Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN | |||||
| 990730016A | 10/01/2002 | 990730016B | 10007838 | Diagnostic information for intermittent transmission downshift, slip, busy/cycling tcc or noisy cooling fan. *tt | 07/12/2004 |
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| 030730056 | 11/01/2003 | 10005566 | 4l60-e automatic transmission oil pump first and second design identification. *tt | 03/04/2004 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||||
| 020730024A | 08/01/2005 | 020730024B | 634999 | Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt | 10/11/2002 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 05/18/2004 | 132000 | 1 | 03/24/2001 |
| Automatic transmission-driving down the interstate on vacation when a cloud of smoke was noticed out the rear of the suburban. pulled over to the side of the road to find transmission fluid sprayed all out of the over flow tube. i was told that too much pressure was built up and the suburbans are known for that. filled it back up with transmission fluid and the transmission continued to slip. had to give up the vacation and get a tow back home. fluid had sprayed all over my vehicle and vehicles behind me. it was extremely hot. luckily i got it shut down before a fire caught. had to replace the transmission at a heavy cost. *ak | |||
| 01/17/2004 | 60000 | 8 | 10/31/1996 |
| 1997 gmc suburban- multiple engine & transmission failures. at 60,000 miles, vehicle began to shift hard. returned to shop for diagnosis and repairs several times for work. finally, while driving the vehicle in city traffic, the transmission failed compeletly. required valve cover and transmission rebuild @ cost of $2,000. on december 27 '03, had to replace the radiator. on jan 17 '04, discovered that there was no antifreeze in new radiator. returned to mechanic who replaced the radiator. said the intake manifold needed to be replaced. cost: ~$600. took to another mechanic for second opinion. same diagnosis. both state that gm is aware of both problems, however, they will not cover the costs of repairs or replacement. additionally- replaced alternator two times; replaced water pump two times; replaced the master cylinder in fall 2003. *ak | |||
| 05/02/2003 | 1 | ||
| The vehicles transmission failed at 47000 miles (1997 gmc). *nlm | |||
| 05/01/2001 | |||
| Example of problem, when the truck has run 50 miles or so on the freeway, stop at off ramp. the truck shifts hard from 1st to 2 nd when i pull away. this continues until i shut the truck off, wait a few minutes and start again. then it is fine for a while and will repeat the same, sometimes weeks apart, more often in the summer months. my driving pattern is one of short trips, so i guess this is why my problem is sparodic. i have read many complaints one web sites about this problem with other gm cars and trucks,the code #1870 seems to figure in most cases, most people have had no luck with gm, and are stuck with bills of 2-3000 dollars. i hope you can check this out, seems to cover gm cars and trucks from the 80s-01. thank's graham brown. dt | |||
| 03/01/2000 | |||
| While turning corner in subdivision transmission would not shift into 2 gear. jumped into 3rd gear and the truck jumped forward. proceeded to drive on highway to get home and once slowed the truck continued to roar until jumping into 3rd gear. once the truck was stopped, i had no reverse. i was told the reverse housing broke,which causes the gears to slip and this happens without any warning...no previous transmission slipping and is a common thing in this model suburban . transmission tech also showed me where this reverse part broke and said general motors is aware of the problem and has made a stronger part for the transmission. if gm knows this is a problem why is this not a recall? it is caused from a faulty part. to fix this problem is costing me over 1500.00 dollars. the abs brakes have to be held to the floor and then the back wheels skid. i thought the whole purpose of the abs braking system was to stop the skidding. it is as if the locking system does not work on sudden stops. because the locking does not take over, the front brakes have to much weight to stop because the rear drums are not enough to complete the stop. they do not work together, causing the pads and shoes to wear out and grind the rotors and drums. the passenger back door electric window while rolling it down makes a clunk noise and then it will only roll back up to the point where the noise is. you have to have 2 people get the window up. one holding the window and pulling at it upwards while the other holds the button to get it to catch.*ak | |||
| 07/01/1997 | |||
| This happens only when the vehicle is completely warmed up. no safety defect. | |||
| 07/12/2001 | 1 | 01/01/1998 | |
| Transmission races between 2nd and 3rd, then clunks hard to shift. *ak | |||
| 04/22/2001 | 1 | 04/01/2001 | |
