Glaval Apollo 2007
Model Apollo made in 2007 by Glaval got 10 recalls. There were some recalls concerningequipment, equipment adaptive and interior lighting.
Model 2007
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| EQUIPMENT | ||||||||||||||||
| 12V580000 | Glaval Bus Division | from 01/01/2007 to 12/03/2012 | V (Vehicle) | 704 | MFR | Glaval Bus Division | 12/10/2012 | 12/13/2012 | ||||||||
| Defect Summary | Glaval bus is recalling certain model year 2007-2012 transit buses, models: entourage, sport, universal, titan, titan ii, apollo, primetime, and concord; and manufactured january 1, 2007, through december 3, 2012. the buses are equipped with a ricon manufactured wheelchair lift which has an optional armored pendant cable. the cable may have been installed such that it doesn't clear the wheelchair lift and without a protective cover, or a misinstalled protective cover. | |||||||||||||||
| Consequence Summary | The cable may contact the power lug at the base of the wheel chair lift causing a short circuit that could result in a fire. | |||||||||||||||
| Corrective Summary | Glaval bus will notify owners and direct them to contact ricon. ricon will provide a supplemental cover kit and instructions, free of charge. this recall campaign is expected to begin in january, 2013. owners may contact glaval bus at 1-574-262-2212 or ricon at 1-818-267-3000. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov. | |||||||||||||||
| 10V618000 | GLAVAL BUS DIVISION | from 08/01/1999 to 07/31/2007 | V (Vehicle) | 119 | MFR | GLAVAL BUS DIVISION | 11/23/2010 | 12/14/2010 | ||||||||
| Defect Summary | Glaval is recalling certain model year 2002, 2003, 2006, 2007, and 2008 ford e350/e450 universal, chevy/gmc 4500/5500 titan and freightliner mb-55 apollo transit buses manufactured from august 1999 through july 2007, and equipped with a trans/air ta73 evaporator. the evaporator utilizes a power resistor to regulate blower speed. should a short occur in the low or medium speed circuit while the blower is in high speed, the short will cause the supply voltage to feedback through the resistor to ground, not drawing enough current to trip the fuse. | |||||||||||||||
| Consequence Summary | This would cause the resistor temperature to rise to a point where it will melt and possibly ignite the plastic blower housing to which it is mounted. the overheating can result in a fire. | |||||||||||||||
| Corrective Summary | Glaval in cooperation with trans air will install a thermal shutdown device in series with the speed resistors. this service will be performed free of charge. the safety recall is expected to begin late december 2010 or early january 2011. owners may contact trans air warranty and service center at 1-800-673-2446. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| EQUIPMENT ADAPTIVE | ||||||||||||||||
| 12V321000 | GLAVAL BUS DIVISION | V (Vehicle) | 381 | ODI | GLAVAL BUS DIVISION | 07/09/2012 | 07/09/2012 | |||||||||
| Defect Summary | Glaval is recalling certain buses equipped with braun century-2 and/or vista-2 wheelchair lifts. over time and with frequent use, the roll stop latches on the outer barrier may become bent or misaligned. | |||||||||||||||
| Consequence Summary | A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. if this occurs when the lift platform is in an elevated position, the wheelchair | |||||||||||||||
| Corrective Summary | Glaval will notify owners, and the repairs will be performed by authorized braun dealers free of charge. owners may contact glaval bus at 1-800-347-7440. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||
| 10V143000 | GLAVAL BUS DIVISION | from 12/01/2007 to 12/31/2009 | V (Vehicle) | 302 | 04/26/2010 | MFR | GLAVAL BUS DIVISION | 04/12/2010 | 04/12/2010 | |||||||
| Defect Summary | Glaval bus is recalling certain model year 2006 through 2010 universal, titan, titan ii, primetime, sport, and apollo transit buses manufactured between december 2007 and december 2009 fitted with ricon public use lifts. the restraint belt on these lifts was designed to prevent the lift from moving, unless the tongue of the belt is fully engaged and latched in the buckle. ricon has discovered, however, that it is possible for the operator to insert the belt tongue into the buckle without fully engaging the latching mechanism. in this case, the restraint belt would appear to be latched, and the operator could run the lift. if the restraint belt tongue is not fully engaged into the restraint belt buckle, and latched, the lift may operate with an occupant on the platform. | |||||||||||||||
| Consequence Summary | The user of the lift could be injured should the lift move without the restraint belt properly buckled. | |||||||||||||||
| Corrective Summary | Glaval bus is working with ricon and ricon will be performing the remedy for this campaign. please see ricon's defect report 09e-060. ricon will provide customers with a warning decal and a dvd-based training aid. the safety recall began on april 26, 2010. owners may contact ricon at 1-818-267-3000 or glaval bus at 1-800-322-2884. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| 10V144000 | GLAVAL BUS DIVISION | from 10/01/2007 to 12/31/2009 | V (Vehicle) | 132 | 04/26/2010 | MFR | GLAVAL BUS DIVISION | 04/12/2010 | 04/13/2010 | |||||||
| Defect Summary | Glaval bus is recalling certain model year 2007 through 2010 transit buses manufactured between october 2007 through december 2009, equipped with certain ricon s series and k series l-model wheelchair lifts. due to a problem in the software that controls the lift's up function, should the up switch be released before the floor level limit switch is activated, the lift may continue its upward travel and may overrun the floor level cut off point. | |||||||||||||||
