Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE | ||||||||||||||||
| 06E043000 | HONEYWELL INTERNATIONAL, INC. | E (Equipment) | 88303 | 10/18/2006 | MFR | GENERAL MOTORS CORP. | 05/19/2006 | 05/22/2006 | ||||||||
| Defect Summary | Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on document search and then bus applications). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line. | |||||||||||||||
| Consequence Summary | This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur. | |||||||||||||||
| Corrective Summary | Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1). | |||||||||||||||
| Notes | This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, GASOLINE | |||
| 01/01/2005 | 98641 | 3 | 12/28/2002 |
| Gas gauges are defective,fuel system and gasoline system are not working propoperly.all door lock actuators have been replaced and now they have stopped working again,other people with this suv have the same problems,i'm a single female,and i am getting ripped off. *ak | |||
| 04/04/2002 | 30000 | 07/19/2001 | |
| All five doors on my 1999 gmc suburban have defective door lock actuators! my fuel gauge also stopped working in april 2002.*nlm | |||
| 12/27/1999 | 8 | 02/12/1999 | |
| Vehicle has been in shop 8 times for gas fumes filling the cargo area. dealer said problem can't be fixed. *ak | |||
| FUEL SYSTEM, GASOLINE - CARBURETOR SYSTEM | |||
| 09/08/1999 | 5 | ||
| #7 spark plug would fail. also, changed intake manifold & head gaskets. problem was not intermittent. happened all time. took vehicle to shop for repairs & problem still exists. *ak | |||
| FUEL SYSTEM, GASOLINE - DELIVERY | |||
| 08/12/2002 | 2 | 08/01/2099 | |
| For a brand new suburban i don't feel it should be having major part problems. no safety defect listed. *ak | |||
| FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
| 04/20/2006 | 156000 | 3 | 11/09/1998 |
| Fuel pump/connector failure. initially engine would shut down intermittently. on last occasion, vehicle engine shut down resulting in loss of power steering, power brakes, etc. would not restart. former gm mechanic told me that he witnessed this problem numerous times and found most cases involved failure of electrical connector or ground connection at fuel pump. *jb | |||
| 10/21/2005 | 102000 | 1 | 07/01/2004 |
| Dt: the consumer stated that while driving with a quarter tank of gas the vehicle stalled without any previous warning. then, it completely died. the consumer pushed the vehicle to the side of the road. the consumer was finally able to restart the vehicle after several attempts, and drive home. the next day he inspected the connection to the fuel pump. he discovered there was low voltage to the electrical assembly area. nhtsa recall campaign 05v155000 was issued involving the same type of vehicle. this vehicle was not included in the recall due to the vin, but was experiencing the same problem as indicated in the recall. the consumer called gm ,who suggested a diagnostic test. no repairs have been made due to the expense of the repairs. *ak (11/22/05) *sc updated 01/10/07. *jb | |||
| 04/06/2003 | 95361 | 1 | 11/08/2001 |
| Failure of fuel pump on 1999 gmc suburban with 45 gallon tank, 350 engine. left vehicle in non starting situation. *jb | |||
| 02/01/2000 | 0 | ||
| While driving down road at an extended amount of time vehicle will shut off. took to dealer , and they did a program upgrade. consumer continued to have problem, but dealer couldn't duplicate the problem.*ak | |||
| 10/01/1998 | |||
| Fuel pump has been replaced two times due to loud noises. also, transmission was replaced because it did not shift gears automatically, rough switch. abs brakes did not operate properly, causing extended stopping distance. in addition, two tires replaced in the rear due to vibration of vehicle. dealer contacted, and are attempting to remedy the problems that exist. provide further information. *ak | |||
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||
| 10/18/1999 | 1 | 09/16/1999 | |
