Gmc C4500 2007
Model C4500 made in 2007 by Gmc got 2 consumer complains there are 2 recalls as well as 22 service bulletins. Consumer complaints with reference, among others things, to engine and engine cooling, power train. Technical service bulletines regarding electrical system, engine and engine cooling and latches/locks/linkages. There were some recalls concerningequipment adaptive, suspension.
Model 2007
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| EQUIPMENT ADAPTIVE | ||||||||||||||||
| 08E004000 | INTERMOTIVE VEHICLE CONTROLS | E (Equipment) | 250 | 11/20/2007 | MFR | GENERAL MOTORS CORP. | 01/07/2008 | 01/08/2008 | ||||||||
| Defect Summary | Certain intermotive wheelchair lift interlock, p/no. ilis605-h3 ilis activation kit (interlock option for gateway 401) sold for use as aftermarket for 2005 - 2008 chevy 560 (c4500 and c5500 kodiak) 6.6l diesel vehicles which a protection diode was used. the diode can be exposed to voltage spikes greater than what it can withstand. the diode could fail, which could prevent vehicle interlock operation when a wheelchair lift is deployed. | |||||||||||||||
| Consequence Summary | Should the diode fail, it will be possible to move the vehicle with the wheelchair deployed, which could result in injury to anyone using the lift. | |||||||||||||||
| Corrective Summary | Intermotive will notify owners and repair the vehicles free of charge. the recall began on november 20, 2007. owners can contact intermotive toll-free at 1-800-969-6080. this recall only pertains to aftermarket intermotive wheelchair lifts and has no relation to any original equipment installed on chevrlot and gmc vehicles manufactured by general motors. | |||||||||||||||
| Notes | Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
| SUSPENSION | ||||||||||||||||
| 07E086000 | LINK MANUFACTURING, LTD | E (Equipment) | 367 | 06/07/2007 | MFR | GENERAL MOTORS CORP. | 10/16/2007 | 10/16/2007 | ||||||||
| Defect Summary | Certain link ultraride rear air suspension systems, model 8m000070, sold for installation as aftermarket equipment on gm chassis models 4500 and 5500, ambulances and shuttle buses. the axle side lateral control bracket of the suspension has cracked in some cases. | |||||||||||||||
| Consequence Summary | If the lateral control rod bracket fractures, the handling of the vehicle will be adversely affected, including possible loss of vehicle control. | |||||||||||||||
| Corrective Summary | Link will notify owners and provide repair kits free of charge and will reimburse for labor and inspection costs. the recall began june 7, 2007. owners can contact link toll-free at 1-800-222-6283. | |||||||||||||||
| Notes | This recall only pertains to aftermarket link suspension systems and has no relation to any original equipment installed on vehicle manufactured by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| SB-09-06-03-004A | 09/01/2009 | SB-09-06-03-004B | 10032332 | Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). | 03/05/2010 |
| ELECTRICAL SYSTEM - WIRING | |||||
| SB-09-06-03-004A | 09/01/2009 | SB-09-06-03-004B | 10032332 | Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). | 03/05/2010 |
| ENGINE AND ENGINE COOLING | |||||
| PIE-0129 | 10/01/2010 | 10037128 | Gm: there may be an engine coolant leak or knock noise. there could be an engine cooling fan break. *rm | 05/09/2011 | |
| PIE-0129 | 10/01/2010 | 10037128 | Ready | 05/09/2011 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| PIE-0169 | 04/01/2011 | 10038749 | Ready | 06/27/2011 | |
| PIE-0169 | 04/01/2011 | 10038749 | Gm: there is an engine coolant leak or engine knock noise. the engine coolant fan may have broken. 2005-2007 kodiak/top kick. *rm | 06/27/2011 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
| PIE-0129 | 10/01/2010 | 10037128 | Gm: there may be an engine coolant leak or knock noise. there could be an engine cooling fan break. *rm | 05/09/2011 | |
