Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
STRUCTURE - BODY | ||||||||||||||||
01V158000 | GENERAL MOTORS CORP. | from 10/01/2000 to 03/31/2001 | V (Vehicle) | 8197 | 07/16/2001 | MFR | GENERAL MOTORS CORP. | 05/16/2001 | 05/22/2001 | 571 | 201 | |||||
Defect Summary | Vehicle description: certain sport utility vehicles fail to comply with requirements of fmvss no. 201, occupant protection in interior impacts. these vehicles have a console cover/armrest lid latch that could release at less than the 10g vertical load requirement of the standard. | |||||||||||||||
Consequence Summary | In the event of a crash, the console cover could open and the cover or items stored under it could injure an occupant. | |||||||||||||||
Corrective Summary | Dealers will replace the console latch mechanism and install a striker plate. owner notification began july 16, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact gmc at 1-800-462-8782. | |||||||||||||||
Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
02V273000 | GENERAL MOTORS CORP. | from 02/01/2002 to 09/30/2002 | V (Vehicle) | 46 | 10/04/2002 | MFR | GENERAL MOTORS CORP. | 10/04/2002 | 10/09/2002 | |||||||
Defect Summary | Certain sport utility vehicles are missing welds on the rear floor plan. | |||||||||||||||
Consequence Summary | In a crash, missing welds could degrade performance of the third row seat and safety belt anchorage and occupants could receive greater injuries. | |||||||||||||||
Corrective Summary | Dealers will inspect the vehicle for missing welds. if missing welds are found, gm will exchange the vehicle for an equivalent vehicle or provide a refund of the purchase price. owner notification began october 4, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. | |||||||||||||||
Notes | Gm recall no. 02045.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
STRUCTURE | |||||
01078E | 01/01/2004 | 01078F | 10007552 | Noise from instrument panel cluster tachometer. *tt | 07/01/2004 |
01663A | 01/01/2004 | 01663B | 10006296 | Vibration noise from under hood, sounds like sheet metal vibrating. *tt | 04/27/2004 |
062503 | 06/25/2003 | 10003721 | Rear license plate pocket seal being rolled over due to improper installation. this a vme message. *tt | 10/29/2003 | |
020849009 | 10/01/2002 | 10000164 | Interference with center console rear auxiliary power outlet cover and rear seat cushion. *tt | 02/13/2003 | |
020867004 | 05/01/2002 | 634583 | Some customers may comment that the headliner sags at the rear of the sunroof opening. *tt | 10/03/2002 | |
STRUCTURE - BODY | |||||
0508110004 | 04/01/2005 | 10017326 | Cargo cover handle broken. *tt | 11/03/2005 | |
030866008 | 08/01/2003 | 10012578 | Perimeter seal/gasket pulls away from license plate housing and/or excessive adhesive around gasket. *tt | 03/07/2005 | |
0408111003 | 06/01/2004 | 10012546 | Rear license plate pocket parts new available individually. *tt | 03/07/2005 | |
040866001 | 10/01/2004 | 040866001A | 10011141 | Rear license plate pocket gasket loose or out of position. *tt udate. *tt | 01/03/2005 |
040864012 | 09/01/2004 | 040864012A | 10011083 | Front or rear side door glass scratched. *tt | 12/29/2004 |
00731A | 01/01/2004 | 00731B | 10007578 | Noise from front of vehicle over bumps or under light acceleration. *tt | 07/01/2004 |
0308111002A | 10/01/2004 | 0308111002B | 10005189 | Paint chipping behind front wheels/front of rear wheels, damaged lower door/cladding and rocker panels. *tt this service bulletin replaces 0308111002. *eh update. *tt | 02/11/2004 |
030863003 | 12/01/2003 | 10005188 | Rattle from front of vehicle. *tt | 02/11/2004 | |
030857004 | 06/01/2006 | 030857004C | 10004735 | Wet front floor carpet. *tt update. *tt update. *kb | 01/05/2004 |
120902 | 12/09/2002 | 10002739 | Buzz or rattle noise coming from the front end of light accelreation at 25 to 45 miles per hour or over bumps. *tt | 09/12/2003 | |
020844016A | 12/01/2002 | 020844016 | 10000747 | Whine, buzz, generator whine, whine type noise heard on acceleration. *tt | 03/28/2003 |
020864024 | 12/01/2002 | 10000750 | Discoloration / fading of door glass molding. *tt | 03/28/2003 | |
020861002 | 06/01/2002 | 634667 | Some customers may comment that the assist step skid pad is warped. *tt | 10/04/2002 | |
020866004 | 04/01/2002 | 634552 | Some customers may comment that the paint on the liftgate around the edges of the license plate housing or pocket appears to be rubbing through or wearing off. *tt | 10/03/2002 | |
020862001 | 08/01/2002 | 634312 | Some customers may comment that the front fascia on the vehicle appears to be loose. *tt | 09/28/2002 | |
33 | 03/01/2001 | 619223 | Information on headliner replacement, headliner harness routing, and replacing or servicing the sunroof on various models including the 2002 chevrolet trailblazer. *tt | 05/19/2001 | |
STRUCTURE - BODY - DOOR | |||||
