Gmc K Series 2001
Model K Series made in 2001 by Gmc got 5 investigations as well as 24 service bulletins. Technical service bulletines regarding electrical system and engine and engine cooling. The car had one investigation (parking brake).
Model 2001
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM - IGNITION - MODULE | |||||
010604050 | 11/01/2001 | 627810 | Information regarding decreased engine performance/power, filter minder indicator on, possible malfunction indicator lamp illuminated and diagnostic trouble code p0101/p0103 set. *yh | 02/25/2002 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
PIP-4695 | 09/01/2009 | 10032435 | Gm: loss of power hesitates on acceleration. 4.3, 4.8, 5.3, 5.7 and 6.0 engines coupled with the 4l60e or 4l65e may experience a condition of hesitates, misses or loss of power under acceleration. the vehicle may operate as if it is in r | 03/24/2010 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
010601029A | 06/01/2002 | 010601029 | 634831 | Subject regarding higher than expected engine oil consumption. *tt | 10/09/2002 |
020601023 | 04/01/2008 | 020601023E | 634716 | Oil leak at oil cooler to engine block mating surface (replace o-rings, apply sealant). *tt updated *eh updated 6/17/08. *nj | 10/07/2002 |
020601002 | 05/01/2002 | 634712 | Information on vehicles exhibiting a random engine ticking noise. *tt | 10/07/2002 | |
250102 | 01/25/2002 | 629718 | Some vehicles may comment on continued oil consumption with blue or whitish smoke on start up. *tt | 04/05/2002 | |
000601023A | 12/01/2001 | 000601023 | 628938 | Information used when diagnosing noise conditions such as engine rattle noise, spark knock at 2000 - 2500 rpm range, under a moderate to heavy load with a warmed up engine. *tt | 03/25/2002 |
000604003A | 12/01/2001 | 000604003 | 628905 | Some customers may comment on rough idle after start up, especially after setting overnight. *tt | 03/22/2002 |
010601029 | 12/01/2001 | 628898 | Some customers may comment on higher than expected engine oil consumption. *tt | 03/21/2002 | |
010601028 | 12/01/2001 | 628896 | Some vehicles may exhibit an engine knock noise on cold start. *tt | 03/21/2002 | |
010601022 | 09/01/2001 | 625287 | Subject on information on engine knock on cold start for pickup and utility models. *et | 11/19/2001 | |
010139002A | 08/01/2001 | 625274 | Subject regarding noise in engine compartment with air conditioning (a/c) on, a/c system inoperative (install redesigned rear a/c suction hose, replace compressor). *yd | 11/19/2001 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
020601007 | 02/01/2002 | 629454 | Some owners of certain pickup models may comment on an accessory drive noise. *tt | 04/02/2002 | |
EQUIPMENT - ELECTRICAL - AIR CONDITIONER | |||||
010139002B | 12/01/2001 | 010139002A | 628932 | Some customers may comment on excessive noise from the engine compartment with the air conditioner on, air conditioner inoperative. *tt | 03/25/2002 |
010139005 | 11/01/2001 | 627831 | Information regarding noise or vibration in passenger compartment with a/c on between 2000-2400 rpm. *yh | 02/25/2002 | |
POWER TRAIN - AXLE ASSEMBLY | |||||
020420002 | 05/01/2002 | 634901 | Subject regarding revised wheel bearing adjustment procedure. *tt | 10/10/2002 | |
STEERING - LINKAGES - TIE ROD ASSEMBLY | |||||
020234001 | 05/01/2002 | 634909 | Subject regarding tie rod replacement- inner procedure. *tt | 10/10/2002 | |
STRUCTURE - BODY | |||||
010866005A | 12/01/2001 | 010866005 | 631973 | Subject regarding the availability of pickup box reinforcement kits for toolbox/rear window barrier/ladder rack applications. *slc | 06/27/2002 |
010866014 | 12/01/2001 | 628936 | Pickup box sheet metal fractures/damage when using aftermarket accessories such as tool boxes, window barrier and ladder racks. *tt | 03/25/2002 | |
UNKNOWN OR OTHER | |||||
020451003 | 04/01/2002 | 634903 | Subject regarding revised diagnostic trouble code b2725. *tt | 10/10/2002 | |
020601015 | 04/01/2002 | 634298 | Subject regarding low oil pressure and new oil level indicator. nlm | 09/28/2002 | |
010856005 | 08/01/2001 | 625322 | Subject regarding revised theft deterrent diagnostic information for various models including chevrolet truck s series 2002. *et | 11/19/2001 | |
VISIBILITY - DEFROSTER/DEFOGGER SYSTEM | |||||
010139005A | 02/01/2002 | 010139005 | 629525 | Some customers may comment on a resonating noise or vibration in the passenger compartment with a/c on between 2000 - 2400 rpm. *tt | 04/02/2002 |
VISIBILITY - POWER WINDOW DEVICES AND CONTROLS | |||||
000864018C | 03/01/2002 | 000864018B | 631239 | Some customers may comment that the rear door window is inoperative. *slc | 05/21/2002 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
PARKING BRAKE | ||||||
PE03057 | GENERAL MOTORS CORP. | 12/08/2003 | 04/09/2004 | PARKING BRAKE FAILURE | ||
Odi opened pe03-057 to assess parking brake ineffectiveness in the subject vehicles.these vehicles are equipped with four wheel disc brakes that incorporate a single-shoe drum-in-hat parking brake independent of the service brakes.complaint and warranty data indicate that the parking brake linings tend to wear out early in the life of the vehicle (at an average of 24 months in service), reducing the parking brake system's torque below that needed to immobilize the vehicle.gm has attributed this accelerated wear to foreign material intrusion and a failure of the brake shoe to properly self-center within its brake drum.effective with the start of my 2003 production, a newer reduced force hold-down clip was introduced to facilitate brake shoe disengagement from the drum surface.this part is also available at the service level for the my 1999-2002 vehicles.gm has indicated that the paking brake is intended to operate in conjunction with the transmission to immobilze parked vehicles, and that in many cases, accelerated parking brake lining wear is caused by rough use, vehicle modifications, and driving with the parking engaged. odi has upgraded the preliminary evaluation to an engineering analysis to gather further information concerning parking brake usage factors and the circumstances surrounding the seventeen reported vehicle crashes. | ||||||
EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
PARKING BRAKE - CONVENTIONAL | ||||||
EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
PARKING BRAKE - CONVENTIONAL - MECHANICAL | ||||||
EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
PARKING BRAKE - CONVENTIONAL - MECHANICAL - LINKAGE AND CABLE | ||||||
EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. |