Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN | |||||
| 010730002C | 08/01/2003 | 010730002B | 10004354 | Malfunction indicator lamp (mil) is on; the transmission is stuck in third gear; and / or the instrument cluster is inoperative. *tt | 12/03/2003 |
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| 030730056 | 11/01/2003 | 10005566 | 4l60-e automatic transmission oil pump first and second design identification. *tt | 03/04/2004 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||||
| 020730024A | 08/01/2005 | 020730024B | 634999 | Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt | 10/11/2002 |
| POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT | |||||
| 98464102A | 10/01/1998 | 46-41-02 | 602753 | Conditions with front propeller shaft cv boot torn or cracked. *yc | 01/11/1999 |
| POWER TRAIN - DRIVELINE | |||||
| 3300 | 3300A | 10013572 | 4wd models with noise, vibration on dry pavement. *eh | 04/21/2005 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN | |||
| 05/22/1999 | 6 | 09/01/1997 | |
| While driving 70 mph speedometer was stuck, and did not show the speed that vehicle was traveling, especially when passing through a school zone. *ak | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 06/16/2006 | 78000 | 1 | |
| While driving along the pennsylvania turnpike i had my 1997 gmc jimmy in cruise control. i taped to brake to turn off the cruise control. after resuming the cruise control the vehicle began picking up speed much to fast. i again tapped the brake and shut off the cruise control. i then heard what seemed like a flat tire, i began pulling off of the road. as i looked in the passenger side mirror i could see flames coming from the passenger side rear of the vehicle. after stopping the vehicle i said to my mother the passenger the vehicle is on fire get out after she opened the door the flames tornadoed and came inside the vehicle and started everything on fire. i then pulled my mother over the console and dragged her away to safety, the vehicle in less than 20 seconds was engulfed in flames. *nm | |||
| 10/21/2005 | 51000 | 8 | 11/23/1996 |
| Dt:the contact stated the upper and lower ball joints on both sides broke while driving in a parking lot. the vehicle had to be towed to the dealership, where the ball joints and the anti lock brake sensors were replaced. contacted the manufacturer, there were nhtsa recalls 01i018000 and 01v200000, but this vehicle was not included in the recalls due to vin. in addition, this vehicle experienced several other problems as well. the left door broke off while in the driveway, the male joint of the door broke when shutting the door. also, the transmission and anti lock brakes were replaced. the anti lock brake sensor was replaced twice. *ak | |||
| 11/15/2004 | 70000 | 10 | 03/30/2000 |
| Transmission failure / replaced transmission - upper & lower ball joint failure / replaced upper & lower ball joints - rear window wiper failure / inoperable at this point - extremely expensive replacements with no old parts available at this point. events leading up to failure i can only attribute to severely poor manufacturing of products, there was no operating misuse or abuse. also other parts that have failed and have since been replaced are the: alternator, fuel pump, fuel pressure regulator and cooling system failures. *jb | |||
| 08/28/2004 | 68000 | 50 | 04/10/2000 |
| Windshield wipers do not work all the time. i was in a bad rainstorm last night and had to pull off the road because we couldn't see anything. scary - this is a potential big law suit for gmc if anyone dies in an accident due to this common complaint. my gmc mechanic revealed that this happens on almost all gmc jimmy's, yet there is no recall to replace the defective part to date. transmission - slipped badly. i paid to have it replaced and sometimes it still slips. this transmission repair shop said that this is common with the jimmy, as well as a faulty gas gauge, faulty ball joints and oxygen sensors. i did have to replace the oxygen sensor, but i consider that normal repairs. *jb | |||
| 08/15/2003 | 64212 | 2 | 06/28/1997 |
| Ignition switch has failed and been replaced twice in past 4 years (10/2000 & 8/2003). when it fails, the transmission fails to shift properly and the vehicle loses power and/or stalls. this creates a very dangerous situation, especially if you are in heavy traffic with your entire family. i have been told by gm technicians that this is a common problem due to poor design, engineering and mfg quality.*ak | |||