| Consumer's car was pulling to right and braking to left. took to dealer, and and they aligned front end, and did repairs on brakes and knuckles. *ak the steering wheel wobbles when the vehicle comes to a stop. there was wind noise from right side of the vehicle. the engine idles rough due to dirty injectors. the vehicle vibrates at speeds of 80-90 mph due to bent wheel. the vehicle would not start due to a weak battery. the steering moans when turning due to failure of evo sensor on steering column. *yh | |||
| 03/01/2000 | 5 | 11/21/1999 | |
| Vehicle has been to dealer 5 times. fuel injector gets clogged, and vehicle will stall in traffic. dealer says additives in gasoline clogs injector. *ak the engine stalling resulted in loss of steering power and brake failures. the manufacturer extended the warranty admitting the problem. the consumer finally turned in the vehicle to the manufacturer. *yh | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
| 12/15/1999 | |||
| While driving daughter to school, pulled into the parking lot and vehicle stalled, and would not start again. had vehicle towed to the dealer, and they broke the fuel sending unit. which they replaced. but, still having problem with vehicle stalling. engine check light came on and stayed on. they pressurized the tank. now the gas gauge does read properly. *ak | |||
| FUEL SYSTEM, OTHER | |||
| 02/09/2011 | 66000 | ||
| Engine rpm increases when foot is off the accelerator while driving. this issue started approximately 4 months ago and is on going, each time the vehicle is driven. this is unintended acceleration. | |||
| 12/15/1999 | |||
| While driving daughter to school, pulled into the parking lot and vehicle stalled, and would not start again. had vehicle towed to the dealer, and they broke the fuel sending unit. which they replaced. but, still having problem with vehicle stalling. engine check light came on and stayed on. they pressurized the tank. now the gas gauge does read properly. *ak | |||
| FUEL SYSTEM, OTHER - DELIVERY - FUEL PUMP | |||
| 04/26/2005 | 52000 | 1 | 12/05/1999 |
| Noisy fuel pump in gas tank, non functioning fuel guage. spoke with several friends who own full size gm pickups, suv's and vans from same era. fuel guage, fuel pump problems have occured in 5 out of 6 vehicles. | |||
| FUEL SYSTEM, OTHER - FUEL INJECTION SYSTEM | |||
| 10/22/2002 | 50013 | 6 | 01/31/2000 |
| Injector pump failure causing the vehicle to just stall when going down the road. it happened to me the last hot weekend this fall. the local dealer took my vehicle & had it for over a week, finally getting a code to show up that allowed them to replace the injector pump. i don't believe that the injector pump was at fault, but instead the pmd electronic control module was failing. this replacement didn't cost me anything, but i think gm should extend the warranty for a much longer period of time because of the known problem. they extended the warranty to 120,000 miles on an engine that is designed to run 200,00+ miles w/proper care. my vehicle has approx. 50,000 miles on it at this time. | |||
| FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||
| 01/01/2005 | 98641 | 3 | 12/28/2002 |
| Gas gauges are defective,fuel system and gasoline system are not working propoperly.all door lock actuators have been replaced and now they have stopped working again,other people with this suv have the same problems,i'm a single female,and i am getting ripped off. *ak | |||
| 04/26/2005 | 52000 | 1 | 12/05/1999 |
| Noisy fuel pump in gas tank, non functioning fuel guage. spoke with several friends who own full size gm pickups, suv's and vans from same era. fuel guage, fuel pump problems have occured in 5 out of 6 vehicles. | |||
| 07/29/2003 | 50000 | 18 | 01/15/2000 |
| Door acuators faulty. power steering pump replaced. fuel guage faulty. security system overrides starter which does not allow the vehicle to be started. we have had the vehicle serviced three times for door actuators as we were told this is what was causing security system to shut down vehicle. this did not solve the problem. gmc national service center was not helpful. they did not return calls or set-up special service appointment at local dealer as they promised. there are several incident dates of when we could not start our vehicle. will use july 29th as one date, unable to start vehicle while on summer vacation in lake tahoe area. if this happens during real emergency it would be unfortunate. | |||