Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 3024 | 01/01/2004 | 3024A | 10010076 | Gen iii engine coated piston information. *tc | 11/04/2004 |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| 3121 | 01/01/2004 | 10010248 | Exhaust vibration resonance or moan in vehicles with gen iii v8 engines. *tc | 11/08/2004 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 3004 | 01/01/2004 | 10008891 | 4.8l 5.3l 6.6l 8.1l p1285 p1286 or p2133 after replacing app sensor. *mj | 08/25/2004 | |
| 040604012 | 03/01/2006 | 040604012C | 10008669 | Vehicle with flexible fuel will not start, stalls and will not restart, loss of power, poor performance. *tt poor performance and/or fuel gauge reads inaccurate/incorrect. *tt | 08/13/2004 |
| 030601023 | 08/01/2003 | 10004370 | Higher than expected oil consumption <8500 gvw. various models including 2003-2004 chevrolet kodiak (c4500-c5500 series models)and gmc topkick (c4500-c5500 series models). *tt | 12/04/2003 | |
| 020601035 | 10/01/2002 | 10000170 | High oil consumption. *tt | 02/13/2003 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 08/01/2011 | 145000 | ||
| Broken exhaust manifold studs are causing environmental hazard and may lead to failed catalytic converter and other engine problems. this is a manufacturing defect that should be recalled, as it renders the vehicle either unusable or unable to pass environmental testing. | |||
| 11/19/2010 | 116000 | ||
| Tl-the contact owns a 2002 gmc yukon xl. while driving approximately 30 mph the vehicle stopped accelerating and a battery indication light began illuminating on the dashboard. the vehicle also stalled and upon restart the failure recurred. the vehicle was taken to an independent repair shop where he was informed the crankshaft position sensor needed to be replaced. the vehicle was in the process of being repaired. the failure and current mileages were 116,000. sm. | |||
| 12/16/2007 | 70000 | 6 | |
| Tl*the contact owns a 2002 gmc yukon xl. on six separate occasions, while driving at any speed, the vehicle completely shut off and would not restart immediately. the vehicle would shut off while accelerating from a traffic light or stop sign, and would not restart immediately. the vehicle failed to start on a few occasions while in park. nhtsa campaign id number 07v521000 (engine and engine cooling) is identical to the failure the contact is experiencing. the current mileage was 76,000 and failure mileage was 70,000. updated 11/12/08. *lj updated 11/14/08. *jb | |||
| 12/14/2003 | 14523 | 50 | 08/17/2002 |
| Tl*the contact owns a 2002 gmc yukon xl. the contact stated that the vehicle would not start. in addition, the vehicle would stall intermittently while driving at various speeds. the engine would completely shut off. occasionally, the vehicle would immediately restart, but other times, it would take a while. there were no warning indicators prior to the failure. the vehicle stalled the most during deceleration. the vehicle was towed once and the dealer made several attempts to correct the failure, but has been unsuccessful. the current mileage was 54,409 and failure mileage was 14,523. updated 04/29/08. *lj the consumer stated the crankshaft position sensor was replaced. the consumer stated there have been no further problems. updated | |||
| 10/15/2006 | 1 | ||
| Car stalls while traveling down highway, occurs at least once on each trip. time of occurrence is between 3 and 30 miles. several times it has stalled and would not restart while in motion, those time took several minutes to five minutes to get it restarted. problem started six months ago and has proceeded getting worse. has been serviced by dealership 5 times since first time. they have replaced several items that have not corrected the problem. we have had several near rear end crashes and scary moments when on the inside lane of an interstate pulling a 16 ft trailer. *jb | |||
| 10/16/2006 | 135000 | 4 | 10/28/2003 |
| Dt*: the contact stated while traveling 75 mph, the vehicle stalled without warning. the vehicle restarted and the manufacturer was alerted. updated 11/9/2006 - the vehicle stalled three times in one day and another time about 16 months ago. the consumer was told by a service manager that the problem was with a computer ring in the key switch assembly. *nm | |||
| 02/27/2006 | 57800 | 1 | 04/01/2002 |
| Original problem: my 2002 yukon xl was running poorly when the weather turned cold - below 30 degrees. problem diagnosed as faulty intake gaskets due to improper design. second problem: it became hard to start, and a couple of days later, it would not start at all. problem diagnosed as faulty fuel pump. both problems are because they were designed for use with ethanol or unleaded gas. i only use unleaded (never have seen a station that sells ethanol). if your gm vehicle has a 5.3l v8 engine, and the vin has a z in the 8th position, be aware that this might happen to your vehicle. if not under warranty, it is very costly! the gaskets and the fuel pump alone cost over $630. labor over $500. *nm | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 11/01/2003 | 15481 | 11 | 03/29/2002 |
| Dt: the consumer believes that there are electrical problems with the gmc. the water pump was out, the radio has quit working 5 times, and has been replaced 4 times, the windows on the passenger quit, and the regulator was replaced 4 times. this has happened at 35,000 miles. *ak | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 10/01/2009 | 89000 | ||
| Engine shuts down while driving: i have a yukon xl 2002. over the past 6 months the engine would suddenly shut down while the car is being driven. it has occured at high speed and at low speed. i have taken it back to the dealer no less than 5 times and the problem persists. this represents a major danger as while on the highway, when the engine shuts down the car becomes difficult to maneouver and moving out of the highway traffic has been each time extremely dangerous to me and to other drivers. | |||
| 10/19/2007 | 71123 | 7 | 12/20/2004 |
| My gmc yukon 2500 with the 8.1l stalls while driving. this is unexplainable and unrepeatable. this has occurred probably 6 or 7 times and is a real danger as you loose power steering and brakes. i believe it is the cam positioning sensor. what is my recourse to have fixed by manufacturer. *tr | |||