Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 205 | 02/16/2005 | 10015294 | Timesert 14mm drain plug thread repair kit. *tt | 07/13/2005 | |
| 07012004 | 07/01/2004 | 10014017 | Poor a/c cooling during hard acceleration. *eh | 04/27/2005 | |
| 9971 | 06/04/2003 | 10002091 | Coolant in the engine oil pan. *tt | 08/13/2003 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| 11012003 | 11/01/2003 | 10009278 | Heater blower motor gets hot or blows a fuse. honda. servicenews. *tt | 09/21/2004 | |
| 00025 | 02/22/2000 | 610325 | Subject regarding coolant leaks from the reservoir cap outlet on vehicles from various vin ranges. *tt | 04/25/2000 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 05027 | 06/10/2005 | 10017639 | Malfunction indicator lamp on with diagnostic trouble code p0420 or engine ping under load. *tt | 11/14/2005 | |
| 03076 | 10/14/2003 | 10004797 | Malfunction indicator lamp comes on with diagnostic trouble code p0131 (primary heated oxygen sensor circuit low voltage) or poor engine performance. *tt | 01/08/2004 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| 010402 | 04/01/2002 | 636738 | Subject regarding customer complaints that the engine hesitates briefly when accelerating. *tt | 11/13/2002 | |
| 302 | 03/16/2002 | 631027 | Customers may complain of a brief hesitation when accelerating at high engine speeds. *tt | 05/01/2002 | |
| 01040 | 08/14/2001 | 01040 | 623200 | Subject on regarding civic rear main oil seal leaks. *et | 10/26/2001 |
| 01040 | 06/12/2001 | 623373 | Subject regarding rear main seal leak. *et | 10/26/2001 | |
| 010201 | 02/01/2001 | 619944 | Brief information on long crank time at cold startup. *tt | 07/06/2001 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
| 060103 | 06/01/2003 | 10002701 | Vehicle's emission type. *tt | 09/11/2003 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||||
| 901 | 09/16/2001 | 626815 | Subject on diagnostic trouble code of catalytic converter efficiency below threshold.*jb | 12/18/2001 | |
| 011001 | 10/01/2001 | 626823 | Information regarding catalytic converter efficiency below threshold. *yd | 12/18/2001 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||||
| 010400 | 04/01/2000 | 618988 | Information on vehicles exhibiting exhaust rattle. *tt | 05/10/2001 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 07/18/2008 | 1 | ||
| My engine needed more oil and the oil light did not come on in my car and the engine ended up getting burned out. the check engine light also did not come on. *tr | |||
| 07/03/2008 | 98000 | 1 | |
| While drving the vehicle, the engine just quits. it happened 3 times today. it is very dangerous. *tr | |||
| 06/15/2003 | 53000 | ||
| I got into a car one afternoon and heard a rattling sound, i turned off the a/c to make sure it wasnt the engine. as soon as i turned it off, the sound stopped. i turned it back on and drove down the road and heard something fly out from underneath my car and suddenly the air was blowing hot out of the a/c. i took it to a shop to get it looked at and was told that it was the clutch from the a/c that had broken off and it now needs to be replaced. in replacing the clutch, i was also told that the compressor and drier also needed to be replaced which would cost me a total of $950.00. before i had taken it in, i was told that if it was still blowing air than it wasn't the compressor, so why would it need to be replaced? of course, honda wont stand behind it and pay for the a/c unit being fixed. i bought it brand new in 2000 and havent even had it 3 years yet. | |||
| 03/20/2004 | 27280 | 15 | 07/05/2000 |
| Manual transmission jumps while driving also does not want to go into second gear. makes wierd grinding sound while driving slow. car shutters and shakes violently while in 5th gear in excess of 70 mph. car shuts off by its self( was told vin not in sequence for ignition recall). right front springs sticks and some times makes a ( boing ) sound. car keeps pulling to right even after alignment. when heater or defroster are on they make a loud chirping sound. on cold or rainy days steam will pour out of engine compartment smelling like radiator fluid. was in 2 minor accidents one front end colision one rear end colission both about 30 mph and air bags did not deploy. engine is becoming rusty and coroded. drivers power window is slow to go up and front seat belts will not retract. engine light comes on and car loses power and gas mielage. goes offf when gas tank is filled. car has been to dealer numerous times for honda scheduled service and also while it was under warranty. all the problems adressed above were told to dealer who said they could not find a problem..but they sure did when my warranty expired. now they will not fix anyhting unless i pay for it. *jb | |||
| 12/31/2002 | 63000 | ||
| Vehicle's main motor seal is leaking oil, which can cause motor to blowout. please provide more details. ph...*ak | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 07/06/2008 | 87500 | 1 | |