| 08/11/2003 | 97000 | 4 | 09/01/1998 |
| Transmission slipping again...shift with gas pedal...let off on gas & let rpms drop to allow trans to shift. dealership told me that they no longer service transmissions, too much hassle - will sell me a new one for $2500 plus labor @ another $900 to $1200...limited to only 6 months of coverage! i know of at least 10 other blazaer and jimmy owners at fort bliss that have had same tramsmission problems. an investigation should be opened to recall this transmission. i can be reached anytime at 915-593-5144 to further clarify my concerns...cpt burgess. *ak | |||
| 08/05/2002 | |||
| Vehicle unable to shift into reverse because water got into transmission while parked in garage. manufacturer was notified. feel free to provide any further information.*ak | |||
| 01/01/2002 | 1 | ||
| Automatic transmission gears do not engage properly while driving. dealer has been contacted. *ak *jb | |||
| 01/01/2002 | 1 | ||
| Vehicle suddenly accelerated when idiling. dealer has been contacted, and has replaced fuel injectors. please provide further details.*ak the heating system malfunctioned due to heating core failure. the a/c was not blowing warm air. there was a clicking noise from the engine area because the power steering pump was leaking fluid. the vehicle leans to the left due to torsion bar out of adjustment. front left and right axle seals were leaking. transmission was leaking. back window had air leak. the rear wiper sticks due to wiper motor failure. front end makes clunking noise due to ball joint failure. there was clunk noise when shifting into gear due to rear d-shaft and u-joint failures. the intake gasket was leaking and was replaced. the throttle sticks. the serpentine belt failed and was replaced. *yh | |||
| 01/01/2002 | |||
| While driving consumer automatic transmission gears do not engage properly, it also stalls on an intermittent basis. dealer has been notified of this problem. please provide further details.*ak | |||
| 1 | |||
| While driving, transmission malfunctions and will not go into reverse or overdrive. also, transmission fluid became thick. *ak *tt consumer states now she is experiencing problems with the radiator losing coolant. *slc | |||
| 08/31/2001 | 1 | 10/01/1996 | |
| Upper ball joint separated and the wheel was cut through causing the tire to go flat. the vehicle has been well maintained and the front end had been checked a few months earlier by a competent mechanic when new shocks were installed. two weeks later a friend alerted me to gm product safety campaign # 01048. this was an alert to upper ball joints separating without warning on some '96-'97 jimmys, bravadas and blazers. i inquired at my dealer to see if my vehicle qualified and was told no, there are no open recalls on your vin.. i called the gmc customer assistance center at 1-800-gmc-8782 and spoke with lisa who assigned me reference number 056 42 894. gm confirmed they can do nothing for me, as there are no open recalls on your truck. it was built at a different plant and a different supplier provided the ball joints than the ones in the recall. sounds like a load of crap to me. if i sound overly angered by a ball joint failure it might be because i have had nothing but grief with this vehicle and am tired of being a victim. the transmission was pulled under warranty at 28000 miles, yet i had to have it pulled again at my expense ($1474) at 52500miles. two of the four o2 sensors have failed, the radiator was full of the infamous missisippi mud dex-cool sludge, the service engine light comes on at least once a month, the serpentine tensioner fell apart at 37k miles and had to be replaced again at 58k, the wipers frequently won't turn on unless you hit the mist lever as you hit a bump (common according to the edmunds.com site), and last week my abs went out from what the trouble code diagnosed as a bad left front speed sensor. i'll have to drive it with the sensor unplugged for now because i've already put over $2000 in repairs into this thing during calendar year 2001 alone, and i'm tapped out. same with the wiper condition. | |||
| 07/13/2001 | 1 | 06/01/1999 | |
| Please make gm take care of transmission problem. i am not alone in my complaint. code 1870. when will this end when my 5 year old and i are stranded on the highway for hours? i want a recall on this problem. i will not give in on this. gm must pay for these repairs. the consumer should not be responsible. *ak | |||
