Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
SUSPENSION | |||||
030310001 | 01/01/2008 | 030310001D | 10000959 | Tire slowly goes flat and/or excessive wheel vibration caused by bead splits (replace wheels with new heavy duty rim version) *tt *ar updated 4/11/08. *nj | 04/09/2003 |
SUSPENSION - FRONT | |||||
01425 | 11/18/2003 | 10004239 | Snap and popping noise in the front suspension area. *tt | 11/24/2003 | |
SUSPENSION - FRONT - SPRINGS - LEAF SPRING ASSEMBLY - U-BOLT, LEAF SPRING TO AXLE | |||||
3340 | 09/23/2006 | 3340C | 10020874 | Left front axle shaft difficult to remove. axle differential leak seal shaft. *kb | 01/25/2007 |
SUSPENSION - REAR | |||||
PIP4054A | 02/01/2008 | PIP4054B | 10024345 | Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe | 04/07/2008 |
3525 | 3525B | 10016714 | Automatic level control inoperative due to water ingestion. *tt | 09/28/2005 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SUSPENSION | |||
11/23/2004 | 5000 | 3 | 04/07/2004 |
Poor braking. 2)poor steering/ride control. 3)vehicle shifts-jumps intermittently/momentary loss of control twice. 4)vehicle spun out of control on ramp to rt 25 bourne ma, outcome details : *ak | |||
SUSPENSION - FRONT | |||
12/15/2003 | 4000 | 4 | 02/17/2003 |
2003 gmc yukon xl has been experiencing multiple problems with front suspension and steering column since it was new. at approx. 4,000 miles, took to dealer for thumping/popping sound that could be felt in steering column when turning, accelerating, stopping or over a speed bump. dealer packed intermediate steering shaft with grease. did not work. took back to dealer. dealer replaced intermediate shaft. nothing more felt in steering column. at approx. 12,500 miles took yukon back to dealer to remedy popping noise and unusual wear/feathering on inside tread of f. tires. dealer could not duplicate noise. said alignment was off and not covered by warranty. had to pay for alignment/rotation. wife took vehicle back when tech. was available to ride along. wife was able to get yukon to duplicate noise with tech. in vehicle. tsb said to remove bolts from cross member, bore bolt holes, lubricate, replace and torque. didn't get off of the lot before noise returned. now at 25,000 miles, after more unusual tire wear and the unresolved popping noise, took yukon back at dealership. service manager ordered washers as per new tsb for permanent fix of popping noise and is experimenting with alignment tolerances. just drove 10 feet out of service area parking lot and popping noise is exactly the same. have to take it back in on monday 08/08/05 so the service manager can ride along to observe problem. talked to a front end specialist at work and he indicated that we are experiencing same problems with our 2000 & up g.m. fleet vehicles.(100+) said gm rep came to inspect, noted the problem and left. front-end specialist said that there is a defect in gm torsion bar suspension system that is causing most of these problems but gm reps will not acknowledge or remedy. *jb | |||
SUSPENSION - FRONT - SPRINGS - TORSION BAR | |||
12/15/2003 | 4000 | 4 | 02/17/2003 |
2003 gmc yukon xl has been experiencing multiple problems with front suspension and steering column since it was new. at approx. 4,000 miles, took to dealer for thumping/popping sound that could be felt in steering column when turning, accelerating, stopping or over a speed bump. dealer packed intermediate steering shaft with grease. did not work. took back to dealer. dealer replaced intermediate shaft. nothing more felt in steering column. at approx. 12,500 miles took yukon back to dealer to remedy popping noise and unusual wear/feathering on inside tread of f. tires. dealer could not duplicate noise. said alignment was off and not covered by warranty. had to pay for alignment/rotation. wife took vehicle back when tech. was available to ride along. wife was able to get yukon to duplicate noise with tech. in vehicle. tsb said to remove bolts from cross member, bore bolt holes, lubricate, replace and torque. didn't get off of the lot before noise returned. now at 25,000 miles, after more unusual tire wear and the unresolved popping noise, took yukon back at dealership. service manager ordered washers as per new tsb for permanent fix of popping noise and is experimenting with alignment tolerances. just drove 10 feet out of service area parking lot and popping noise is exactly the same. have to take it back in on monday 08/08/05 so the service manager can ride along to observe problem. talked to a front end specialist at work and he indicated that we are experiencing same problems with our 2000 & up g.m. fleet vehicles.(100+) said gm rep came to inspect, noted the problem and left. front-end specialist said that there is a defect in gm torsion bar suspension system that is causing most of these problems but gm reps will not acknowledge or remedy. *jb | |||
SUSPENSION - FRONT - WHEEL BEARING | |||
12/04/2007 | 1 | ||
I have a gmc yukon and the wheel bearings in both sides have went out. i heard that the h2 hummer has a recall on its wheel bearing. how come the yukon doesn't? i heard of other yukons having the same problem. is this a chevy problem? my wheel almost came off of my vehicle going down the highway. the mechanic said the only thing that was keeping it on was the brake caliper. i sure hope nobody gets hurt over saving a couple of dollars, please there needs to be a warning and possibly a recall for this problem. *tr |