| I was at a stop light and had the a/c running it was working fine and blowing cold. while accelerating the light i heard a loud metal noise and thump and the air conditioner started blowing hot. i took the car to a dealer and they informed me that part of the air conditioner fell off, the fan clutch????, i am not a mechanic but i have never had problems with the air conditioner an i know parts of a car should not fall off while driving down the road. the air conditioner has never been worked on and the car is serviced regular, the car only has 87,000 miles. i am being told it will be about 1,400.00 dollars to have this repaired. *tr | |||
| 06/11/2005 | 35000 | 3 | 02/02/2003 |
| Failure of 2 air conditioning systems in a 2000 honda civic, presently on a new 3rd system. vehicle mileage is 35,000. honda states that it is not responsible for the current failure. | |||
| 09/12/2003 | 40000 | 1 | 10/30/2001 |
| Black death syndrome--where the compressor starts seizing up and shredding the a/c cluth into metal shaving into the a/c system. a very known issue to honda technicians and can even get it fixed out of warranty out of goodwill. the a/c will just give out one day there and they will actually have to open up the compressor to see if this is the cause. any year and model! *ph | |||
| 07/26/2000 | 1 | ||
| While driving engine overheated and consumer lost control of vehicle without a warning. *ak | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||
| 02/06/2000 | 12/01/1999 | ||
| Extremely disappointed. how can a 2 months old radiator be so fragile? honda denied it was a defect by manufacturer which i have to end up paying $511.65 for the replacement of radiator. i feel like being cheated and robbed. *ak | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 05/17/2008 | 60750 | 1 | |
| I have never had an issue with my 2000 honda civic si because i had the recommended maintenance performed , oil changes every 3000-4000 miles and on may 17th, 2000 honda civic si with only 60,000 miles-blown head gasket...the car is at honda west pending-a goodwill concession from honda. *tr | |||
| 09/04/2005 | 50000 | 4 | 09/04/2002 |
| Tl*the contact owns a 2000 honda civic. the contact stated that the vehicle vibrates while driving 30 mph. the tires grip the pavement and the brake pedal appears to be elevated, creating difficulty when they are depressed. the rpms run high when idling and the vehicle begins decelerate while in motion. the contact pulled off the road and shut off the vehicle. the vehicle restarted, but the failure recurred soon after. the contact believes the failure may be caused by the fuel pump system or the accelerator may be stuck. the dealer was unable to determine the cause of failure. the vin and engine size were unknown. the current mileage is 80,000 and failure mileage was 50,000. | |||
| 09/09/2003 | 3 | ||
| Request for reimbursement for defective part replacement on 2000 honda civic.*mr (nar) *cb | |||
| 11/26/2003 | 1 | 01/27/2000 | |
| Have head gasket leak, my mechanic says that this has to be a manufacturing defect because he can see nothing else that would cause this. *la | |||
| 07/21/2003 | 8 | ||
| I dropped my car of 7/21/03 for engine repair and body work. the body shop said it would take 10 days. 7/28/03 my car was broken into while in their shop and i was not alarmed until 21/2 weeks after the break in incident by the detective on the case. in between the time before i knew about the break in, i've spoken to the owner inquiring about the time frame my car would be finished, the owner never mentioned of the incident. when i did find out of the incident and confronted store owner he stated that he thought i knew. i expressed my anger and mentioned the fact that my car was broken into and if he had advised me of the situation, i would have taking that in consideration of the time frame of prolonged service and understood more of the delay. the owner said the fact that my car being broken into had no reason of the delay. i had numerous unpleasant conversations with him, from where he's called me a !@#$%, that i don't give him enough business to harass him about information on my car as much as i do. i've already gave him $1,500.00. when i finally had the time and transportation to go see my car, there were some parts of my car that was taking that needed to be repaired, for example my front bumper was totally ripped and needed to be replaced- that was stolen, my passenger rear view mirror was taking, that also needed to be replaced. my strut bar was taking but the person or persons who took it had the time to put the screws back on, whoever broke in my car also took my back spoiler, gauge cluster, speedometer, headrest, both of my door panels and door speakers, my console, and some other stuff. my car is three times worse then when i dropped it off. the owner stated that he does not have to replace these items if he doesn't want to. i still pay car notes my car, it i've mentioned this to the owner how important it is for me to have work done and right asap many times but he seems to not understand or care. my car has not been worked on. *tr | |||
| 07/08/2000 | 2 | 12/01/1999 | |