| PIE-0129 | 10/01/2010 | 10037128 | Ready | 05/09/2011 | |
| ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
| SB-08-06-04-002 | 01/01/2008 | 10032853 | Chevrolet/gmc: diagnostic and repair information on poor engine performance with dtc p0101-mass air flow sensor performance set. *pe | 06/02/2010 | |
| SB-08-06-04-029B | 07/01/2009 | SB-08-06-04-029C | 10030123 | General motors: lbz, lly, lmm mil/ses light n dtc p0087-fuel rail pressure (frp) too low, lack of performance, no power, engine runs rough, no start (diagnose fuel system components). *pe updated 3/1/10. *pe | 08/05/2009 |
| LATCHES/LOCKS/LINKAGES - DOORS - LATCH | |||||
| 4488 | 12/13/2007 | 4488A | 10023475 | Right outside door handle inoperative. *nj | 12/13/2007 |
| SEAT BELTS - FRONT - RETRACTOR | |||||
| 05-09-40-002E | 10/01/2010 | 10037184 | Gm: service bulletin explaining when the safety belts are supposed to lock. *rm | 05/11/2011 | |
| 05-09-40-002E | 10/01/2010 | 10037184 | Ready | 05/11/2011 | |
| SEAT BELTS - FRONT - WEBBING | |||||
| 05-09-40-002E | 10/01/2010 | 10037184 | Gm: service bulletin explaining when the safety belts are supposed to lock. *rm | 05/11/2011 | |
| 05-09-40-002E | 10/01/2010 | 10037184 | Ready | 05/11/2011 | |
| SERVICE BRAKES, AIR - ANTILOCK - WHEEL SPEED SENSOR | |||||
| PI-00983A | 06/01/2011 | 10039488 | Ready | 08/01/2011 | |
| SERVICE BRAKES, HYDRAULIC | |||||
| PIT-4515A | 10/01/2009 | 10032452 | Gmc/chevrolet: service brake soon indicator with dtc c0272. some customers may state the service brake soon indicator comes on. may also comment the audible brake warning buzzer is sounding. *pe | 03/26/2010 | |
| PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 | |
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - WHEEL SPEED SENSOR | |||||
| PI-00983A | 06/01/2011 | 10039488 | Ready | 08/01/2011 | |
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST | |||||
| PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 | |
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST - HYDRAULIC | |||||
| PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 | |
| STRUCTURE - BODY - DOOR | |||||
| 08-08-64-005 | 04/01/2008 | 10025183 | Passenger side front outside door handle inoperative (replace outside door handle). *pe | 07/16/2008 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||
| 02/12/2008 | 2000 | 2 | 09/01/2007 |
| Truck lost almost all power and barley moved itself from the travel lanes to the side of the road, had to be towed and after a week in the shop! at my business loss .a crank sensor was determined to be faulty,then an e.g.r valve and finally replaced the p.c.m. check engine light still on and off and still weak on power. fuel usage is horrible most of the time 6 -7 mpg. truck currently towed to another dealer for a transmission problem, it wont move!! i found trans to be almost out of fluid. i check fluids regularly. truck has 16k on it now. and this is the second tow, the first at 2,000 miles. *tr | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 02/12/2008 | 2000 | 2 | 09/01/2007 |
| Truck lost almost all power and barley moved itself from the travel lanes to the side of the road, had to be towed and after a week in the shop! at my business loss .a crank sensor was determined to be faulty,then an e.g.r valve and finally replaced the p.c.m. check engine light still on and off and still weak on power. fuel usage is horrible most of the time 6 -7 mpg. truck currently towed to another dealer for a transmission problem, it wont move!! i found trans to be almost out of fluid. i check fluids regularly. truck has 16k on it now. and this is the second tow, the first at 2,000 miles. *tr | |||
Car dealers selling
| State | City | Zip | Name | Phone |
|---|---|---|---|---|
| PA | GLENSHAW | JOE BALL GMC | 412-487-8500 |