Gem Nev 2002

Model Nev made in 2002 by Gem got 2 consumer complains there is 1 recall as well as 1 service bulletin. Consumer complaints with reference, among others things, to electrical system, structure. Technical service bulletines regarding structure. There was one recall concerning electrical system .

Model 2002

Recalls


CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
ELECTRICAL SYSTEM
06V222000GLOBAL ELECTRIC MOTORCARS, LLCfrom 01/01/1999 to 03/31/2004V (Vehicle)2735009/11/2006MFRCHRYSLER GROUP GLOBAL ELECTRIC MOTORCARS06/21/200606/21/2006
Defect SummaryOn certain 2 and 4 passenger, short and long bed low speed vehicles, the 12 volt output from the auxiliary card circuit board (a dc voltage to dc voltage converter) may become inoperative and result in loss of headlamp, tail lamp and turn signal lamp functions.
Consequence SummaryA loss of headlamps could impair a driver's visibility, increasing the risk of a crash. if there is a loss of tail lamp or turn signal lamp function, a following driver may not know when the brakes have been applied or that the vehicle in front is turning, a rear-end crash could occur without prior warning.
Corrective SummaryDealers will replace the auxiliary cards, install a splash/spray protection, and adjust the dash seal free of charge. the recall began on september 11, 2006. owners may contact global electric at 888-871-4367.
NotesGemcar recall no. 002.customers can also contact the national highway traffic safety administration

Bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
STRUCTURE - BODY - DOOR
97A200106/05/200910030358Gem: installation of the riv nut as a replacement to the rubber well nut for the framed canvas door option. in the event of part failure, the rubber well nut will need to be replaced. *pe09/24/2009

Consumer Complaints


Fail datemilesoccurencesPurchase date
ELECTRICAL SYSTEM
01/01/2007105/01/2003
 Tl*the contact owns a 2002 gem nev. the contact received recall notice # 06v222000 regarding the electrical system in january 2007. she called the dealer four times to schedule an appointment for the repair. the technician called her back to schedule, but he never called back to confirm. the contact stated that she waited too long to have the recall repair performed. presently, no failures have occurred. the current mileage is 1,250, and the failure mileage was unknown.*ak
STRUCTURE - FRAME AND MEMBERS
01/01/19011
 2002 global electric motorcar with broken frame. consumer stated that the rear of the frame that holds the rear axle broke in two places. he states other people had the same problem. *kb