| The vehicles malfunction indicator light came on indicating a problem after running 2,255 miles within seven months. the engine ran very roughly and hesitated on acceleration, making it very difficult to control. the service depatment stated they tried to diagnosis and fix the problem but did not know what was wrong. later they said the valves were to tight and consequently adjust them. after the vehicle was returned, the next day it would not start. eventually the vehicle started very roughly and shook violently; the malfunction indicator lamp came back on. the service department found the fuel injectors leaking and replaced all four-fuel injectors. after these malfunctions and repairs, i noticed a change in the performance of the vehicles acceleration power, and the idling was noisier. the gas mileage seemed less and the vehicle has stalled on a few occasions. this complaint to the nhtsa concerns a defective and nonconforming vehicle that was likely to caused severe bodily injury or death if driven. the vehicle was sold with defects that not only jeopardized the safety of the consumer but the public was also at risk.. that risk of fuel leaking from injectors and engine malfunction (valves) could have caused a fire, pollution, and collision hazard. such defects and nonconformities breach the implied and expressed warrantees and violate various federal laws intended to protect the consumer and the public. the expectation of a new vehicle to perform in a safe and reliable manner should not be compromised by defective manufacturing, and inadequate service. i am requesting an investigation of this problem. it would be a life saving service to the public who is unsuspecting that a new, well maintained vehicle would run for less than 2,300 miles and have dangerous defects appear. the pattern of neglect that begun with the manufacture, persisted with the sale and the service of the vehicle by the dealer. this lack of due care could get somebody killed. *ak | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 05/22/2002 | 36486 | 12 | 02/01/2002 |
| While driving, car will jerk violently, feels like several cylinders are not firing, then start back up again. after a few seconds of this kind of sputtering, the engine will throttle down and then die. while it is having the problem there is a drastic loss of acceleration. if the gas pedal is pushed nothing happens and it bogs down more. after the car has died it cannot be restarted for several minutes. this car has been to the dealership 11 times since i bought it, owning it a total of 16 months. twice it had to be towed to the dealer, and once they were able to start it immediately after it was delivered. it has been in service for a total of 29 days. the first time i took it in, i had driven 4,000 miles and only owned the car less than 3 months. problem is sporadic, many times when i have taken it in for service they have not found anything wrong with it, then it will die on me on the way home. the catalytic converter has been replaced 3 times, spark plugs twice, and oxygen sensor once, and it still has the same problem i took it in for the first time. *nlm | |||
| 06/10/2002 | 5 | 07/01/2000 | |
| 5 speed - engine stalls while in fifth gear. have to pull car over and restart. car taken repeatedly to repair and no problems could be found. finally looked up recalls on insurance company's web site and saw recall for engine switch. took car to dealer to repair and egnition switch replaced. stall happened again. called honda customer service and was informed there were no recalls on cars in my vin sequence. said i would have to take car to dealer again for repair. no one can seem to tell me why the car keeps stalling. it only happens when i'm driving in 5th gear at 50+ speeds. situation is scary because of the speeding traffic around me. not sure what else i can do. dt | |||
| 05/17/2002 | 1 | ||
| At 50mph and with no warning transmission will automatically switch to lower gear. cause unknown. dealer notified.*ak the transmission would not disengage out of gear when the consumer stops pushing the gas pedal. the engine makes a knocking noise while warming. *yh | |||
| 2 | |||
| Intermittently when braking, transmission will shift down on a slight to moderate incline. dealer has been notified. *ak half of the time the transmission shifts without warning at up to 55 mph under light to moderate braking. this could cause a serious accident. consumer also states that there is a metallic clacking or knocking noise when the engine is warmed. *jg | |||
| 1 | |||
| Consumer states intermittently while driving on a slight downhhill between 35 to 55 mph and applying very light to moderate braking, the transmission will shift gears from overdrive to third gear. when this happens the tachometer and speedometer will jump up one inch even though vehicle is slowing down. there is a metallic clacking or knocking noise when the engine is warmed up in gear at idle with the brake on. *tt | |||
| 02/19/2001 | 1 | 08/19/2000 | |
| Consumer states that after turning vehicle off, he hears a ticking noise, dealer informed consumer that the noise is not a problem and should happen more on colder days. *slc | |||
| 01/04/2001 | 2 | 02/02/2000 | |
| About a minute after starting the vehicle it stalled, towing company called, vehicle started right away, after gas pedal was held to floor about 30 seconds, mechanic stated that hondas tend to flood themselves in cold weather. *cj | |||
