Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
STEERING | ||||||||||||||||
07V469000 | GENERAL MOTORS CORP. | from 07/01/2003 to 06/30/2004 | V (Vehicle) | 990 | 10/25/2007 | MFR | GENERAL MOTORS CORP. | 10/04/2007 | 10/04/2007 | |||||||
Defect Summary | On certain medium duty trucks equipped with zf model 8018 steering gears, the steering gear may have been produced incorrectly. a steering gear with this condition may produce the feeling of hitting a curb and a cracking or pinging sound when the steering wheel is turned. | |||||||||||||||
Consequence Summary | The steering wheel position may be off-center and increased effort may be required when turning, increasing the risk of a crash. | |||||||||||||||
Corrective Summary | Dealers will inspect for certain date codes and verify the mileage on steering gears and replace gears as necessary. the recall began on october 25, 2007. owners may contact chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or isuzu at 1-800-255-6727. | |||||||||||||||
Notes | Gm recall no. 07220.customers may also contact the national highway traffic safety administration |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
STEERING | |||||
091703 | 09/17/2003 | 10005037 | Vehicle may have a tighter turning radius in one direction or the other, or may not be able to achieve the turning radius due to the self-adjusting steering limiter not set. gm voicemail log. *tt | 01/26/2004 | |
030232044 | 09/01/2004 | 030232044A | 10004297 | Effect of steering box limiter adjustment on turning radius and possibility of power steering system damage due to improper adjustment. various 1990-2004 models. *tt | 12/01/2003 |
STEERING - GEAR BOX (OTHER THAN RACK AND PINION) | |||||
PIT-4883 | 07/01/2009 | 10032397 | Gmc/chevrolet: fluid leak at steering gear input shaft. all c series models. when repairing a power steering fluid leak at the steering gear input shaft stub seal beware that the pressure seal is not available from gm spo parts. | 03/15/2010 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
STEERING - LINKAGES | |||
11/28/2005 | 1 | ||
Dt*: the contact stated upon inspection, the vehicle's drag links were worn out to the point of falling off. the contact expressed that steering would be completely lost if the drag links fell off. the dealer was contacted numerous times and determined that there was no problem with the vehicle. the manufacturer was not contacted. | |||
STEERING - LINKAGES - LINK - DRAG - CONNECTION | |||
08/28/2006 | 31000 | 5 | 05/15/2004 |
Drags links failing prematurely on gmc topkicks. first found at 31,000 miles. checked the rest of the fleet and found 3 others failed. since then we have had failures in as little as 6300 miles. brand new just put in service. these are 2004/2005 and 2006 gmc. parts were replaced under warranty. warranty refused on the second go around. (so far) dealer is investigating. failure would mean loss of steering control. death and injuries. *nm |