| Harsh 1st to 2nd upshift; based on my research, gm has been aware of problem but has been unresponsive. *ak | |||
| 04/05/2001 | 1 | 11/01/1997 | |
| On a 400 mile trip over easter weekend, we noticed that the transmission started shifting very hard in the first through third gears. we became aware of the problem as we began driving the suburban after a rest stop. we became very concerned about the transmission when we tried to pass vehicles of accelerate up hills and it seemed as though the overdrive was not engaging. the following day, i took the vehicle to the only repair shop in a small town on the mississippi gulf coast. they advised me to have the transmission serviced, (replace filter, and fluid). i paid $135 to do that. the problem was not solved. the week of april 16th, through the advise of a gmc customer rep, i took the sub to the dealer in hopes that a computer upgrade would solve the problem. they advised me that the upgrade was already done and the only thing they could do was to tear down the transmission to find the cause. i declined and requested (through the dealership and gmc) to meet with a gmc zone manager. they have yet to reply. i found litterally hundreds of the exact problems at www.thecomplaintstation.com/g/_gm. general motors is very much aware of this problem and they refuse to recall the vehicle. *ak | |||
| 08/01/1997 | |||
| No summary listed for above vehicle. *ak | |||
| 06/19/2000 | 1 | ||
| Vehicle is experiencing transmission problems continually requires repairing. *mjs | |||
| 11/15/1999 | 2 | 11/01/1997 | |
| No summary | |||
| 07/17/2000 | 3 | 08/01/1997 | |
| The front brakes of the suburban has been replaced for the second time with raybestos (lifetime wear) brake shoes. my transmission started shifting very hard, as if someone had rearended the truck at a slow speed. i took it to aamco transmission's for repears. aamco rebuilt the transmission, but did'nt fix the problem. after $2200.00 and the fifth attemt to fix the problem i took it to a gmc dealer and they actually fixed the problem the first time for $308. | |||
| 06/19/2000 | 1 | ||
| Vehicle is experiencing transmission problems continually requires repairing. *mjs | |||
| 04/27/2000 | 10/01/1997 | ||
| On april 10, transmission failed and vehicle was returned to dealership. on april 18, the vehicle was returned to the owner after having replaced the transmission, the transmission cooler, and intake manifold gasket. on april 27, 2000, the engine failed on a busy road as schools were letting out. the engine failure, put both the occupants of the vehicle at risks and the schoolchildren also, as the engine failure resulted in loss of power steering and power brakes. the driver avoided collision but with no steering and loss of braking power, the results could have been catastrophic. *ak | |||
| 03/27/2000 | 1 | 06/01/1999 | |
| Transmission overheated (unknown reason per dealer) vented all fluid. transmission had to be replaced. *ak | |||
| 11/01/1998 | 2 | 02/01/1997 | |
| Transmission failed and the replaced transmission failed too. yh | |||
| 01/22/2000 | 1 | 01/01/2000 | |
| Normal highway speed i noticed a lot of smoke coming from rear of vehicle i stopped and heard a hissing noise under vehicle and saw oil spraying on the exhaust pipes near transmission it then caught fire put fire out i checked fluid level in transmission it was low help showed up with oil filled it back up continued home at slow speed approximately 50 miles later o.d. started to slip then drive started to slip so i drove 30 mph in 2nd was told that transmission was going out because of fluid loss out of vent tube | |||
| 07/24/1999 | 1 | 10/01/1996 | |
| Rear end of transmission crack in half causing fluid to leak out vehicle had to be towed on flat bed 140 miles to get home the entire end of the transmission was broke had to defect in the casting of housing or a design flaw car has high miles due to much travel mechanic stated never saw transmission brake like that before contacted dealer and had dealership mechanic look at it but they stated they were not going to help us they say lack of maintanince to the car we have had our car checked every 3 -4 thousand miles oil changes ect we have receipts for everything we feel gmc had a craftsmanship defect on should cover this even if we are out of warranty | |||
| 07/01/1999 | 2 | ||
| While driving at 55 mph vehicle is shifting very hard from first to second gear. transmission has been replaced twice.dealer can't determine the problem. *ak | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||
| 02/03/2000 | 0 | ||
| While car was sitting noticed transmission fluid leaking. took vehicle to dealer, and they said it was the transmission. *ak | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||
| 06/08/1999 | 1 | 01/01/1997 | |