030864006 | 04/01/2007 | 030864006C | 10001264 | Doors hard to close. *tt updated 07-24-07. *kb | 04/25/2003 |
STRUCTURE - BODY - HATCHBACK/LIFTGATE | |||||
3999 | 3999A | 10021085 | Liftgate glass will not lock unless lock is press a second time. *kb | 03/01/2007 | |
060866011 | 08/01/2006 | 10020523 | Rear liftgate binds, improper fit. may be caused by broken welds or cracks formed around the two inner welds. *kb | 11/09/2006 | |
060866001 | 02/01/2006 | 10019506 | Revised liftgate lock cylinder replacement. *tt | 03/20/2006 | |
3135 | 01/01/2004 | 10010175 | Chmsl applique contacts roof when opening rear gate/glass. (to include 2005 chevrolet trailblazer) (mt 370 only) *sc | 11/04/2004 | |
030866006 | 06/01/2003 | 10002877 | Lift gate glass hard to close. *tt | 09/30/2003 | |
031003 | 03/10/2003 | 10001903 | The lift gate, or lift gate glass, binds when opening or does not open completely because of center high mounted stop lamp or chimsel applique hits the roof of the vehicle. *tt *jb | 07/25/2003 | |
STRUCTURE - BODY - HATCHBACK/LIFTGATE - HINGE AND ATTACHMENTS | |||||
702 | 02/01/2005 | 10016372 | Unlocking liftgate latch. gm tech links. 2002 and newer chevrol trailblazer, gmc envoy, oldsmobile bravada and buick rainer. *tt | 09/09/2005 | |
STRUCTURE - BODY - HOOD | |||||
040863005 | 06/01/2004 | 10012537 | Rattle noise under hood. *tt | 03/07/2005 | |
STRUCTURE - FRAME AND MEMBERS | |||||
012903 | 01/29/2003 | 10005113 | Information on replacing a full frame assembly on a collision repair. gm voicemail express. *tt | 01/30/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
STRUCTURE | |||
06/01/2004 | 500 | 2 | 06/23/2001 |
Consumer had all of the weather proofing on the vehicle replaced by the dealer as well as the clutch assembly . *ak the fan clutch was replaced, the air bag indicator light came on. the consumer was told that nothing could be done if the light wasn't on at the time. the plastic trim from the seat belt broke, the seat belt failed again, the transmission would drag, the engine light was on and made a grinding noise,the drivers side tire was loosing pressure, the passenger inner door seal leaked, the clock on the radio would reset itself, the drivers side seat belt would lock up when the brakes were applied they would skid and pull to the right. *sc *jb | |||
05/29/2002 | 1 | 02/13/2002 | |
Vehicle's air bag light keep flashing/ vehicle running on high rpm's. *mr air bag sensor replaced and calibrations had to be updated. additional problems included faded window moldings, loss of power and steering. ignition switch and fuse block was replaced. inoperative power mirrors. parts had to be ordered. consumer was upset with the number of problems experienced with vehicle and the number of recalls on this new suv. *tt *jb | |||
12/05/2001 | 12/01/2001 | ||
While driving at 30mph headwind and topping out a large hill, front end lifts and swerves due to a large air pocket formed by the front of the hood, the top of the radiator and grill 'fins' or 'bars', the pocket is five inches deep, 4 inches high and 4 feet wide. driver filled the pocket with nylon foam cut to fit and glued into place. the pocket caused the vehicle to lose traction for the front (steering) wheels and pushed the front end by wind gusts to an excessive and dangerous amount. | |||
STRUCTURE - BODY | |||
08/20/2001 | 1 | ||
Engine non-start problems -- waiting 15-20 minutes seems to correct. wandering side view mirrors. rubbing noise when turning tightly. driver's side door movement noise when turning over bumps. side mirror air noise. the 1st. two (2) problems have been ongoing, and the most concerning, since the vehicle was purchased new in 2001. it has been in for repairs to two (2) gmc dealers numerous times, and an ignition recall repair was done and the dealer assumed it would correct the non-start problem. it did until yesterday. more importantly however, shortly after this vehicle was purchased, gmc's owner assistance help has been sought for these (2) problems assuming they may inform the dealer of engineering fixes, but to no avail. *jb | |||
2 | |||
The consumer had received recall on console arm rest latch, it was fixed but failed again. *yh | |||
2 | |||
The consumer had received recall on console arm rest latch, it was fixed but failed again. *yh recall 01v158. *slc | |||
STRUCTURE - BODY - DOOR | |||
12/07/2002 | 1 | 03/01/2002 | |
Spot welds failing on door hinge assembly due to flexing of metal adjacent to hinge. door check rod not performing restraining function. broken spot welds could allow a door to fall off moving vehicle. dt | |||
10/25/2001 | 7 | 08/01/2001 | |
