Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SERVICE BRAKES, AIR | |||||
| 020526001B | 01/01/2005 | 020526001C | 10006115 | Rear parking brake shoe retaining spring clip service kit for drum-in-hat (dih) equipped vehicles. *tt update. *tt | 04/16/2004 |
| SERVICE BRAKES, AIR - ANTILOCK - ABS WARNING LIGHT | |||||
| 040525002 | 06/01/2007 | 040525002D | 10022470 | Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb | 08/15/2007 |
| SERVICE BRAKES, AIR - DISC - CALIPER | |||||
| 040523003 | 04/01/2004 | 10012585 | Revised rear brake caliper bracket mounting bolt fastener specification. *eh | 03/08/2005 | |
| SERVICE BRAKES, HYDRAULIC | |||||
| 3064 | 01/01/2004 | 10009369 | Front brake noise or squealing on the first few light brake applies after the vehicle has sat for a long period of time, such as overnight. this message applies to the long wheel base model. service vme. *tt | 09/27/2004 | |
| 02053 | 01/01/2004 | 3080 | 10007739 | Information on resurfacing the park brake portion of the rear brake rotor. *tt | 07/09/2004 |
| 011703 | 01/17/2003 | 10005108 | Front brake noise or squealing after the vehicles has sat overnight. gm voicemail express. *tt | 01/30/2004 | |
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||||
| 3832 | 12/01/2007 | 3832C | 10019241 | Abs, red brake ,svc and 4wd light on hvac blower inoperative. *ak updated 1/30/08. *nj | 02/22/2006 |
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - ABS WARNING LIGHT | |||||
| 130701 | 07/13/2001 | 623808 | Customers may complain of an anti-lock brake system (abs) or brake indicator light illuminating or a service brake system message from the driver information center with a code of c0238 in the electronic brake control module. | 10/30/2001 | |
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - CONTROL UNIT/MODULE | |||||
| 3204B | 3204C | 10017413 | Installation of an aftermarket trailer brake module. *tt | 11/07/2005 | |
| 040525002B | 11/01/2005 | 040525002C | 10008659 | Anti-lock brake system (abs) light on, diagnostic trouble codes (dtcs) c0265, c0201, u1041 set and/or loss of communication with brake module. *tt update. *tt | 08/13/2004 |
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||||
| 030523002 | 05/01/2005 | 030523002A | 10017359 | Revised front brake caliper bracket mounting bolt fastener tightening specification. *tt | 11/03/2005 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SERVICE BRAKES, HYDRAULIC | |||
| 06/01/2004 | 500 | 2 | 06/23/2001 |
| Consumer had all of the weather proofing on the vehicle replaced by the dealer as well as the clutch assembly . *ak the fan clutch was replaced, the air bag indicator light came on. the consumer was told that nothing could be done if the light wasn't on at the time. the plastic trim from the seat belt broke, the seat belt failed again, the transmission would drag, the engine light was on and made a grinding noise,the drivers side tire was loosing pressure, the passenger inner door seal leaked, the clock on the radio would reset itself, the drivers side seat belt would lock up when the brakes were applied they would skid and pull to the right. *sc *jb | |||
| 4 | |||
| Consumer states while comiing down a hill pcm shorted out. as a result, driver lost all electrical functions. steering wheel got really stiff. brake pedal became hard to press. | |||
| 12/30/2002 | 1 | ||
| Consumer front brakes failed, causing the consumer to use the emergency brake to stop the vehicle.*jb | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 02/13/2006 | 28000 | 1 | 05/15/2002 |
| Dt*: the contact stated the abs engaged at speeds of 30 mph and below. the stopping distance was increased as a result. there is a nhtsa recall, # 05v379000, regarding the abs system. the vehicle has the same problems as the recall; however it is not included in the recall due to the vin. the vehicle was taken to a local dealership for inspection. the dealer can not duplicate the problem and no repairs were made. updated 03/03/06. *jb | |||
| 09/06/2005 | 1 | ||
| When vehicle is stopping, it feels as though the brakes are releasing some sort of air. we then have to lift off of the brake in order to fully stop. this has been a problem when trying to make sudden stops. *jb | |||
| 09/02/2004 | 1 | ||
