Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||||
| 010902 | 09/01/2002 | 638105 | Customer complants of thumping from fuel tank from sloshing fuel.. *tt | 12/10/2002 | |
| FUEL SYSTEM, OTHER | |||||
| 02012005 | 02/01/2005 | 10015277 | Checking the short-term fuel trim when a diagnostic trouble code (dtc) p0171 is set. *tt | 07/13/2005 | |
| 03001 | 01/28/2003 | 10000993 | Malfunction indicator lamp on with diagnostic trouble code p1457 - evap bypass solenoid valve failure. *tt | 04/10/2003 | |
| FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||||
| 100102 | 10/01/2002 | 10005906 | Service manual fix. fuel gauge sending unit test. honda servicenews. *tt | 03/18/2004 | |
| 020103 | 02/01/2003 | 10001815 | Fuel gauge sending unit test. *tt *jb | 07/18/2003 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, GASOLINE | |||
| 09/13/2011 | 116040 | ||
| I initially noticed a gasoline smell in the garage. then, after filling the gas tank one day, and parking in the garage overnight, i discovered a puddle of gasoline on the garage floor! the gas is leaking from the fuel tank, at the seam or joint where the tank's integral cylindrical tube projection transitions to the flat surface of the tank. the rubber filler hose clamps onto this tank tube, but the leak is in the tank tube joint seam only. light finger pressure on the side of the tube results in a more obvious leakage rate. i contacted honda owner link, and was told that a dealer had to confirm my observation before honda could help with this safety defect. i took the car in, and the service tech reported fuel leak at the filler neck. tank has no road damage. tank will need to be replaced. fuel is leaking at this time. i waited another 2 hours for the service manager to contact and receive a response from the honda dpsr. she declined any goodwill assistance due to miles and year of vehicle. the quote to replace this safety defect is $1200, and no one at honda accepts any responsibility. i have tried to elevate this dangerous safety defect within honda, and have been told it is not a safety defect because there is no nhtsa action in place. i was told that the only further elevation avenue beyond the honda dpsr was to file this nhtsa complaint, and wait for enough similar fuel tank failures to be registered by nhtsa. meanwhile, gasoline is leaking from my defective pilot fuel tank, and my only choices are to run it out of fuel and park it, or to pay $1200 myself to correct the honda design or manufacturing defect in this fuel tank. i do not understand how honda can deny responsibility for this extremely dangerous safety defect, when their technician has confirmed that it is integral to the fuel tank, and that the tank has not been damaged in driving. | |||
| 10/12/2009 | 135000 | 1 | |
| I'm not of that scared of sticking gas pedals kind on person. just want to file this incident to probably help others to avoid problems in the future. after car being parked for three weeks at airport when first started it i had and issue with the stuck gas pedal. fortunately i was in the parking gear when i first pressed the pedal, otherwise could be an accident on the parking lot if i was in the drive gear. i just pulled the pedal back with my toe and pressed and pulled it couple times more before it started working ok. before that i felt it little mushy after long parking periods especially in the relatively cold days in georgia autumn/winter but it was coming away after driving the car daily. when i got back home i rectified the problem by pouring some oil in the throttle cable jacket and lubricated the pedal axis as well. had no problems since than so far. *tr | |||
| 03/12/2007 | 56000 | 1 | |
| My honda pilot has an unfixable life threatening defect. it is sticking gas pedal. usually it sticks after the night in the garage and i need to idle until the engine is hot and then the pedal unsticks. but sometimes it happens while driving. this defect makes the car absolutely unpredictable while driving and could easily lead to the fatal accident. actually, one time out of four when it happened while driving i was very close to such accident. first time i encountered this defect when my new car was still on warranty nov 4, 2004. since than the authorized honda dealer has tried to fix this defect more than four times. they replaced the throttle body but all the attempts to fix it were unsuccessful. the problem is still there. i?m very concerned and scared to drive this car at this point as this defect not only directly jeopardizes my life but also the life of my 6-year old daughter who is almost always with me in the car. the american honda stated that it was not anymore responsible for this defect because it?s unfixable and anything else concerning this defect from now on is my responsibility. *tr | |||
| 09/01/2004 | 1 | 12/01/2003 | |
| Engine light keeps on turning on. this is makes it difficult to see how much gas is in the vehicle . also, vehicle is using twice as much gas as before.*ak | |||
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - FUEL RAIL | |||
| 02/17/2004 | 3 | ||
| When starting the vehicle consumer smelled gas from the engine. consumer indicated that fuel rail was leaking. dealer replaced the fuel line and the plenum gasket three times, but problem recurred. *ak | |||
| FUEL SYSTEM, GASOLINE - STORAGE | |||
| 08/10/2005 | 40000 | 1 | 09/28/2002 |
| The gas tank had a leak. enough that fuel was dripping to the ground when the tank was over half full. the leak point was around a seam at the fuel intake where the tank was assembled. honda replaced the tank but because the car had 40,000 miles on it was out of warranty. honda applied a goodwill warranty and paid for the parts. we paid almost 300 dollars for labor. | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
| 03/08/2007 | 1 | 1 | 10/06/2006 |
| After coming to a complete stop, there is a loud thumping that comes from the rear of the vehicle. it scares the heck out of you and you think someone has hit you! took it to several mechanics and the honda dealer in brantford, ontario and although honda acknowledges the problem as a related to fuel tank design they are refusing to do anything about it. *jb | |||
| 05/15/2003 | 1 | 10/05/2002 | |
| I owned a 2003 honda pilot. it's a very good suv. except that last year, i made a complaint with grand honda dealership in elmhurst il. regarding an annoying noise coming from the fuel tank which i believe is very unusual. splashing noise is very strong when the fuel tank is half to almost full tank. according to the dealer it is normal and there was no recall which i strongly disagree. i believe there is not enough chambers to control the splashing noise and might cause further damage. please help!!! *jb | |||
| 06/06/2003 | 5280 | 1 | 05/17/2003 |
| Hearing the annoying and pretty loud back and forth sloughing or thumping sound from the bottom or rear of the driver seat (most likely from the gas tank which is where it is located) whenever coming to a stop or accelerate from a stop.*ak | |||
| 05/04/2003 | 1 | 04/30/2003 | |
| Every time i accelerate from a stop or come to a stop i hear a thumping noise from fuel sloshing around in the tank. the location of the fuel tank is right under the floor behind the driver's seat. it is very loud and annoying to hear. *jb | |||