Memory mirrors do not return to the correct settings. consumer was orginally told there was no problem; however, two dealerships had duplicated the problem and could not fix it. had it in a total of 8 times, and several parts of vehicle have been replaced, including mirrors/ mirror actuators/ liftgate control module , and driver's side door control module. this mirror defect was similar to the ones mentioned in odi id numbers 755966, 757526, 757914, 759042, 759973, 760504 and 8000646. consumer's file number with gmc has been 1-11855349. this was very unsafe because when thinking that mirrors were set, they were not. at night or in the dark consumer must wait to see a light to set them. dt. *ak | |||
08/09/2001 | 1 | 05/25/2001 | |
Power steering rack failed at highway speeds, making it difficult to steer vehicle. dealer has inspected vehicle and determined that steering rack would need to be replaced.*ak there was a loud noise due to no fluid in the power steering reservoir. rear differential leaks. driver side front and rear doors rattle and flew over large bumps. interior courtesy lights do not come on when passenger side door is open. *slc | |||
STRUCTURE - BODY - HATCHBACK/LIFTGATE | |||
03/01/2006 | 1 | 06/29/2005 | |
I purchase a 2002 gmc envoy 06/05 ,and about 1 month ago i heard a loud noise when i went to open my tail hatch after noticing my passenger side brake light was out. i talk to the dealer about this and was told by the body shop manager that the flap over the hatch was suppose to look like that there is a very noticeable gap,he then said that it probably had been fixed before. and during a later conversation with him he said that it was natural wear and tear. i am the owner and only driver of my truck, and i probably wouldn't have open the back hatch if i hadn't notice the brake light out which i found out is under a recall. my conversations with the dealer and also gmc have lead to no where. i took the truck to an outside repair shop who look at the hatch and also said that it had been repair before and to try to work with gmc and the dealer with getting it fixed. *nm | |||
01/11/2005 | 47000 | 4 | 07/01/2001 |
When driving the back hatch makes a popping noise and rear hatch opens. *nm | |||
08/15/2002 | 6 | ||
While driving at any speed on flat surface and with no warning, hatchback window will open. consumer will have to pull over to close the window. dealer notified.*ak there is a popping sound heard when the window opens on it's own similar to the same noise heard when actually pushing the button for the window to open. *jg | |||
STRUCTURE - BODY - HATCHBACK/LIFTGATE - HINGE AND ATTACHMENTS | |||
10/25/2001 | 7 | 08/01/2001 | |
Memory mirrors do not return to the correct settings. consumer was orginally told there was no problem; however, two dealerships had duplicated the problem and could not fix it. had it in a total of 8 times, and several parts of vehicle have been replaced, including mirrors/ mirror actuators/ liftgate control module , and driver's side door control module. this mirror defect was similar to the ones mentioned in odi id numbers 755966, 757526, 757914, 759042, 759973, 760504 and 8000646. consumer's file number with gmc has been 1-11855349. this was very unsafe because when thinking that mirrors were set, they were not. at night or in the dark consumer must wait to see a light to set them. dt. *ak | |||
STRUCTURE - BODY - TAILGATE - HINGE AND ATTACHMENTS | |||
07/24/2005 | 48000 | 1 | 06/29/2005 |
In regard to my prior complaint i notice that my hinges holding my tailgate on were rusted about a month after i purchase my truck, and took it the dealer service shop. i was told that the hinges were not covered under the certified warranty,although according to the certified car and truck warranty it should have been notice during the bumper to bumper inspection before selling the truck. i can't remember the exact day i took it in i believe it was near the end of the month. *nm | |||
01/17/2005 | 60000 | 100 | 07/01/2002 |
Dt*: the contact stated the electronic mirrors re-adjust without warning. the mirrors should maintain the last setting, but require re-adjustment every time the vehicle is driven. occasionally the mirrors re-adjust while driving making it difficult to change lanes. the vehicle was taken to a service dealer twice for repairs. the dealer replaced the mirrors and made adjustments to the electrical unit. the problem was only alleviated temporarily by the repairs and the mirrors began malfunctioning again a year ago. *nm... the mirrors will self adjust the settings. while driving the contact looked in the mirrors to change lanes and they were out of adjustment. had to constantly adjust the mirrors prior to changing lanes. also, when shutting the vehicle off, and restarted it, had to adjust the mirrors. the mirrors will not hold the set adjustment. in addition, the tailgate could only be opened with the remote, there was no other way to open the tailgate. in a situation where the contact's only exit from the vehicle was from the inside, could not open manually from the inside. *ak |