Freightliner Freightliner 1983
Model Freightliner made in 1983 by Freightliner got 1 investigation as well as 4 recalls. The car had one investigation (suspension). There were some recalls concerningengine and engine cooling and service brakes, air.
Model 1983
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | ||||||||||||||||
84V042000 | FREIGHTLINER CORP. | from 09/01/1983 to 03/01/1984 | V (Vehicle) | 8500 | 04/30/1984 | MFR | FREIGHTLINER LLC | 03/29/1984 | 04/04/1984 | |||||||
Defect Summary | Engine cooling fan is made of a plastic outer ring and blade molded to a metal center. the fan blades can separate from the hub and disintegrate without warning. | |||||||||||||||
Consequence Summary | ||||||||||||||||
Corrective Summary | Immediate replacement of defective fan with an all metal fan will be done free of charge. | |||||||||||||||
Notes | Vehicle description: heavy trucks.system: engine and engine cooling; cooling fan.consequences of defect: should blade separation and disintegration occur whilethe vehicle is being serviced with the cab tilted or hood released and theengine running, severe bodily injury may result. | |||||||||||||||
SERVICE BRAKES, AIR - SUPPLY - HOSES, LINES/PIPING, AND FITTINGS | ||||||||||||||||
85V161000 | FREIGHTLINER CORP. | from 03/01/1983 to 08/01/1985 | V (Vehicle) | 20 | 11/07/1985 | MFR | FREIGHTLINER LLC | 12/03/1985 | 12/09/1985 | |||||||
Defect Summary | Rear brake relay valve control line was connected to the secondary double check valve, rather than the primary one. consequence of defect: these trucks have a two axle brake system each on separate systems to avoid total loss of brakes. however with the misconnected lines and if a rupture or leak occurs in the control line, the front and rear axle brakes will fail. | |||||||||||||||
Consequence Summary | ||||||||||||||||
Corrective Summary | Properly connect control line to the primary double check valve. recheck for proper operation of front brakes. | |||||||||||||||
Notes | System: air brakes plumbing.vehicle description: heavy duty low cab forward trucks. model fll6384. | |||||||||||||||
STEERING - LINKAGES | ||||||||||||||||
84V021000 | FREIGHTLINER CORP. | from 01/01/1979 to 02/01/1984 | V (Vehicle) | 4773 | 03/20/1984 | MFR | FREIGHTLINER LLC | 03/02/1984 | 04/04/1984 | |||||||
Defect Summary | A bolt may not have been fully tightened on the pitman arm and retaining screws may not have been installed or may not have been fully tightened. the pitman arm could separate from the steering shaft. | |||||||||||||||
Consequence Summary | ||||||||||||||||
Corrective Summary | A retainer will be installed, or the pitman arm will be replaced, if loose. | |||||||||||||||
Notes | Vehicle description: heavy trucks equipped with sheppard model 392 steeringgear systems.system: steering; pitman arm.consequences of defect: loss of steering would result, possibly causing anaccident. | |||||||||||||||
SUSPENSION - REAR - SPRINGS - AIR SUSPENSION SYSTEM | ||||||||||||||||
84V159000 | FREIGHTLINER CORP. | from 06/01/1981 to 09/01/1984 | V (Vehicle) | 15 | 03/01/1985 | MFR | FREIGHTLINER LLC | 12/20/1984 | 01/07/1985 | |||||||
Defect Summary | A poorly designed bracket which mounts the service/parking brake unit to the rear drive axle may allow damage to brake chamber. damage may cause the spring brake to be applied. | |||||||||||||||
Consequence Summary | ||||||||||||||||
Corrective Summary | Brake chamber support brackets will be replaced with a type that provides the necessary clearance, without cost to the owner. | |||||||||||||||
Notes | Vehicle description: trucks equipped with disc brakes in combination with airsuspension system.system: braking; brake chamber mounting brackets.consequences of defect: loss of vehicle control may occur without priorwarning, resulting in an accident.note: this problem should be corrected immediately. |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
SUSPENSION | ||||||
EA85036 | FREIGHTLINER LLC | 07/31/1985 | 05/22/1987 | FAILURE OF SPRING HANGERS | ||
There is no summary currently available |