Gmc C3500 2001
Model C3500 made in 2001 by Gmc got 1 consumer complain, 7 investigations there is 1 recall as well as 10 service bulletins. Consumer complaints with reference to service brakes, hydraulic. . Technical service bulletines regarding engine and engine cooling, equipment and fuel system, gasoline. The car had some investigations: engine and engine cooling, service brakes, hydraulic and steering. There was one recall concerning interior lighting .
Model 2001
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| INTERIOR LIGHTING | ||||||||||||||||
| 01V220000 | GENERAL MOTORS CORP. | from 04/01/2001 to 06/15/2001 | V (Vehicle) | 38863 | 07/09/2001 | MFR | GENERAL MOTORS CORP. | 06/26/2001 | 07/03/2001 | 571 | 105 | |||||
| Defect Summary | Vehicle description: certain pickup trucks equipped with 6.6l diesel engines fail to comply with requirements of fmvss no. 105, hydraulic and electric brake systems. these vehicles have a brake system warning light in the instrument cluster that may not illuminate when the brake fluid is low. in addition, when the brake fluid is low, the vehicle may not meet the partial system requirements of fmvss no. 105. | |||||||||||||||
| Consequence Summary | These conditions could result in reduced braking capability, which could lead to a crash. | |||||||||||||||
| Corrective Summary | Dealers will change the location of a wire connection in the underhood bussed electrical center. owner notification began july 9, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. | |||||||||||||||
| Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| PIP-4695 | 09/01/2009 | 10032435 | Gm: loss of power hesitates on acceleration. 4.3, 4.8, 5.3, 5.7 and 6.0 engines coupled with the 4l60e or 4l65e may experience a condition of hesitates, misses or loss of power under acceleration. the vehicle may operate as if it is in r | 03/24/2010 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
| 020601010 | 03/01/2002 | 632326 | Information on serpentine belt identification and diagnosis for certain hd pickup models. *tt | 07/12/2002 | |
| EQUIPMENT - OTHER - LABELS | |||||
| 01021 | 05/24/2001 | 619770 | Subject regarding certification and tire pressure label information incorrect. *tt | 06/29/2001 | |
| FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||||
| 010604037B | 10/01/2001 | 010604037A | 627790 | Information regarding fuel transfer pump inoperative. *yh | 02/25/2002 |
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| 000730017B | 01/01/2002 | 000730017A | 631802 | Subject regarding service parts resriction program for allison series 1000 automatic transmission. *slc | 06/20/2002 |
| 010730021 | 05/01/2001 | 619742 | This technical service bulletin states that technicians may experience difficulty in removing the connectors from the park / neutral position switch, usually when trying to remove the switch during transmission service. *tt | 06/26/2001 | |
| 010730020 | 04/01/2001 | 619715 | Subject ordering reference table for ordering the new valve body, spacer plate and gasket kit. *tt | 06/25/2001 | |
| UNKNOWN OR OTHER | |||||
| 010856004A | 09/01/2001 | 010856004 | 627635 | Information regarding security lamp illumination on the instument panel, engine stalls. *yh | 02/13/2002 |
| 010730002B | 05/01/2001 | 010730002A | 619741 | Malfunction indicator lamp (mil) is on; the transmission is stuck in third gear; and / or the instrument cluster is inoperative. *tt | 06/26/2001 |
| VISIBILITY - WINDSHIELD WIPER/WASHER - MOTOR | |||||
| 070501 | 05/07/2001 | 619775 | Customer may complain that the wiper motor is inoperative or that the wiper motor fuse blows repeatedly. *tt | 06/29/2001 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | ||||||
| EA06016 | GENERAL MOTORS CORP. | 09/14/2006 | 11/09/2007 | CRANK POSITION SENSOR FAILURE - STALL | 07V521000 | |
| In a letter dated november 7, 2007, general motors (gm) reported to the office of defects investigation (odi) that it will conduct a safety recall (07v-521) to replace the crank position sensor (ckp) in approximately 12,000 model year (my) 2001 chevrolet silverado and gmc sierra vehicles equipped with 8.1 liter engines manufactured on or before november 15, 2000.according to gm, the ckp can fail intermittently or permanently.a permanent ckp failure would result in an engine stall without restart.an intermittent ckp failure could cause the service engine soon light to illuminate, the vehicle to run rough or the engine to stall but allows restart.as a remedy, an improved ckp will be installed in the subject vehicles.the recall campaign will start in december 2007. during the preliminary evaluation (pe06-016), and this ea investigation, gm and odi independently conducted detailed reviews of certain field data to understand the nature and rate of subject vehicle stalling due to ckp failures.gm and odi reviewed gm's warranty claims for the ckp with the objective of ascertaining an estimate of those claims representing an engine stall while driving.the ckp warranty claims without verbatim text were the largest segment of warranty claims.using those claims, gm surveyed vehicle owners to gather additional information to determine if the claim was associated with a stall while driving event.based on the survey, gm estimated that approximately 49% of all warranty repairs for the ckp involved a stall while driving.odi | ||||||
| ENGINE AND ENGINE COOLING - ENGINE | ||||||
| EA06016 | GENERAL MOTORS CORP. | 09/14/2006 | 11/09/2007 | CRANK POSITION SENSOR FAILURE - STALL | 07V521000 | |
| In a letter dated november 7, 2007, general motors (gm) reported to the office of defects investigation (odi) that it will conduct a safety recall (07v-521) to replace the crank position sensor (ckp) in approximately 12,000 model year (my) 2001 chevrolet silverado and gmc sierra vehicles equipped with 8.1 liter engines manufactured on or before november 15, 2000.according to gm, the ckp can fail intermittently or permanently.a permanent ckp failure would result in an engine stall without restart.an intermittent ckp failure could cause the service engine soon light to illuminate, the vehicle to run rough or the engine to stall but allows restart.as a remedy, an improved ckp will be installed in the subject vehicles.the recall campaign will start in december 2007. during the preliminary evaluation (pe06-016), and this ea investigation, gm and odi independently conducted detailed reviews of certain field data to understand the nature and rate of subject vehicle stalling due to ckp failures.gm and odi reviewed gm's warranty claims for the ckp with the objective of ascertaining an estimate of those claims representing an engine stall while driving.the ckp warranty claims without verbatim text were the largest segment of warranty claims.using those claims, gm surveyed vehicle owners to gather additional information to determine if the claim was associated with a stall while driving event.based on the survey, gm estimated that approximately 49% of all warranty repairs for the ckp involved a stall while driving.odi | ||||||
| SERVICE BRAKES, HYDRAULIC | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST - HYDRAULIC | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| STEERING - HYDRAULIC POWER ASSIST - PUMP | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| STEERING - HYDRAULIC POWER ASSIST SYSTEM | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 02/01/2001 | 5000 | 15 | 02/01/2001 |
| Shortly after buying this truck, i was doing less than 20 mph slowing down to stop at a light. i hit a small dump then i heard the abs come on and i roll right through the red light. the dealer told me it must be my driving. after several other similar situations, i had the abs disconected and have not had any other failures. | |||