| 01/01/2000 | 3 | 11/01/1996 | |
| Transmission has a history of shifting hard between 1st and 2nd, especially when warm. during a routine oil change, mechanic noticed a rusted trans dip stick. though protested by gm as a defect, extended warenty covered. i had to go elsewhere for trans flush, dealer did not have equipment. problem persists through 2000. trasmission overheated on hwy causing overflow and slipage. dealer found rust in radiator and debrise in trans. had to replace radiator/flush engine and trans. at my expense 1/2001. now, with warmer weather, trans. oil is varnished and shift hard between 1 & 2nd again just 5000 miles later. engine lite on. found multible simular complaints at http://www.thecomplaintstation.com/g/gm_toc.htm. gm is not recognizing what appears to be an expensive, chronic problem with transmission and associated cooling components. i am not prepared to spend another $1-$2k on a $30k that has been well cared for when gm knows about these problems. i called gm customer relations and sent letters to gm directors and got no intellect or sympathy assigned to my case. please read the web site, there are many cases of 1995-1997 jimmy/s10/blazers with the exact symptoms.*ak | |||
| 12/26/2000 | 2 | 01/01/1997 | |
| Vehicle described in this complaint appears to have a flaw in the design of transmission. in addition to what is included in this report, i also had a problem at 28,000 miles where they repaired the transmission while it was under warranty. in both cases the vehicle would not go in reverse, the 4x4 would not work, and certain gears failed. i would also like to note that this appears to be a wide spread problem. i would support this notion by the countless tranmission complaints (for the exact same year and make or other vehicles that most likely use the same transmission ie the blazer) noted on the tod complaint web site for general motors, which is where i found a link to this site.*ak | |||
| 09/15/1997 | 10 | 08/01/1997 | |
| The transmission intermittently slips into, but not fully, 4wd when the vehicle is put in reverse. there is a very noticable noise that sounds like the transmission is not fully engaged. the only way to eliminate the noise is to shift the vehicle into 4wd and then back into 2wd. the vehicle has been brought back to the dealer on at least 4 occasions with this complaint. they have not been able to duplicate the problem and therefore have not done any research. on december 19th, 2000 the symptom reappeared after backing my car out of the driveway and i immediately brought it to the dealer. the service manager then test drove the vehicle and noted that the problem i described previously does exist and scheduled me to bring in the truck on thursday, december 28, 2000. when i brought the vehicle in the manager who had test drove the vehicle just one week ago did not seem to recall the condition and said they would check it out. i have a problem with the way the whole thing is being handled. i can't believe that my vehicle is the only one that has this problem in the entire country. i would think that gmc should have some information regarding this in their database. at this point i am not convinced that the proper diagnostic methods are being taken to locate the problem and remedy it. i don't know where else to turn and i am looking to you for any guidance that you can provide. *ak | |||
| 12/20/2000 | 1 | 09/01/1997 | |
| Transmission slips r-3-4, hard shifting 1-2, soft shifting 3-4, leaks. dealer is unresponsive at this time!!*akk | |||
| 12/20/2000 | 1 | ||
| Transmission would shift hard and slow, and was hard to pull. dealership aware of problem. there was a lot of play and slippage in transmission.*ak the transmission was defective accordig to the consumer, but the manufacturer did not admit it. *yh | |||
| 3 | |||
| Ea94-038, under any braking and upon depressing brake pedal abs system kicked in, causing extended stopping distance and poor braking ability. consumer has contacted dealer. dealer has yet to replace parts. also, transmission has been replaced three times. please provide any further details. *ak | |||
| 10/31/1999 | 2 | 10/01/1997 | |
| Transmission failed on interstate and the emergency flashers failed, transmission has been replaced on two occasions, the electrical system experiences continual malfunctions (emergency flashers, brake lights, warning buzzer). *mjs | |||