| While applying the brakes pedal went to the floor. consumer was able to maintain control of the vehicle, and drove it to the dealer for inspection. mechanic informed consumer that the problem could not be duplicated. *ak | |||
| 04/13/2004 | 22000 | 50 | |
| Several months ago while driving at any speed and when depressing the brakes consumer felt pulsation in the brake pedal. currently, when the brakes are depressed the pulsation is very severe. dealer has made an appointment to examine the vehicle. pulsation occurred fifty times in the last few months.*ak | |||
| 05/21/2003 | 1 | ||
| While driving 5 mph the brakes failed and as a result the vehicle was involved in an accident in which the front of the vehicle was damaged. *nlm | |||
| 01/10/2003 | 3 | 07/14/2000 | |
| Engine stalls, causing consumer to wait a half an hour to start vehicle again. this has happened three times. dealer has inspected vehicle and could not duplicate or correct the problem. please provide further information. also, abs failure. *ak | |||
| While driving t 75mph brake light illuminated indicating a malfunction. vehicle then shut completely down, causing loss of all power. please provide vehicle identication number, and any further information. *ak | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - ABS WARNING LIGHT | |||
| 09/07/2007 | 41225 | 1 | 01/12/2002 |
| When having my 02' envoy serviced and state inspection by my gmc dealer the service manager called and told me, i would need to r/r my front rotors. the pads were half worn but the rotors smooth surface did not exist. it looked like they were not machined thoroughly. ser. mgr thought i lived near the shore, stating salt water would usually causes this. i do not live near the shore and do not go the beach. i drive this vehicle to and from work all highway driving. my vehicle has 41225 mi and has always been serviced by gm. i have owned gm vehicles for 38 yrs and the cars with rotors never looked like this. this looks like a manufacturing imperfection. from reviewing the odi list for this vehicle, others have also documented similar complaints. if i did not bring the vehicle in for the state inspection i would never have know this defect existed. this gave me neither warning in braking, stability nor squealing/ticking from early warning system. i should had asked for old rotors or taken a picture. front rotors and pads replaced at my expense. *tr | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DIFFERENTIAL PROPORTIONAL VALVE | |||
| 08/09/2001 | 1 | 05/25/2001 | |
| Power steering rack failed at highway speeds, making it difficult to steer vehicle. dealer has inspected vehicle and determined that steering rack would need to be replaced.*ak there was a loud noise due to no fluid in the power steering reservoir. rear differential leaks. driver side front and rear doors rattle and flew over large bumps. interior courtesy lights do not come on when passenger side door is open. *slc | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||
| 11/18/2002 | 07/01/2002 | ||
| Transmission on cold start stays in first gear. left rear brake appear to have hung up and is burning. dt | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - PADS | |||
| 10/31/2005 | 1 | 07/01/2002 | |
| Dt: the contact stated the brake pad wear indicator did not make any noise before the brake pads went to the metal. the vehicle was not taken to the dealership for repairs. as a result, gm told him they could not assist, and advised him to take the vehicle to the local dealership for brake pads inspection. there have been no corrections to the vehicle at this time. *ak | |||
| 12/20/2004 | 27000 | 2 | 06/20/2002 |
| I noticed the brakes pulsing badly on my 2002 gmc envoy at 27,000 miles. the dealership stated that brakes are covered up to 21,000 miles and rotors covered to 24,000. all 4 rotors and brake pads had to be replaced at my expense. i guess that i shouldn't have assumed that a warranty of 3 years or 36,000 miles meant that everything was covered. how convenient it is for the warranty coverage on brakes and rotors expires prior to the 3 year 36,000 mile warranty. that tells me that gm knows when the cheaper parts they are using are going to fail. the 3 year 36,000 warranty is very misleading. in my 27 years of driving, i've never seen rotor and brake pad failure at 27,000 miles. good brake parts are vital in the safety of a vehicle, i don't understand how they are allowed to use inferior materials. thank god my pregnant wife didn't have and accident while driving this vehicle. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - ROTOR | |||
