Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| SB-09-06-03-004A | 09/01/2009 | SB-09-06-03-004B | 10032332 | Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). | 03/05/2010 |
| PIT-4662 | 06/01/2008 | 10026744 | Gmc: sir mil dtc b0084 and/or b0085. this concern could be caused by broken seat position sensor circuits under the driver or passenger front seats. over time, from repeated seat movement, the wiring could break. *pe | 12/12/2008 | |
| ELECTRICAL SYSTEM - WIRING | |||||
| SB-09-06-03-004A | 09/01/2009 | SB-09-06-03-004B | 10032332 | Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). | 03/05/2010 |
| PIT-4662 | 06/01/2008 | 10026744 | Gmc: sir mil dtc b0084 and/or b0085. this concern could be caused by broken seat position sensor circuits under the driver or passenger front seats. over time, from repeated seat movement, the wiring could break. *pe | 12/12/2008 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||
| PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
| In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ELECTRICAL SYSTEM - BATTERY | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
| In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
| ELECTRICAL SYSTEM - BATTERY - CABLES | ||||||
| PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
| In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
| ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ELECTRICAL SYSTEM - WIRING | ||||||
| PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
| In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | ||||||
| PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
| In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 11/11/2012 | 92000 | 1 | |
| Hvac system became operational with the ignition turned off for an unknown period of time while the truck was parked in the garage. relay resistor module overheated causing melting of the resistor and circuit board. truck cabin and vicinity around the truck had a strong smell of burning plastic. truck cabin filled with smoke. was only able to turn off the hvac system and stop the burning by disconnecting the wiring harness. dealer had to replace the blower motor, resistor, module connector and relay. burning could have caused the entire vehicle to catch fire causing significant damage to other vehicles parked nearby and the house in which the garage was attached. issue was identical to scenario described in transport canada recall #2011074. *tr | |||
| 11/11/2012 | 92000 | ||
| Hvac system became operational with the ignition turned off for an unknown period of time while the truck was parked in the garage. relay resistor module overheated causing melting of the resistor and circut board. truck cabin and vicinity around the truck had a strong smell of burning plastic. truck cabin filled with smoke. was only able to turn off the hvac system and stop the burning by disconnecting the wiring harness. dealer had to replace the blower motor, resistor, module connector and relay. burning could have caused the entire vehicle to catch fire causing significant damage to other vehicles parked nearby and the house in which the garage was attached. issue was identical to scenario described in transport canada recall #2011074 | |||
| 03/29/2010 | 33800 | ||
| Engine shuts down, service brake system message appears in display, abs light illuminates. since engine shuts down, lose steering and braking. latest incident occured on highway during rush hour. this also happened first year i owned the vehicle (i bought it new), they replaced the underhood fuse box. this happened again on march 13. they replaced a blown pcm fuse and said they could find nothing wrong. when it occured on 3/29, i replaced the fuse 5 times to try and get off the freeway. after each time it was replaced, i could drive 1-2 miles before it would blow again. | |||
| 04/28/2009 | 47000 | 1 | |
| Our customer/insured was driving his 2007 gmc sierra on april 23, 2009 with his child in the back seat, the auto started on fire as he was driving. he was able to get out of the auto with the child before fire reached the interior. the fire started in the engine compartment and traveled throughout the rest of the auto before the fire department could get to the scene. over 3/4 of the auto was totally burned. owners name is john czech. *tr | |||