| 03/01/1998 | |||
| Carpet--hole. automatic transmission--leak at pump, replaced. | |||
| 1 | 11/04/1997 | ||
| Transmission failed. *yc | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||
| 12/01/1999 | 1 | 01/01/1998 | |
| 4-wheel drive motor failed, and shorted out the 4-wheel drive relay causing entire system to not operate at all. | |||
| POWER TRAIN - AXLE ASSEMBLY | |||
| 10/12/1999 | 1 | 10/01/1999 | |
| No summary listed for above vehicle. *ak | |||
| 07/19/1999 | |||
| While driving axle separated from rear of vehicle. manufacturer has been notified. *ak | |||
| POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT | |||
| 12/11/2000 | 1 | 10/01/1999 | |
| This vehicle has been a nightmare...unfortunately it was a spur of the moment purchase. although used, with only 39,000 miles, i thought i would be ok since it had an extended warranty till 72,000. i have replaced both upper and lower ball joints, idler arm, alternator, belt tensioner, ignition switch, 4wd sensors, gas gauge sensor, left rear axle shaft and both rear axle bearings. at least these were all covered under the warranty, but not the rental cars for all the time the truck spent in the shop. now the vehicle has 90,000 miles and the dealership is telling me that the recall for the ball joints does not pertain to my truck (the vin # is not included), the transmission dipstick is rusted (i've seen several complaints but no recall), my accelerator pedal sticks severely (also numerous complaints), and i've already replaced (out of pocket cost of $1700) a complete rear end. i owe more than this vehicle is worth...but will need to get rid of it soon because i do not feel safe driving my son around in it. many of these problems could have caused a serious accident... | |||
| POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT - SEAL | |||
| 07/18/2000 | 1 | 12/01/1999 | |
| The mileage reported for each incident is approximate, the failed components could have existed at time of vehicle purchase, the vehicle had 33310 miles. that's well under the manufacturer's warranty coverage, however the problems weren't discovered until the vehicle passed the warranty mileage. the opinion of the mechanic who repaired the items stated the rear axle seal usually lasts for the life of a vehicle however, he said gmc jimmy's are known to have this problem. the rear axle seal broke which caused axle oil to leak on the rear brakes which cause the vehicle to have increased stopping distance or appear as though it was not going to stop, depending on the traveling speed when trying to stop the vehicle tended to pull to one side before the problem was identified. the problem with the transmission dip stick was identified when i took the vehicle into get the oil changed at express oil change in marietta ga. when the mechanic put in the vin # a service bulletin appeared indicating the problem with the transmission dip stick. the mechanic inspected my transmission dip stick and it was rusted just as the service bulletin indicated could happen. i called a gmc dealer about the service bulletin and was informed that i could replace the part at my expense approximately $375 - $ 500 parts & labor. then i was told i could call the gmc customer satisfaction line for further assistance. the individual at the gmc customer service line also stated that since i had purchased the vehicle used, and i had an extended warranty, other than the gmc extended warranty plan that gmc would not repair the faulty dip stick. however, the individual indicated that if i didn't have an extended warranty gmc would inspect and possibly repair the faulty part free. my complaint the part has been identified as faulty, why should i have to pay for repairs? when the tsb was released the vehicle was within the mileage.*ak | |||
| 3 | 10/01/1997 | ||
| Three out of the four axle seals have been replaced due to failure. *mjs | |||
| POWER TRAIN - DRIVELINE | |||
| 10/12/1999 | 1 | 10/01/1999 | |
| No summary listed for above vehicle. *ak | |||
| POWER TRAIN - DRIVELINE - CONSTANT VELOCITY JOINT | |||
| 10/11/2000 | 1 | ||
| While pulling into driveway, upper ball joints fell apart without prior warning. took vehicle to be fixed and was told about recall 01 i 018 000 that deals with a similar problem concerning upper ball joints. *ak left wheel speed sensor was missing. replaced inner cv boot. *yh | |||
| POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||
| 01/26/2000 | 10/01/1996 | ||
| No summary listed for above vehicle. *ak | |||
| POWER TRAIN - DRIVELINE - DRIVESHAFT | |||
| 12/11/2000 | 1 | 10/01/1999 | |
| This vehicle has been a nightmare...unfortunately it was a spur of the moment purchase. although used, with only 39,000 miles, i thought i would be ok since it had an extended warranty till 72,000. i have replaced both upper and lower ball joints, idler arm, alternator, belt tensioner, ignition switch, 4wd sensors, gas gauge sensor, left rear axle shaft and both rear axle bearings. at least these were all covered under the warranty, but not the rental cars for all the time the truck spent in the shop. now the vehicle has 90,000 miles and the dealership is telling me that the recall for the ball joints does not pertain to my truck (the vin # is not included), the transmission dipstick is rusted (i've seen several complaints but no recall), my accelerator pedal sticks severely (also numerous complaints), and i've already replaced (out of pocket cost of $1700) a complete rear end. i owe more than this vehicle is worth...but will need to get rid of it soon because i do not feel safe driving my son around in it. many of these problems could have caused a serious accident... | |||
| 1 | 12/13/1996 | ||
| Driveshaft failed resulting in leakage out of transfer case. | |||
| POWER TRAIN - DRIVELINE - UNIVERSAL JOINT | |||
| 11/15/2004 | 70000 | 10 | 03/30/2000 |
| Transmission failure / replaced transmission - upper & lower ball joint failure / replaced upper & lower ball joints - rear window wiper failure / inoperable at this point - extremely expensive replacements with no old parts available at this point. events leading up to failure i can only attribute to severely poor manufacturing of products, there was no operating misuse or abuse. also other parts that have failed and have since been replaced are the: alternator, fuel pump, fuel pressure regulator and cooling system failures. *jb | |||
| 01/01/2002 | 1 | ||
| Vehicle suddenly accelerated when idiling. dealer has been contacted, and has replaced fuel injectors. please provide further details.*ak the heating system malfunctioned due to heating core failure. the a/c was not blowing warm air. there was a clicking noise from the engine area because the power steering pump was leaking fluid. the vehicle leans to the left due to torsion bar out of adjustment. front left and right axle seals were leaking. transmission was leaking. back window had air leak. the rear wiper sticks due to wiper motor failure. front end makes clunking noise due to ball joint failure. there was clunk noise when shifting into gear due to rear d-shaft and u-joint failures. the intake gasket was leaking and was replaced. the throttle sticks. the serpentine belt failed and was replaced. *yh | |||
| POWER TRAIN - MANUAL TRANSMISSION | |||
| 08/01/1999 | 2 | ||
| Transmission failed. nlm | |||
| POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||
| 06/16/2006 | 78000 | 1 | |
| While driving along the pennsylvania turnpike i had my 1997 gmc jimmy in cruise control. i taped to brake to turn off the cruise control. after resuming the cruise control the vehicle began picking up speed much to fast. i again tapped the brake and shut off the cruise control. i then heard what seemed like a flat tire, i began pulling off of the road. as i looked in the passenger side mirror i could see flames coming from the passenger side rear of the vehicle. after stopping the vehicle i said to my mother the passenger the vehicle is on fire get out after she opened the door the flames tornadoed and came inside the vehicle and started everything on fire. i then pulled my mother over the console and dragged her away to safety, the vehicle in less than 20 seconds was engulfed in flames. *nm | |||
| 12/30/1999 | 3 | 11/01/1999 | |
| Transfer will not engage/disengage all of the time. two gm dealerships have looked at the vehicle and neither can find the cause, suggested that i start replacing parts and hope i get the right one. the first incident occured on snow slickened roads, the transfer case would not engage four wheel drive rendering the vehicle rwd only . second incident occured while driving down a steep mountain road in low range when i got to hard paved road the transfer case would not disengage. | |||