Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, DIESEL | ||||||||||||||||
11V478000 | DAIMLER TRUCKS NORTH AMERICA | from 07/11/2003 | V (Vehicle) | 73500 | 02/21/2012 | MFR | FREIGHTLINER LLC | 09/16/2011 | 09/21/2011 | |||||||
Defect Summary | Daimler trucks is recalling certain model year 2004 through 2008 heavy trucks manufactured from july 11, 2003, through september 28, 2007, equipped with epa04 model mbe4000 engines built with plastic low pressure fuel lines and fuel filters mounted near the center of the engine on the left-hand side. the plastic low pressure fuel line between engine mounted fuel filter and engine block may develop a substantial diesel fuel leak. | |||||||||||||||
Consequence Summary | This could create a road hazard increasing the risk of a crash. fuel leakage, in the presence of an ignition source, could result in a fire. | |||||||||||||||
Corrective Summary | Daimler trucks will notify owners and the remedy will be performed by detroit diesel corporation authorized repair facilities. vehicles will be inspected and the plastic low pressure fuel line will be replaced with a steel low pressure fuel line. this service will be performed free of charge. an interim letter was mailed to owners on october 28, 2011. the safety recall began on february 21, 2012. owners may contact daimler trucks at 1-800-547-0712. | |||||||||||||||
Notes | Daimler trucks' campaign number is 11c-2.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
FUEL SYSTEM, GASOLINE - DELIVERY | ||||||||||||||||
07V335000 | FREIGHTLINER LLC | from 12/01/2006 to 02/18/2007 | V (Vehicle) | 4299 | 10/04/2007 | MFR | FREIGHTLINER LLC | 08/02/2007 | 08/02/2007 | |||||||
Defect Summary | On certain trucks, a manufacturing error in the fuel-water separator preheater thermoswitch may prevent the fuel preheater from turning off if the ignition is left on. if the ignition switch is left on when fuel is added to the fuel- water separator at the factory or during a filter element change, a small flame may occur inside the filter cover. | |||||||||||||||
Consequence Summary | The potential exists for the flame to spread resulting in possible personal injury. | |||||||||||||||
Corrective Summary | Dealers will inspect the fuel filter date code and thermoswitch lot code to determine if they contain the suspect component free of charge. the recall began on october 4, 2007. owners may contact freightliner at 1-800-547-0712. | |||||||||||||||
Notes | Freightliner recall no. fl-508.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, DIESEL - STORAGE - TANK ASSEMBLY | |||||
FSB-20-67 | 08/01/2011 | 10041425 | Freightliner: tank seams are split/cracked which causes fuel to leak. the valve might be plugged with contaminate. *pe | 10/03/2011 | |
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY | |||||
SB-49-29 | 01/01/2011 | 10039646 | Ready | 08/08/2011 | |
SB-49-29 | 01/01/2011 | 10039646 | Freightliner llc: on vehicles with a fuel tank cover installed there may be cover mounting fasteners that are too long. they may dig into the tank. *rm | 08/08/2011 |