| 12/09/2000 | 4 | 09/01/2000 | |
| The car could not start four times since december 2000. the quality of the car is really bad, and it should be recalled. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
| 11/02/2009 | 66618 | 1 | |
| I had a check engine light indicating a bad catalytic converter on my 2000 honda civic. the cat was replaced under warranty by the dealer in march '08 only to have the exact same scenario repeated in july '08. now i'm facing the same situation again. so in summary, the catalytic converter has now been replaced 3 times in a 20 month period. from all my research this is very rare. my suspicions are that the electronic control module (ecm) is defective and truly the root of the problem. however, i believe that the dealer has purposely avoided revealing the ecm as possible cause as it would be a costly repair for them as the ecm falls under epa emissions warranty.. *tr | |||
| 01/07/2009 | 125840 | 1 | |
| 2000 honda civic dx-vp o2 sensor failed at 125,000 miles due to a cracked exhaust manifold at the sensor - no information as to how much earlier the crack might have occurred before the sensor was damaged. the sensor failure generates an error code and causes the check engine light to come on, and creates rough idling and stalling in traffic, creating serious safety issues. the vehicle will not pass the state emissions inspection in that condition. the only way to correct the issue is to replace the cracked exhaust manifold and catalytic converter assembly along with the o2 sensor. honda was contacted and denies knowledge of any significant issues with cracked manifolds and sensor failures on 2000 honda civics and refuses to provide any assistance with repairs. it is well documented that the cracked manifold is a significant problem on civics on all model years from 1996 to 2003. honda issued extended warranties on many of these model years that fails to provide any assistance to most owners, since the defect commonly appears outside of the extended warranty period. honda and it's dealers are also being allowed to generate additional revenues from the sale of replacement manifolds and installation to correct the very defect that it created. this defect has not yet been corrected on my vehicle due to the expense involved ($1000) and the vehicle inspection not expiring until august. this is clearly a well documented defect for which honda should be held accountable. honda should be required to make the repairs or provide some type of assistance or compensation to the owners for the repairs, which are necessary in order to pass state vehicle inspection and keep the vehicle operating legally, and to prevent serious safety issues from the stalls in traffic. *tr | |||
| 12/15/2007 | 1 | ||
| Took my car in for regular service, immediately after picking it up, car kept rattling & sputtering. came back in and they stated suddenly the manifold was cracked & the bolt for the heat shield was broken off. looked online & saw that there are many many issues with cracked manifolds with civics, so much that a handful of model years (but not mine) was recalled. mine is just considered out of warranty, & is now a safety (fumes can cause sickness) & environmental issue. given how i babied this car, the only reason this would have cracked is either a major design flaw/weakness (or the mechanics really messed up my car). since it's such a major reported (ignored) issue, it's clearly a design flaw. | |||
| 01/19/2009 | 131580 | 1 | |
| Car has been running fine since i had purchased it as a secondhand vehicle. at 130,xxx miles, the check engine light came on, upon using a obd2 scanner, it was discovered that the primary oxygen sensor heater has malfunctioned. when the heat shield to the exhaust manifold was removed, a huge crack about 2 inches was found in the center of the manifold above the oxygen sensor. *tr | |||
| 06/11/2008 | 135716 | 1 | |
| Exhaust manifold is cracked for 2nd time; also have 2 other honda civics (99 and 97) with same problem - obvious manufacturers defect. honda will not cover repairs. *tr | |||
| 12146 | 1 | ||
| After starting the vehicle consumer smelled gas fumes. dealership was notified, but did not resolve the problem. *ak | |||
| 03/14/2001 | 5 | ||
| When getting in or out of vehicle or when rocking vehicle could hear a squeaky noise. dealer told consumer that problem was with exhaust donut which had been replaced five times. *ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
| 03/10/2007 | 12/16/2004 | ||
| Honda civic exhaust manifold; after owning a 2000 honda civic for two years, i have had to replace the entire exhaust, oxygen sensors and now the exhaust manifold. i became upset after this series of burdens on me, so, i decided to conduct research on-line. thus, i found numerous reports and similar complaints from fellow honda civic owners. it appears civcis created between 1992-2000 have had deffective exhaust manifolds causing many consumers to have to fight to get a resolution through honda, the manufacturer. honda is reviewing each vehicle on an individual basis, rather than admitting that their product, widespread, is deffective. | |||
