Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
POWER TRAIN - CLUTCH ASSEMBLY | ||||||||||||||||
02V052000 | GENERAL MOTORS CORP. | from 09/01/1998 to 08/31/2000 | V (Vehicle) | 1530 | 04/23/2002 | MFR | GENERAL MOTORS CORP. | 02/12/2002 | 02/26/2002 | |||||||
Defect Summary | Certain medium duty tilt cab trucks equipped with manual transmissions have a condition in which the clutch master-cylinder pushrod end that attaches to the clutch pedal pin can wear prematurely. the first noticeable effect of this wear could be the clutch pedal not returning completely to the full-up position. | |||||||||||||||
Consequence Summary | If this occurs, the fast-idle engine speed control may not function. if the clutch master-cylinder pushrod end wears sufficiently to allow the attaching end to bend open or break off, the pedal pin would detach from the clutch rod link and the clutch would engage. if clutch engagement occurred while the vehicle was stopped, with the engine running and the transmission in gear, and if the brakes were not applied, the vehicle could move forward if the transmission were in a forward gear, or rearward if the transmission were in a reverse gear. | |||||||||||||||
Corrective Summary | Dealers will install a new clutch master-cylinder assembly and clutch pedal assembly. owner notification began april 23, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. | |||||||||||||||
Notes | Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
020730017 | 05/01/2002 | 634968 | Concern with no shift, harsh shift, no engagement, transmission in default, check transmission warning indicator illuminated, range inhibited indicator illuminated, transmission diagnostic trouble codes set on f-model medium duty tilt cab m | 10/10/2002 | |
POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT - SEAL | |||||
010420005 | 11/01/2001 | 627737 | Information regarding correct vehicle application for eaton. 1990-2002 chevrolet and gmc c-series conventional and t-series tilt cab medium duty models. *yh | 02/15/2002 | |
POWER TRAIN - CLUTCH ASSEMBLY | |||||
02006 | 04/16/2002 | 636545 | This message announces recall 02006 regarding a condition in which the clutch master cylinder push rod end that attches to the clutch pedal pin may wear to the point of not performing as intended. *tt | 11/09/2002 | |
02006A | 05/29/2002 | 02006 | 634259 | Subject regarding recall 02006a revision - clutch master cylinder pushrod wearout. *tt | 09/28/2002 |
010731003 | 12/01/2001 | 628902 | Concerns about a slipping clutch or early clutch failure. *tt | 03/21/2002 | |
POWER TRAIN - MANUAL TRANSMISSION | |||||
160201 | 02/16/2001 | 619242 | This message concerns certain 1997 through 2001 medium duty trucks with spicer seven speed manual transmissions exhibiting heavy vibration that increases with speed and / or an oil leak and / or a cracked engine block. *tt | 05/21/2001 | |
990729004 | 08/01/1999 | 607589 | Some medium duty models equipped with manual transmissions may exhibit a high shift effort or hard shifting condition. *tt | 09/29/1999 | |
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||||
990421003 | 06/01/1999 | 606091 | Some owners may comment about a slipping type condition at the front wheels while the vehicle is in four wheel drive (4wd). *tt | 08/06/1999 |