| Consequence Summary | When the platform overruns the vehicle floor level and stops at an angle from 15-20 degrees, it is possible for a person in a wheelchair to tip over and for someone standing on the platform to fall, possibly resulting in injuries. | |||||||||||||||
| Corrective Summary | Glaval bus will notify owners and the repairs will be performed by authorized ricon dealers free of charge. a software solution for this safety defect is under investigation. until the software solution is available, ricon will provide owners with a bulletin outlining proper wheelchair lift operation and will ship owners a dvd-based training aid to promote proper lift operation at no cost. the safety recall began on april 26, 2010. owners may contact ricon at 1-818-267-3000 or glaval bus at 1-800-322-2884. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| 08V014000 | GLAVAL BUS DIVISION | from 07/18/2005 to 07/06/2006 | V (Vehicle) | 215 | MFR | GLAVAL BUS DIVISION | 01/20/2008 | 01/10/2008 | 571 | 404 | ||||||
| Defect Summary | Certain transit buses equipped with braun platform lifts fail to comply with the requirements of federal motor vehicle safety standard no. 404, platform lift installations in motor vehicles. a passenger can approach the exposed lift doorway without the audible alarm alerting them of their proximity to the threshold. | |||||||||||||||
| Consequence Summary | Should the threshold warning system fail to operate, the lift user can fall from the vehicle and be seriously injured. | |||||||||||||||
| Corrective Summary | Glaval is working with braun corporation to have the doorway lift fixed free of charge (please see 06e094). owners may contact braun corporation at 1-800-946-7513 or glaval at 1-574-262-2212. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||
| 08V155000 | GLAVAL BUS DIVISION | V (Vehicle) | 466 | 05/10/2008 | MFR | GLAVAL BUS DIVISION | 04/07/2008 | 04/07/2008 | ||||||||
| Defect Summary | Glaval bus is recalling 466 buses equipped with ricon platform style wheelchair lifts. these buses fail to comply with the requirements of federal motor vehicle safety standard no. 404, platform lift installations in motor vehicles. the threshold warning system may not detect the presence of a wheelchair or mobility aid user in a certain spot within the defined threshold area. | |||||||||||||||
| Consequence Summary | The user of the lift could be injured should the lift move unintentionally. | |||||||||||||||
| Corrective Summary | Glaval bus is working with ricon to correct the wheelchair lifts free of charge (please see 07e095). the recall began on may 10, 2008. owners may contact ricon at 1-800-322-2884 or glaval bus at 1-574-262-2212. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
| EQUIPMENT - ELECTRICAL - AIR CONDITIONER | ||||||||||||||||
| 12V011000 | GLAVAL BUS DIVISION | from 01/02/2006 to 12/31/2010 | V (Vehicle) | 1407 | ODI | GLAVAL BUS DIVISION | 01/13/2012 | 01/13/2012 | ||||||||
| Defect Summary | Glaval is recalling certain model year 2006 through 2007 transit buses built on ford, gmc, chevrolet, and freightliner chassis and equipped with carrier genv em-1 evaporator units. due to time, temperature, and/or vibration, the fuse may loosen in the fuse holder resulting in high resistance and arcing. | |||||||||||||||
| Consequence Summary | If sufficient arcing occurs, the fuse holder may melt, and a vehicle fire may occur. | |||||||||||||||
| Corrective Summary | Glaval will notify owners and provide information on how to obtain the retrofit kit from carrier along with repair instructions. this service will be performed free of charge. the recall is expected to begin during january 2012. (see carrier's recall campaign 11e-003.) owners may contact carrier at 1-800-348-7440. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| INTERIOR LIGHTING | ||||||||||||||||
| 09V421000 | GLAVAL BUS DIVISION | V (Vehicle) | 161 | 11/10/2009 | MFR | GLAVAL BUS DIVISION | 10/28/2009 | 10/30/2009 | ||||||||
| Defect Summary | Glaval bus is recalling certain model year 2001 through 2009 transit buses equipped with luminator horizon led side destination signs. the connector board can corrode due to an accumulation of moisture under the connector. | |||||||||||||||
| Consequence Summary | A short could occur, possibly causing smoke and fire. | |||||||||||||||
| Corrective Summary | Glaval bus will notify owners and luminator will repair the buses free of charge. please see luminator's defect report 09e-054. the safety recall began on november 10, 2009. owners may contact luminator at 1-972-516-3033 or glaval bus at 1-574-262-2212. | |||||||||||||||
| Notes | Glaval bus' recall campaign number is 17744.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| STEERING | ||||||||||||||||
| 07V306000 | FREIGHTLINER LLC | from 04/17/2007 to 06/27/2008 | V (Vehicle) | 18000 | 12/21/2007 | MFR | GLAVAL BUS DIVISION | 07/18/2007 | 07/18/2007 | |||||||
| Defect Summary | Freightliner is recalling certain school bus chassis, heavy trucks, van chassis, rv motorhome chassis manufactured from january 5 to may 17, 2007, equipped with axle alliance company (aac) front axles. during the front axle assembly, the fasteners that attach the steering arm or tie rod arms to the spindle may be over or under tightened. | |||||||||||||||
| Consequence Summary | Incorrectly tightened steering arm fasteners may fatigue and fracture which could cause a crash without warning. | |||||||||||||||
| Corrective Summary | Thomas built will notify owners, inspect the fasteners, and replace the steering arm if necessary. the recall began on december 21, 2007. owners can contact freightliner at 1-800-547-0712. | |||||||||||||||
| Notes | Freightliner recall no. fl-501.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||