from 12/01/1999 to 02/17/2000 | V (Vehicle) | 13545 | 08/07/2000 | MFR | FREIGHTLINER LLC | 03/17/2000 | 03/22/2000 | |||||||
Defect Summary | Vehicle description: heavy duty trucks built with dual leaf spring type air ride suspensions and vehicles built with single leaf spring type air ride suspensions. rear suspension springs can fracture through the center bolt hole after vehicle assembly. | |||||||||||||||
Consequence Summary | If undetected, the rear end of the spring could separate from the vehicle causing a hazardous road debris situation. | |||||||||||||||
Corrective Summary | For vehicles equipped with single leaf springs, dealers will remove and replace all springs. for vehicles equipped with dual leaf springs, dealers will inspect for cracked springs and replace if cracked. | |||||||||||||||
Notes | Owner notification began august 7, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
TRAILER HITCHES - FIFTH WHEEL ASSEMBLY | ||||||||||||||||
03V227000 | FREIGHTLINER CORPORATION | from 09/03/1999 to 04/14/2003 | V (Vehicle) | 2000 | 11/12/2003 | MFR | FREIGHTLINER LLC | 06/17/2003 | 06/19/2003 | |||||||
Defect Summary | On certain truck tractors equipped with jost international jsk 37u series fifth wheels, a fatigue crack can develop in the bracket pin weld under certain loading conditions. | |||||||||||||||
Consequence Summary | If left undetected or corrected it could lead to the separation of the fifth wheel top plate from its mounting structure, possibly resulting in a crash. | |||||||||||||||
Corrective Summary | Dealers will replace the bracket pins and repair instructions free of charge. owner notification began november 12, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jost international at 616-846-7700 or by email to recall@jostinternational.com or freightliner at 1-800-547-0712. | |||||||||||||||
Notes | Freightliner recall no. fl-411.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||||
SF230AC | 12/01/2001 | 629049 | Field service campaign for vehicles with the charge air cooler piping rubbing against the engine tunnel when the engine is under severe load. *tt | 03/26/2002 |