| 09/07/2007 | 41225 | 1 | 01/12/2002 |
| When having my 02' envoy serviced and state inspection by my gmc dealer the service manager called and told me, i would need to r/r my front rotors. the pads were half worn but the rotors smooth surface did not exist. it looked like they were not machined thoroughly. ser. mgr thought i lived near the shore, stating salt water would usually causes this. i do not live near the shore and do not go the beach. i drive this vehicle to and from work all highway driving. my vehicle has 41225 mi and has always been serviced by gm. i have owned gm vehicles for 38 yrs and the cars with rotors never looked like this. this looks like a manufacturing imperfection. from reviewing the odi list for this vehicle, others have also documented similar complaints. if i did not bring the vehicle in for the state inspection i would never have know this defect existed. this gave me neither warning in braking, stability nor squealing/ticking from early warning system. i should had asked for old rotors or taken a picture. front rotors and pads replaced at my expense. *tr | |||
| 01/01/1901 | 1 | ||
| 2002 gmc envoy has defective brake rotors.***no answer required***. *mr the brake rotors were cracking at the edges and in danger of cracking. the consumer wrote to the manufacturer but hasn't received a response. the consumer believes there is a defect in the steel used to produce the rotors. *nm | |||
| 06/29/2005 | 09/14/2001 | ||
| I have a 2002 gmc envoy slt with 22700 miles. recently, i noticed deep scoring in the rear brake rotors. i thought that the brake pads were severely worn, so i took my vehicle to the dealer where i purchased it. usually, i keep very close watch on the rotors, front and rear because it can become a costly job if they are scored. when the service manager informed me that the pads were ok and that they were only half worn, sent up red flags to me. he also said the front rotors were out of round. he said it could be due to wear and tear. i am 53 years old and i have never heard of the rotors being so deeply scored without the pads being worn down. | |||
| 12/20/2004 | 27000 | 2 | 06/20/2002 |
| I noticed the brakes pulsing badly on my 2002 gmc envoy at 27,000 miles. the dealership stated that brakes are covered up to 21,000 miles and rotors covered to 24,000. all 4 rotors and brake pads had to be replaced at my expense. i guess that i shouldn't have assumed that a warranty of 3 years or 36,000 miles meant that everything was covered. how convenient it is for the warranty coverage on brakes and rotors expires prior to the 3 year 36,000 mile warranty. that tells me that gm knows when the cheaper parts they are using are going to fail. the 3 year 36,000 warranty is very misleading. in my 27 years of driving, i've never seen rotor and brake pad failure at 27,000 miles. good brake parts are vital in the safety of a vehicle, i don't understand how they are allowed to use inferior materials. thank god my pregnant wife didn't have and accident while driving this vehicle. *ak | |||
| 05/15/2003 | 30000 | 1 | |
| Consumer states that all four rotors have failed at 30000. dealer notified. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM | |||
| 03/01/2005 | 40000 | 1 | 07/26/2002 |
| Dt: the front brake drums rusted. vehicle was taken to service repair shop because there was severe vibration in the both front wheels when brake pressure was applied. service manager noted both brake drums were rusted. there were chunks falling from the inside of the brake drums, and they needed to be replaced. consumer was waiting these parts to come in so that they could be placed on the vehicle and repaired. *ak | |||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST - VACUUM - HOSES, LINES/PIPING, AND FITTINGS | |||
| While operating vehicle at about 75 mph in fast lane vehicle lost power, almost causing an accident. loss of engine power/ steering power, and once vehicle came to a stop. dashboard illumination showed brake check valve defect. *ak | |||