Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC | ||||||||||||||||
04V045000 | GENERAL MOTORS CORP. | from 05/01/2003 to 07/31/2003 | V (Vehicle) | 68875 | 06/18/2004 | MFR | GENERAL MOTORS CORP. | 02/04/2004 | 02/06/2004 | 571 | 135 | |||||
Defect Summary | Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore. | |||||||||||||||
Consequence Summary | Consequently, the valve o-ring seal may fracture. steering efforts may be slightly increased while braking or parking. under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture. | |||||||||||||||
Corrective Summary | Dealers are to replace the hydro-boost relief valve. the recall began on june 18, 2004. owners should contact cadillac at 1-866-982-2339; chevrolet at 1-800-630-2438; gmc at 1-866-996-9463; or hummer at 1-866-486-6376. | |||||||||||||||
Notes | Gm recall no. 04004.customers can also contact the national highway traffic safety administration |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
SERVICE BRAKES, AIR - ANTILOCK - ABS WARNING LIGHT | |||||
040525002 | 06/01/2007 | 040525002D | 10022470 | Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb | 08/15/2007 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SERVICE BRAKES | |||
11/03/2012 | 139335 | 1 | |
I started my truck. i applied the brakes and shifted into drive. i began to roll forward, then applied my brakes prior to exiting my driveway. the brake pedal went to the floor, the brake service light came on and the truck continued forward. i had to pump the brakes to come to a stop. i pulled the truck over and observed brake fluid all over the street. i crawled under the truck and saw that the brake line was rusted and that it burst somewhere in the middle of the truck on the driver's side. *tr | |||
11/03/2012 | 139335 | ||
I started my truck. i applied the brakes and shifted into drive. i began to roll foward, then applied my brakes prior to exiting my driveway. the brake pedal went to the floor, the brake service light came on and the truck continued foward. i had to pump the brakes to come to a stop. i pulled the truck over and observed brake fluid all over the street. i crawed under the truck and saw that the brake line was rusted and that it burst somewhere in the middle of the truck on the driver's side. | |||
SERVICE BRAKES, HYDRAULIC | |||
04/12/2012 | 54000 | ||
Brake lines under drivers seat are completely rusted through. vehicle is garage kept and seems to be experiencing excessive rust on brake lines. while driving vehicle brake pedal went to the floor almost causing me to have an accident. my family and i own and have owned numerous gm products and we're very disappointed with this safety hazard not being addressed by gm. maybe it's time to shop elsewhere... | |||
08/29/2011 | 55000 | ||
Tl-the contact owns a 2003 gmc yukon xl. the contact stated that while exiting a parking space with the brakes slightly depressed, the brake pedal traveled to the floorboard abnormally. the brake warning light was also illuminated. the vehicle was then driven to the dealer and as he parked, all of the braking fluid leaked. the dealer inspected the brake line and noticed corrosion. the dealer replaced the brake line at the owners expense. the manufacturer was notified of the failure and offered no assistance. the failure mileage was 55,000. kmj | |||
08/29/2011 | 55000 | ||
Tl-the contact owns a 2003 gmc yukon xl. as he pulled out of a parking space and depress the brake it went all the way to the floor, the warning light illuminated that there was a problem with the brake. the vehicle was then driven to the dealer and as he parked all the brake fluids leaked out. the dealer inspected the brake line and noticed the corrosion. the dealer replaces the brake line at the owners expense of $1500. the manufacturer was notified and offered no assistance. the failure mileage was 55,000. mw | |||
SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
03/13/2005 | 22000 | 1 | 08/13/2003 |
It was raining, i exited i95 on to rt 321 in south carolina, decelerating speed about 40 mph on exit ramp to the right, when car in front abruptly applied brakes, i did same, and vehicle went in to skid. kept foot on brakes, no alb engagement. vehicle slide off road, and tires hit grave and vehicle spun 180 degrees comin to rest on precipice of cliff. we were nearly killed. the alb did not engage. the dealer said he tested... and siad they were fine?? how did he test on dry pavement that day? i have gotten nothing but lip service from the dealer and gm customer service. there is a serious design flaw in the alb of this vehicle, or an intermittent flaw.. who knows how many people have died not living to tell the story about this design flaw. gm is denying any problem and is of no help. this in my opinion is a major issue, possibly with all these alb systems. i need some help on getting my car recalled and fixed. i read your salt state recall, but it it much larger than that. it is a flaw with all these vehicles. the vehicle i have is a 2003 yukon xl | |||
11/23/2004 | 5000 | 3 | 04/07/2004 |
Poor braking. 2)poor steering/ride control. 3)vehicle shifts-jumps intermittently/momentary loss of control twice. 4)vehicle spun out of control on ramp to rt 25 bourne ma, outcome details : *ak | |||
05/22/2004 | 7600 | 1 | 03/17/2003 |
Very poor brakes on this 2003 gmc yukon xl. brakes feel very spongy and soft, takes much effort to stop vehicle. vehicle currently has 7989 miles on the odometer and this condition was not present when it was first purchased. extremely unhappy with the stopping ability of this vehicle. |