Gmc C5500 2005
Model C5500 made in 2005 by Gmc got 2 consumer complains there are 2 recalls as well as 24 service bulletins. Consumer complaints with reference to engine and engine cooling. . Technical service bulletines regarding communications, electrical system and engine and engine cooling. There were some recalls concerningequipment adaptive, suspension.
Model 2005
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
EQUIPMENT ADAPTIVE | ||||||||||||||||
08E004000 | INTERMOTIVE VEHICLE CONTROLS | E (Equipment) | 250 | 11/20/2007 | MFR | GENERAL MOTORS CORP. | 01/07/2008 | 01/08/2008 | ||||||||
Defect Summary | Certain intermotive wheelchair lift interlock, p/no. ilis605-h3 ilis activation kit (interlock option for gateway 401) sold for use as aftermarket for 2005 - 2008 chevy 560 (c4500 and c5500 kodiak) 6.6l diesel vehicles which a protection diode was used. the diode can be exposed to voltage spikes greater than what it can withstand. the diode could fail, which could prevent vehicle interlock operation when a wheelchair lift is deployed. | |||||||||||||||
Consequence Summary | Should the diode fail, it will be possible to move the vehicle with the wheelchair deployed, which could result in injury to anyone using the lift. | |||||||||||||||
Corrective Summary | Intermotive will notify owners and repair the vehicles free of charge. the recall began on november 20, 2007. owners can contact intermotive toll-free at 1-800-969-6080. this recall only pertains to aftermarket intermotive wheelchair lifts and has no relation to any original equipment installed on chevrlot and gmc vehicles manufactured by general motors. | |||||||||||||||
Notes | Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
SUSPENSION | ||||||||||||||||
07E086000 | LINK MANUFACTURING, LTD | E (Equipment) | 367 | 06/07/2007 | MFR | GENERAL MOTORS CORP. | 10/16/2007 | 10/16/2007 | ||||||||
Defect Summary | Certain link ultraride rear air suspension systems, model 8m000070, sold for installation as aftermarket equipment on gm chassis models 4500 and 5500, ambulances and shuttle buses. the axle side lateral control bracket of the suspension has cracked in some cases. | |||||||||||||||
Consequence Summary | If the lateral control rod bracket fractures, the handling of the vehicle will be adversely affected, including possible loss of vehicle control. | |||||||||||||||
Corrective Summary | Link will notify owners and provide repair kits free of charge and will reimburse for labor and inspection costs. the recall began june 7, 2007. owners can contact link toll-free at 1-800-222-6283. | |||||||||||||||
Notes | This recall only pertains to aftermarket link suspension systems and has no relation to any original equipment installed on vehicle manufactured by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
COMMUNICATIONS - HORN ASSEMBLY | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
ELECTRICAL SYSTEM | |||||
SB-09-06-03-004A | 09/01/2009 | SB-09-06-03-004B | 10032332 | Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). | 03/05/2010 |
ELECTRICAL SYSTEM - WIRING | |||||
SB-09-06-03-004A | 09/01/2009 | SB-09-06-03-004B | 10032332 | Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). | 03/05/2010 |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
PIE-0169 | 04/01/2011 | 10038749 | Gm: there is an engine coolant leak or engine knock noise. the engine coolant fan may have broken. 2005-2007 kodiak/top kick. *rm | 06/27/2011 | |
PIE-0169 | 04/01/2011 | 10038749 | Ready | 06/27/2011 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
050604061 | 10/01/2005 | 10017759 | U-haul rental trucks - lack of power, hard start, no start, poor engine performance. *tt | 11/29/2005 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
070605005 | 04/01/2007 | 10022264 | Diesel engine - low engine power/performance, poor acceleration, eshaust smoke/hissing noise, mil/ses on, dtc's p0101, p0236. (install updated engine exhaust brake valve). *kb | 07/24/2007 | |
LATCHES/LOCKS/LINKAGES - DOORS - LATCH | |||||
4488 | 12/13/2007 | 4488A | 10023475 | Right outside door handle inoperative. *nj | 12/13/2007 |
POWER TRAIN - DRIVELINE | |||||
060421003 | 04/01/2007 | 060421003B | 10022261 | Cab vibration/boom noise at highway speeds. (replace transfer case mounts/shims/spacers and install new rear axle sensor). *kb | 07/24/2007 |
SEAT BELTS - FRONT - RETRACTOR | |||||
05-09-40-002E | 10/01/2010 | 10037184 | Gm: service bulletin explaining when the safety belts are supposed to lock. *rm | 05/11/2011 | |
05-09-40-002E | 10/01/2010 | 10037184 | Ready | 05/11/2011 | |
SEAT BELTS - FRONT - WEBBING | |||||
05-09-40-002E | 10/01/2010 | 10037184 | Ready | 05/11/2011 | |
05-09-40-002E | 10/01/2010 | 10037184 | Gm: service bulletin explaining when the safety belts are supposed to lock. *rm | 05/11/2011 | |
SEATS | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
SERVICE BRAKES, AIR - ANTILOCK - WHEEL SPEED SENSOR | |||||
PI-00983A | 06/01/2011 | 10039488 | Ready | 08/01/2011 | |
SERVICE BRAKES, AIR - SUPPLY - COMPRESSOR | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
SERVICE BRAKES, AIR - SUPPLY - LOW PRESSURE WARNING | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
SERVICE BRAKES, HYDRAULIC | |||||
PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 | |
PIT-4515A | 10/01/2009 | 10032452 | Gmc/chevrolet: service brake soon indicator with dtc c0272. some customers may state the service brake soon indicator comes on. may also comment the audible brake warning buzzer is sounding. *pe | 03/26/2010 | |
SERVICE BRAKES, HYDRAULIC - ANTILOCK - WHEEL SPEED SENSOR | |||||
PI-00983A | 06/01/2011 | 10039488 | Ready | 08/01/2011 | |
SERVICE BRAKES, HYDRAULIC - POWER ASSIST | |||||
PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 | |
SERVICE BRAKES, HYDRAULIC - POWER ASSIST - HYDRAULIC | |||||
PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 | |
STRUCTURE - BODY | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
SUSPENSION - FRONT - STABILIZER BAR | |||||
PIT-5033 | 09/01/2010 | 10036044 | Chevrolet/gmc: replacement rear stabilizer bar (relocate link brackets). if the rear stabilizer bar needs replacing, the new bar is shorter and will require relocation of the stabilizer bar link brackets. *pe | 03/09/2011 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING - ENGINE | |||
09/12/2008 | 165000 | 1 | |
I purchased three c-5500 trucks. as of now i have two trucks with failed engines due to previous injector failure. i am currently out of warranty but not before i noticed the engine was making more noise than normal. i was told that it had to be broken before it could be repaired under warranty. that was 60,000 miles ago. which should not be major mileage for a diesel engine. *tr | |||
09/14/2008 | 165000 | 1 | |
I own 3 chevorlet c-5500 trucks. two out of the three have had injector failure. after the injector failure the trucks engine seem to be noisier. i have complained about the noise and was told it has to be broken before repairscan be performed under warranty. now i am out of warranty and have two trucks with major engine damage due to the previous injector failures. *tr |