Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | ||||||||||||||||
| 97V218000 | GENERAL MOTORS CORP. | from 03/01/1997 to 08/31/1997 | V (Vehicle) | 19716 | 12/15/1997 | MFR | GENERAL MOTORS CORP. | 11/24/1997 | 12/03/1997 | |||||||
| Defect Summary | Vehicle description: light duty pickup trucks and multi-purpose passenger vehicles. a fatigue fracture of the rear axle right-hand brake pipe can occur causing a slow brake fluid leak resulting in a soft brake pedal. if the brake pipe breaks, the driver would experience a sudden drop in the brake pedal, the instrument panel brake light would illuminate, and there would be a loss of rear brake performance. | |||||||||||||||
| Consequence Summary | Partial loss of braking at a time when minimum stopping distance was required could result in a vehicle crash. | |||||||||||||||
| Corrective Summary | Dealers will inspect and replace the brake pipe. | |||||||||||||||
| Notes | Owner notification is expected to begin during december 1997. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, oldsmobile at 1-800-442-6537, or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SERVICE BRAKES, AIR - ANTILOCK | |||||
| 020525006A | 12/01/2002 | 020525006 | 10000749 | Antilock brake (abs) activation at low speeds on various models including the 1995 and 1996 envoy. *tt | 03/28/2003 |
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||||
| 020525006 | 01/01/2006 | 020525006B | 10000062 | Antilock brake (abs) activation at low speeds. *tt | 02/10/2003 |
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM | |||||
| 270901 | 09/27/2001 | 626507 | Subject regarding necessary resurfacing of the park brake drum. *jg | 12/14/2001 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SERVICE BRAKES, HYDRAULIC | |||
| 01/15/2003 | 57000 | 08/25/1998 | |
| Started off with a sudden failure to accelerate on highway then corrected itself; on and off for a few weeks. discovered that brake pedal was soft and was failing to return to starting position; replaced master cylinder to eliminate soft pedal but still sticking and not returning to starting position. cannot find cause. *nlm | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 08/31/2004 | 80000 | 1 | |
| When parking brake pedal went to the floor, causing extended stopping distance. dealership was notified, but did not resolve the problem. *ak | |||
| 1 | |||
| The anti-lock brake system locked up, which resulted in extended stopping distance.*jb | |||
| Anti-lock brakes failed to stop when pedal was depressed but did grab abruptly. disc brakes are on the front and rear are drum brakes. please describe details. *ak | |||
| 02/01/2001 | 0 | ||
| When he applying brakes abs braking light came on. therefore, system was inoperable. dealership was aware of problem. mechanic told him that ebcm devices were bad .this was brain unit to this device. *ak | |||
| 03/01/1998 | |||
| My 1998 gmc sonoma developed a braking problem - pulling hard right. the vehicle (under warranty - 15,000 miles) was taken to the dealership to correct the problem. the front rotors were turned, pads deglazed, wheel bearings repacked, rear drums turned and shoes adjusted to correct the problem. the cost to me was $217. i have never experienced brake problems at such low milage on any vehicle i have ever owned. i am convinced that a defect exists in the braking system that gm is attempting to blame on the consumer. *ak | |||
| 12/25/1999 | |||
| Abs brake problems: whny applying brakes during an emergency on wet pavement/icy or snowy roads, brakes locked up, causing extended stopping distance. this condition could cause a crash. dealer could not duplicate this problem, and problem has not been corrected. *ak *ml | |||
| While driving 20mph driver applied brakes and the vehicle did not stop. consumer rear ended another vehicle. neither driver's side nor passenger's side airbags deployed. dealer said it was normal. driver has rib cage injury. *ak | |||
| 10/16/1999 | 0 | ||
| While driving at about 35-45 mph, trying to slow down and make a turn, and brakes went to the floor. consumer lost control of vehicle and crashed into two trees, and air bag did not deploy. *ak | |||
| When applying the brakes the left front wheel locks up and pulls the vehicle to left or right. dealer says it's normal. *ak | |||
| 10 | 04/01/1998 | ||
| Unccceptable maintenance required., unsatisfactory dealer repairs, service, and satisfaction. no safety efects listed in the summary. *ak | |||
| 05/13/1998 | |||
| Consumer was pulling vehicle into garage ,went to apply brakes,vehicle did not stop, causing loss of control and resulting in a crash. pushed pedal to floor , no response. dealer claims no defect in vehicle. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
| When applying brakes in snowy weather there is clicking sound present and vehicle will not stop. dealer has not seen vehicle. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - ROTOR | |||
| 03/01/1998 | |||
| My 1998 gmc sonoma developed a braking problem - pulling hard right. the vehicle (under warranty - 15,000 miles) was taken to the dealership to correct the problem. the front rotors were turned, pads deglazed, wheel bearings repacked, rear drums turned and shoes adjusted to correct the problem. the cost to me was $217. i have never experienced brake problems at such low milage on any vehicle i have ever owned. i am convinced that a defect exists in the braking system that gm is attempting to blame on the consumer. *ak | |||
| 05/03/1999 | |||
| Had taken vehicle to dealer to check the brakes. the rotors had worn out & were shot. service manager informed manufacter of problem and was told to replace the rotors, but not the pads. was charged for the rotors, even though under warranty. had vehicle checked again & repairs were not done, but the rotors were turned. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | |||
| 04/24/2006 | 107030 | 1 | 09/14/1998 |
| In april 2006, a brake line on my 1998 gmc sonoma pickup broke when i applied the brakes at approx 50 mph. i had to stop rather quickly due to traffic backing up on an interstate highway. when the brake line burst, my brake pedal went to the floor and i had no brakes. prior to this happening, the brakes were working fine. fortunately, i was able to swerve into another lane and downshift (std shift) to avoid an accident. my mechanic replaced the broken line (from hydraulic abs to junction) and also the rear brake pads and rotors. the truck had 107,000 miles on it when this occurred. i decided to report this because i am concerned that it might happen to others, resulting in a serious accident.*jb | |||