| Lost control traveling down interstate i-20 eastbound in conyers, ga. axle separated, and rear wheel came off. suburban flipped 3x, skidded on passenger side & came to rest upside down. airbags did not deploy but car was totally destroyed, including multiple hits on front bumper. 1 passenger airlifted to medical ctr; 3 others transported by ambulance. all alive & healing (thank god), but don't understand why airbags didn't deploy & axle could separate. *ak | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - PARK/NEUTRAL START SWITCH | |||
| 04/12/2000 | 1 | 09/01/1997 | |
| When changing gears there was a knocking noise. service department at the dealership, where the vehicle was purchased, informed consumer that this was a common problen encountered with this particular type of electronic shift transmission . *ak | |||
| POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT - SEAL | |||
| The rear axle seals leak onto the brake lining to point were the brakes wear badly and the emergency parking brake is useless. the problem has been corrected by the dealership. *ak | |||
| POWER TRAIN - DRIVELINE | |||
| 05/12/1998 | 1 | 10/01/1996 | |
| The shaft in the power steering pump busted in two as my husband was driving into a curve @ 60 mph. he was able to keep from crashing. but if i would have been driving it i wouldn't of been able to steer it. my husband walked in the house white as a ghost. the dealer wanted me to drive it in 10 miles on a curving road with no power steering. i tried to drive it impossible for me to do. the brakes wore out and were replaced a second time (front) @ 36000 miles. the rotors were replaced, had been 10,000 miles since last brake job. the rear brakes needed readjustment again at 43200 miles the pedal kept going to the floor and was soft. 11/98 began having more electrical problems with the rear fan blower would not turn off and will run the battery dead constantly. 1/99 both front and rear u-joints were bad, had replaced the car was wandering even worse than it used to they could not find cause. the front differential was leaking and front brakes need replacing again. 2/16/99 the transmission went out in the vechile at 53174 miles. i drove the car 3 miles into town the rpms started going up to 4000rpms wasn't shifting i stopped and parked i tried to back up it started whinning and clunking and wouldn't move. three miles earlier i backed out of my garage with no hint of trouble 3 miles later i am stranded with two babys. my husband contacted gm they refused any assistance. i continued contacting gm through other avenues i called roy roberts one of the vp explained i had some safety concerns with the suburban. i was told he would return my phone call, no return call ever received. i finally found a factory rep. that is looking into the problem but i don't hold out much hope that gm will respond to our concerns. every time i have talked to a gm rep. they tell me no one else has these problems, but according to your records lots of people have had similiar problems. i have all records and receipts and would love to go into more detail with you. | |||
| POWER TRAIN - DRIVELINE - UNIVERSAL JOINT | |||
| 05/12/1998 | 1 | 10/01/1996 | |
| The shaft in the power steering pump busted in two as my husband was driving into a curve @ 60 mph. he was able to keep from crashing. but if i would have been driving it i wouldn't of been able to steer it. my husband walked in the house white as a ghost. the dealer wanted me to drive it in 10 miles on a curving road with no power steering. i tried to drive it impossible for me to do. the brakes wore out and were replaced a second time (front) @ 36000 miles. the rotors were replaced, had been 10,000 miles since last brake job. the rear brakes needed readjustment again at 43200 miles the pedal kept going to the floor and was soft. 11/98 began having more electrical problems with the rear fan blower would not turn off and will run the battery dead constantly. 1/99 both front and rear u-joints were bad, had replaced the car was wandering even worse than it used to they could not find cause. the front differential was leaking and front brakes need replacing again. 2/16/99 the transmission went out in the vechile at 53174 miles. i drove the car 3 miles into town the rpms started going up to 4000rpms wasn't shifting i stopped and parked i tried to back up it started whinning and clunking and wouldn't move. three miles earlier i backed out of my garage with no hint of trouble 3 miles later i am stranded with two babys. my husband contacted gm they refused any assistance. i continued contacting gm through other avenues i called roy roberts one of the vp explained i had some safety concerns with the suburban. i was told he would return my phone call, no return call ever received. i finally found a factory rep. that is looking into the problem but i don't hold out much hope that gm will respond to our concerns. every time i have talked to a gm rep. they tell me no one else has these problems, but according to your records lots of people have had similiar problems. i have all records and receipts and would love to go into more detail with you. | |||