Freightliner Columbia 1999
Model Columbia made in 1999 by Freightliner got 4 investigations there are 2 recalls as well as 4 service bulletins. Technical service bulletines regarding exterior lighting, (pws) and steering. The car had some investigations: service brakes, air, wheels. There were some recalls concerningservice brakes, air, suspension.
Model 1999
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
SERVICE BRAKES, AIR - ANTILOCK | ||||||||||||||||
00V232002 | FREIGHTLINER CORPORATION | from 02/13/1998 to 08/03/2000 | V (Vehicle) | 35405 | 08/29/2000 | MFR | FREIGHTLINER LLC | 08/07/2000 | 08/09/2000 | |||||||
Defect Summary | Vehicle description: heavy duty trucks and school bus chassis built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal. | |||||||||||||||
Consequence Summary | This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. this could result in extended braking distances and a possible crash. | |||||||||||||||
Corrective Summary | Dealers will replace the abs ecu. | |||||||||||||||
Notes | Owner notification began august 29, 2000, to school buses and emergency vehicle customers. owners of the remaining population were sent letters on september 9, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
SUSPENSION - FRONT - HUB | ||||||||||||||||
03V112000 | FREIGHTLINER CORPORATION | from 08/01/1998 to 02/28/2001 | V (Vehicle) | 5716 | 09/20/2003 | ODI | FREIGHTLINER LLC | 03/21/2003 | 03/26/2003 | |||||||
Defect Summary | On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely. | |||||||||||||||
Consequence Summary | Seizure of the bearings can cause wheel separation or wheel end fire. | |||||||||||||||
Corrective Summary | Dealers will replace both front hubs. owner notification is expected to begin on or before september 20, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712. | |||||||||||||||
Notes | Freightliner recall no. fl-407.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
EXTERIOR LIGHTING - TURN SIGNAL | |||||
TSB-54-237 | 07/01/2009 | 10029425 | Freightliner: a new bulb socket is available for turn/park lights that is metalized to withstand high heat without out gassing. model years unknown. models columbia, business class m2 and cascadia. *pe | 07/08/2009 | |
(PWS) | |||||
SB42-68 | 12/01/2012 | 10049539 | Freightliner: brake s-cam tube lubrication interval change. to ensure optimum service life and trouble-free operation, the recommended maintenance interval for lubricating meritor s-cam brake tubes on century class, columbia, cascadia and c | 01/16/2013 | |
STEERING - LINKAGES - TIE ROD ASSEMBLY | |||||
SB-46-47 | 10/01/2009 | 10031824 | Freightliner truck: inner tie rod inspection and repair, rack and pinion gear. increased length of the driver side inner tie rod (if the inner tie rod unthreads from the rack) may cause abnormal steer tire wear due to high toe in or an in | 01/13/2010 | |
STEERING - RACK AND PINION | |||||
SB-46-47 | 10/01/2009 | 10031824 | Freightliner truck: inner tie rod inspection and repair, rack and pinion gear. increased length of the driver side inner tie rod (if the inner tie rod unthreads from the rack) may cause abnormal steer tire wear due to high toe in or an in | 01/13/2010 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
SERVICE BRAKES, AIR - SUPPLY - HOSES, LINES/PIPING, AND FITTINGS | ||||||
PE03005 | FREIGHTLINER LLC | 02/07/2003 | 08/22/2003 | FRONT BRAKE AIR HOSE LEAKS | ||
Certain 1998-2001 freightliner century and columbia vehicles exhibit a higher rate of front brake air hose leaks than earlier vintage freightliner vehicles.the leaks have been frequently discovered at fmcsa roadside inspections since these inspections are conducted with the brakes applied (pressurizing the air hose) whereas driver pre-trip inspections may not always be performed with the brakes applied. after a thorough technical review of this matter,odi has concuded that while the subject vehicles exhibit a higher rate of front brake air hose leaks than earlier vintage and peer vehicles, these leaks appear to be minor. freightliner has extended the warranty for this component to 5 years, 500,000 miles and will assist in alerting those vehicle owners whose vehicles are most susceptible to front brake air hose leakage by issuing a service bulletin alerting those owners to the potential for front brake air hose leakage to occur. see attached report for full technical details. | ||||||
WHEELS | ||||||
PE02088 | FREIGHTLINER LLC | 11/22/2002 | 05/01/2003 | INTEGRAL HUB AND BEARING ASSEMBLY | 03E019000 | |
Freightliner submitted a defect report on march 21, 2003 in which they identified approximately 5000 trucks as possibly beingaffected by this problem.arvinmeritor (front axle mfr) submitted a defect report onapril 16, 2003, which identifies 6098 freightliner trucks asbeing affected by this recall and 1191 axles sold to freightliner in the aftermarket. odi notes that there are twointegral hub and bearing assemblies per front axle.freightliner identified vehicles includingfreightliner,sterling, and western star brand name as beingaffected by this recall.see attached summary report for additional details. | ||||||
PE02088 | FREIGHTLINER LLC | 11/22/2002 | 05/01/2003 | INTEGRAL HUB AND BEARING ASSEMBLY | 03V112000 | |
Freightliner submitted a defect report on march 21, 2003 in which they identified approximately 5000 trucks as possibly beingaffected by this problem.arvinmeritor (front axle mfr) submitted a defect report onapril 16, 2003, which identifies 6098 freightliner trucks asbeing affected by this recall and 1191 axles sold to freightliner in the aftermarket. odi notes that there are twointegral hub and bearing assemblies per front axle.freightliner identified vehicles includingfreightliner,sterling, and western star brand name as beingaffected by this recall.see attached summary report for additional details. | ||||||
PE02088 | FREIGHTLINER LLC | 11/22/2002 | 05/01/2003 | INTEGRAL HUB AND BEARING ASSEMBLY | 03E026000 | |
Freightliner submitted a defect report on march 21, 2003 in which they identified approximately 5000 trucks as possibly beingaffected by this problem.arvinmeritor (front axle mfr) submitted a defect report onapril 16, 2003, which identifies 6098 freightliner trucks asbeing affected by this recall and 1191 axles sold to freightliner in the aftermarket. odi notes that there are twointegral hub and bearing assemblies per front axle.freightliner identified vehicles includingfreightliner,sterling, and western star brand name as beingaffected by this recall.see attached summary report for additional details. |