Gillig Phantom 2004

Model Phantom made in 2004 by Gillig got 6 recalls as well as 1 service bulletin. Technical service bulletines regarding structure. There were some recalls concerningengine and engine cooling and equipment adaptive.

Model 2004

Recalls


CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
ENGINE AND ENGINE COOLING - ENGINE - DIESEL
04V485000GILLIG CORPORATION V (Vehicle)149MFRGILLIG CORPORATION10/07/200410/13/2004
Defect SummaryOn certain phantom and low floor transit buses equipped with cummins 8.3l and 8.9l isc and isl diesel engines, oil can leak into the engine compartment from a crack in the cup plug.
Consequence SummaryOil leakage on a hot engine can result in an engine compartment fire, possibly resulting in injuries.
Corrective SummaryCummins will conduct the owner notification and remedy for this campaign. cummins will isntall a steel cup plug boss cap on the affected engines. owners should contact cummins customer assistance center at 1-800-343-7357 or gillig at 510-785-1500.
NotesCustomers can also contact the national highway traffic safety administration
EQUIPMENT ADAPTIVE
04V500000GILLIG CORPORATIONfrom 07/01/1999 to 04/30/2004V (Vehicle)24210/08/2004MFRGILLIG CORPORATION10/14/200404/21/2004
Defect SummaryCertain gillig buses equipped with sure-lok wheelchair tie-down securement assemblies. the sprocket teeth of the retractor assembly may be out of alignment causing the load pawl not to fully seat in the sprocket teeth.
Consequence SummaryIn the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries.
Corrective SummaryDealers will inspect and replace the wheelchair securement retractors as necessary. the recall began october 8, 2004. owners should contact gillig at 1-800-735-1500..
NotesCustomers can also contact the national highway traffic safety administration
09V359000GILLIG CORPORATIONfrom 01/01/2001 to 08/31/2009V (Vehicle)199009/23/2009MFRGILLIG CORPORATION09/16/200909/16/2009
Defect SummaryGillig is recalling certain model year 2001 through 2009 phantom transit buses manufactured from january 2001 through august 2009 equipped with lift-u wheelchair lifts. the lifts are equipped with a logic board assembly for the wheelchair lift control box, p/nos. 373-0226 and 373-0265. the outboard ramp barrier could fold in toward a lift passenger possibly pinching the passenger's feet.
Consequence SummaryThe lift passenger could be seriously injured.
Corrective SummaryGillig will notify owners and the repairs will be made by lift-u free of charge. the safety recall is expected to begin during october 2009. owners may contact lift-u at 1-209-838-2400 or gillig service at 1-800-735-1500.
NotesOwners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
FUEL SYSTEM, DIESEL
06V427000GILLIG CORPORATIONfrom 08/01/2003 to 05/31/2005V (Vehicle)196111/22/2006MFRGILLIG CORPORATION11/09/200611/09/2006
Defect SummaryOn certain transit buses built with cummins isl and isc diesel engines equipped with the cm850 fuel system, the engine high pressure fuel lines, from the engine high pressure pump to the engine fuel rail, are prone to failure.
Consequence SummaryFailure of the line introduces high pressure fuel spray into the engine compartment which can ignite when it comes in contact with a hot surface.
Corrective SummaryCummins will install a fuel line bracket to reduce fuel line stress. a new fuel line will be installed when adding the bracket (please see 06e037). gillig notified customers on november 22, 2006. customers may contact cummins at 1-800-343-7357 or gillig at 510-264-5031.
NotesCustomers may also contact the national highway traffic safety administration
INTERIOR LIGHTING
09V368000GILLIG CORPORATIONfrom 01/01/2001 to 09/24/2009V (Vehicle)105309/29/2009MFRGILLIG CORPORATION09/28/200909/28/2009
Defect SummaryGillig corporation is recalling certain model year 2001 through 2009 transit buses manufactured between january 2001 and september 2009 equipped with luminator horizon led side destination signs. the connector board can corrode due to an accumulation of moisture under the connector.
Consequence SummaryA short could occur, possibly causing smoke and fire.
Corrective SummaryGillig will notify owners and luminator will repair the buses free of charge. the safety recall began on spetember 29, 2009. owners may contact luminator at 1-972-516-3033 or gillig field services at 1-800-735-1500.
NotesOwners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
STEERING - LINKAGES - TIE ROD ASSEMBLY
04V610000GILLIG CORPORATIONfrom 07/01/2004 to 11/30/2004V (Vehicle)324MFRGILLIG CORPORATION12/28/200412/28/2004
Defect SummaryOn some buses, certain tie rod clamps installed on tie rod assemblies could fail and lead to a steering malfunction.
Consequence SummaryIf both clamps were to fail and the cross tube start to unscrew, significant vehicle misalignment would evolve with the potential for the tie rod end to separate from the cross tube, resulting in loss of steering control and possibly resulting in a vehicle crash.
Corrective SummaryArvin-meritor will notify gillig customers and conduct the remedy at no charge to the customer. owners should contact arvin-meritor at 1-248-435-1000 or gillig at 1-510-785-1500.
NotesCustomers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-327-4236.

Bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
STRUCTURE - BODY
FS-2012-0201/13/201210044128Gillig: gillig's recommendations for the underbody maintenance can be found in chapter 11 of your service manual. *js05/14/2012