Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| PIP-4138K | 01/01/2011 | 10037933 | Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm | 06/08/2011 | |
| PIP-4138K | 01/01/2011 | 10037933 | Ready | 06/08/2011 | |
| 09-06-93-003B | 01/01/2011 | 10037541 | Ready | 05/25/2011 | |
| 09-06-93-003B | 01/01/2011 | 10037541 | Gm: check engine light is on with numerous possible fault codes. there may be a short in a turbocharger sensor. *rm | 05/25/2011 | |
| 3650 | 10018969 | Engine overheating no coolant flow. *tt | 01/26/2006 | ||
| 3632 | 10018549 | Service vme - engineering is investigating glow plug failures in northern indiana, northern ohio, and southeast michigan. *tt | 01/05/2006 | ||
| 030604036 | 10/01/2006 | 030604036A | 10012561 | Information on servicing fuel injectors to avoid contamination. *eh updated 03-19-07. *kb | 03/07/2005 |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| PIP-4851 | 11/01/2010 | 10037492 | Ready | 05/24/2011 | |
| PIP-4851 | 11/01/2010 | 10037492 | Gm: there is an intermittent engine light on due to five possible internal trouble codes. there may also be an extended crank after filling the fuel tank. *rm | 05/24/2011 | |
| PIP-4851 | 12/01/2010 | PIP-4851A | 10037492 | Gm: there is an intermittent engine light on due to five possible internal trouble codes. there may also be an extended crank after filling the fuel tank. *rm updated 5/31/11. *pe | 05/24/2011 |
| PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
| PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
| TB-09-06-04-022 | 05/01/2009 | TB-09-06-04-022A | 10030110 | General motors: malfunction indicator lamp (mil) illuminated, intermittent dtc p0191, slow fuel rail pressure (frp) decay, wiring harness connections, voltage fluctuations/interruptions (follow correction information below). *pe | 08/03/2009 |
| SB-07-06-04-019A | 11/01/2008 | 10028831 | General motors: intermittent mil/ses/ dtc p2138 with reduced engine power (repair instrument panel (ip) to body harness connector). 2005-08 gm passengers cars/light duty trucks (incl. saturns). *pe | 06/01/2009 | |
| 060604066 | 03/01/2007 | 060604066A | 10021106 | Lbz, lly, engine with rough idle, poor performance, black/white exhaust smoke, mil/ses light on and one or more of the following dtc's p003a, p060b, p0230, p0403, p0401, p0606, p2146, p2149, p2152, p2155. (reprogram ecm and replace egr mot | 03/05/2007 |
| 030693001 | 05/01/2006 | 030693001C | 10020839 | Diagnostic information on turbocharger malfunction due to lack of engine oil for lbz, lb7, and lly duramax diesel engine. *kb | 01/24/2007 |
| 050308019 | 07/01/2007 | 050308019B | 10020818 | Diagnostic information for noise in steering and inspection of idler arm bracket. *kb updated on 09/19/07. *nj | 01/23/2007 |
| 06529 | 05/01/2006 | 10020056 | Water in fuel light inoperative because of an error in the engine control module (ecm) calibration. *tt | 07/14/2006 | |
| 06522 | 03/01/2006 | 10019930 | Engine glow plug system concern - reprogram glow plug control module. *tt | 05/16/2006 | |
| 3744 | 10019828 | Duramax head gasket and torque specification change. *tt | 05/02/2006 | ||
| 060601003 | 01/01/2006 | 10019474 | Information on longer main bearing cap bolts required for certain 2001-2006 lb7, lly, lbz duramax diesel engines. *tt | 03/15/2006 | |
| 040604001 | 12/01/2006 | 040604001C | 10011126 | Various intermittent driveability conditions - hesitation, lack of power, etc. *tt | 01/03/2005 |
| ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
| PI-0474 | 05/01/2011 | 10038744 | Ready | 06/27/2011 | |
| PI-0474 | 05/01/2011 | 10038744 | Gm: an 'engine power is reduced' message appears and there is a stored trouble code. this is caused by wear of the internal fuel injector. *rm | 06/27/2011 | |
| PIP-4629 | 04/01/2009 | 10030207 | Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe | 08/18/2009 | |
| SB-08-06-04-029B | 07/01/2009 | SB-08-06-04-029C | 10030123 | General motors: lbz, lly, lmm mil/ses light n dtc p0087-fuel rail pressure (frp) too low, lack of performance, no power, engine runs rough, no start (diagnose fuel system components). *pe updated 3/1/10. *pe | 08/05/2009 |
| 060601006 | 03/01/2006 | 10019849 | Information on 2006 6.6 lbz lly duramax diesel engine cylinder head gasket change - new head gasket and torque specification. *tt | 05/05/2006 | |
| 3586 | 08/01/2009 | PIP-3586F | 10019434 | Diesel engine glow plug trouble codes. *tt updated 3/15/10. *pe | 03/14/2006 |
| 3722 | 10019439 | Diesel engine extended idle smoke. *tt | 03/14/2006 | ||
| 3647 | 10018605 | Diesel engine vibration felt at all rpm. *tt | 01/06/2006 | ||
| 030693001A | 08/01/2005 | 030693001B | 10004319 | Diagnostic information for turbo failure due to lack of oil or repeat turbo failures. *tt | 12/02/2003 |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||||
| 3068 | 3068D | 10009606 | Oil seepage from turbo air charge cooler hoses or hose blowing off during acceleration. possible diagnostic trouble code p0299. *tt updated 04-24-07. *kb | 10/08/2004 | |
| ENGINE AND ENGINE COOLING - ENGINE - OTHER FUEL TYPES - TURBO-CHARGER | |||||
| PIP-4629 | 04/01/2009 | 10030207 | Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe | 08/18/2009 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||||
| PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
| PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
| PIP3343 | 02/01/2008 | PIP3343A | 10024344 | Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj | 04/07/2008 |