| 09/01/2006 | 100000 | 1 | 02/01/2004 |
| Smog check. *nm | |||
| 07/01/2003 | 2 | 10/01/1999 | |
| The vehicle's rear oxygen sensor failed. *nm the front sensor was replaced as well. the consumer requested reimbursement. *sc *jb | |||
| 11/05/2003 | 44371 | 1 | 05/15/2000 |
| The check engine light illuminated. the vehicle was taken to the repair shop where it was determined that the oxygen sensor was inoperative and had to be replaced. please provide any additional information. *nm *jb | |||
| 06/25/2003 | 15600 | 5 | 09/23/2000 |
| Honda civic 2000 model. car only had 15600 miles when the problem started.une 25, 2003 - malfunction indicator light was on. honda adjusted the valves.june 28, 2003 - malfunction indicator light was on. honda replaced oxygen sensor.*ak july 3, 2003 - malfunction indicator light was on. honda changed pressure regulator. july 21, 2003 - car stalled and engine died. honda replaced fuel filter, fuel pump set, ignition coil, ignition control module. aug 25, 2003 - car stalled, engine running but no acceleration (does not move), car makes clacking noise. honda said they will change the fuel tank and fuel pump. car is still at honda. my car has been to the dealers for the 5th time in less than 2 months. the down time is more than normal. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
| 08/29/2005 | 82000 | 1 | 10/02/1999 |
| On monday morning, august 29th, i started my 2000 honda civic cx hatchback and the check engine light came on. this is the first time it had ever happened; the car has 82,000 miles on it. i called cush honda escondido and brought it in for service the same day. they later called me to tell me that their computer showed that the oxygen sensor needed to be replaced and the manifold on the catalytic converter was cracked and the entire unit needed to be replaced. the total cost was $1026. i consider needing a catalytic converter replaced at 82,000 miles to be unacceptable. i am aware of other honda owners who have had the same thing happen. i like having this item wear out to having a transmission or some other major component wear out. it has also been brought to my attention that the catalytic converter has an 80,000 warranty. how convenient!*jb | |||
| 09/09/2003 | 3 | ||
| Request for reimbursement for defective part replacement on 2000 honda civic.*mr (nar) *cb | |||
| 02/08/2000 | |||
| Every time engine is turned off very loud clanging and banging noises come from under the vehicle on the front driver's side. vehicle was taken to the dealership. dealer stated that the noises came from the catalytic converter cooling down and contracting, which was a characteristic of the vehicle. please provide any further information. *ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||
| 02/10/2004 | 27000 | 1 | 01/10/2000 |
| While starting the vehicle, the check engine light came on and remained on while driving. the vehicle was taken to a repair shop, and the mechanic determined that the oxygen sensor needed to be replaced. *ak *jb | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
| 10/21/2005 | 70000 | 1 | |
| Tl*the contact owns a 2000 honda civic. the contact smelled fumes whenever the vehicle was driven. speed was not a factor. approximately three months later, the oxygen sensor failed and the contact discovered a crack in the exhaust manifold. the current mileage was 114,000 and failure mileage was 70,000. updated 09/10/08 *bf updated 09/17/08. *jb | |||
| 11/08/2007 | 1 | 10/01/2000 | |
| Exhaust manifold cracked leaking. *tr | |||
| 03/01/2006 | 74000 | 2 | 11/25/1999 |
| Exhaust manifold cracked for a 2nd time! had replaced at 74,000 miles, now at 129,000. dealer said the second was only covered under a 12 month, 12,000 mile warranty. *jb | |||
| 01/16/2006 | 62000 | 1 | 07/10/2005 |
| Exhaust manifold crack leading to carbon monoxide being sucked through the ventilation system and inhaled by the occupants. this lead to headache and vomiting. *jb | |||
| 12/01/2004 | 129850 | 1 | |
| Intake manifold cracked and fumes came into the vehicle. contacted honda. it stated there were no problems with the vehicle. *ak....alsi replaced spark plugs, and replaced a cracked exhaust manifold. *ak | |||
| 10/01/2004 | 76000 | 1 | 11/09/2002 |
| In february 2004, i noticed a smell of exhaust fumes in the interior of the car. brought it to a mechanic 3 times. he said he didn't smell it, and could find nothing wrong with the car. i recently brought the car in to a new mechanic for servicing, and he informed me that the exhaust manifold is cracked. i've been suffering some unexplained health problems, such as headaches, light headiness, and fatigue, and now wonder if the symptoms are related to long term exposure to the exhaust fumes. the mechanic suggested i contact the honda dealer to request that they fix the problem at no cost. however, the dealer informed me that the part(s) is only covered up to 80,000 mi. my vehicle currently has 82,000 mi. on it. as it is an expensive repair, it has not yet been fixed.*ak | |||
| 10/01/2001 | 1 | 10/01/1999 | |
| Exhaust manifold cracks, causing hot exhaust gases and possible unburned fuel to leak. *ak | |||