Honda Vfr800 2002
Model Vfr800 made in 2002 by Honda got 9 consumer complains, 1 investigation there are 2 recalls as well as 3 service bulletins. Consumer complaints with reference, among others things, to electrical system, engine and engine cooling and exterior lighting. Technical service bulletines regarding digital instrument panel, equipment and service brakes, hydraulic. The car had one investigation (electrical system). There were some recalls concerningelectrical system, service brakes, hydraulic.
Model 2002
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - WIRING | ||||||||||||||||
07V359000 | HONDA (AMERICAN HONDA MOTOR CO.) | from 09/06/2001 to 05/13/2002 | V (Vehicle) | 6952 | 11/05/2007 | ODI | HONDA (AMERICAN HONDA MOTOR CO.) | 08/15/2007 | 08/16/2007 | |||||||
Defect Summary | On certain motorcycles, the front fairing sub-harness (section of the wiring harness) transfers the electrical grounding load of the headlights, front turn signals, instrument panel, and various relays to the main wiring harness via an 18-pin connector. under certain conditions, the ground wire terminals inside the connector can overheat, resulting in melting of the connector and a loss of power to various circuits. | |||||||||||||||
Consequence Summary | As a result, a loss of critical lighting or engine power could occur without warning, which could cause a crash. | |||||||||||||||
Corrective Summary | Dealers will install a re-designed sub-harness. if damage is found, the main wiring harness will also be replaced free of charge. an interim letter was mailed to owners on september 26, 2007. owners were re-notified on november 10, 2007, to take their motorcycles to dealers to have the parts installed. owners may contact honda at 1-866-784-1870. | |||||||||||||||
Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||
SERVICE BRAKES, HYDRAULIC | ||||||||||||||||
05V010000 | HONDA (AMERICAN HONDA MOTOR CO.) | from 01/29/2002 to 05/13/2002 | V (Vehicle) | 36046 | 01/31/2005 | MFR | HONDA (AMERICAN HONDA MOTOR CO.) | 01/24/2005 | 01/25/2005 | |||||||
Defect Summary | Certain motorcycles equipped with combined-brake systems have a proportioning control valve (pcv) that mechanically proportions brake force when the rear brake is applied. a seal in some pcvs is improperly shaped, and brake fluid leakage may occur. | |||||||||||||||
Consequence Summary | If the motorcycle continues to be used after a leak occurs, the rear brake would eventually become inoperative. a loss of rear brake force could increase the risk of a crash. | |||||||||||||||
Corrective Summary | Dealers will inspect the rear brake forleakage. if leakage is confirmed, the dealer will replace the pcv free of charge. the recall began on january 31, 2005. owners may contact honda at 866-784-1870. | |||||||||||||||
Notes | Honda recall no.p65.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
DIGITAL INSTRUMENT PANEL | |||||
SB-06-085 | 05/09/2008 | 10032953 | Honda: warranty extension-vehicle warranty mileage. class action lawsuit alleging that the odometers on certain 2002-2006 honda models were overstating mileage. federal court provided final approval of settlement on 12/29/07. no models | 06/16/2010 | |
EQUIPMENT - OTHER - LABELS | |||||
08-040 | 05/31/2008 | 10025523 | Load carrying capacity reduced label for all honda vehicles. *pe | 08/15/2008 | |
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DIFFERENTIAL PROPORTIONAL VALVE | |||||
10959 | 02/01/2005 | 10015344 | Linked braking system (lbs) proportional control valve (pcv) leakage safety recall. *tt | 07/14/2005 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ELECTRICAL SYSTEM | ||||||
PE05047 | HONDA (AMERICAN HONDA MOTOR CO.) | 09/02/2005 | 12/20/2005 | STALLING & SUDDEN HEADLIGHT OUTAGE | 07V359000 | |
Odi opened this investigation after receiving three complaints concerning alleged engine stalling and/or sudden headlight outages while underway.odi also found numerous postings on a web-based chat board related to the subject vehicle and these allegations.frequently, the posting referenced the blue connector joining the main harness and the headlight sub-harness.odi has inspected subject motorcycles and its peers and met with their owners, discussed this matter with subject motorcycle dealers and independent service personnel, and reviewed honda's response to our information request.based on the information gathered to date, the evidence suggests that most failures have developed slowly over time with the operator notingdifficulty starting the motorcycle,and a smell of melting insulation, (no fires are reported).in the majority of reports, the problem is noted while starting the motorcycle.many reports state the engine stalled when the starter button was initially released. for the headlight problem, many of the circuit overload reports were due to the installation of aftermarket electrical equipment.currently, no defect trend has been identified warranting further expenditure of agency resources at this time.the closing of this investigation does not constitute a finding by the agency that no safety related defect exists.odi will continue to monitor this issue closely and should circumstances change, odi will take appropriate action. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM | |||
01/10/2007 | 17000 | 4 | 03/02/2002 |
I own a 2002 honda vfr 800 motorcycle that has incurred electrical problems that 2 dealers were unable to repair. the electrical problems occurred while i was driving on the highway at highway speeds, and when trying to use turn signals. the headlights went out and the engine died...a very dangerous situation. now the motorcycle still did the same thing, just that the headlights were practically non functioning ,they came on sometimes when going over a bump but the engines still died whenever i use the turn signals. *ak any help you may provide would be greatly appreciated, the more research i do on the internet reveals that this particular bike has had an abnormal amount of electrical problems, many resulting in dangerous perhaps deadly consequences. | |||
08/15/2002 | 43000 | 4 | 01/15/2002 |
Dt: the consumer experienced 4 separate electrical failures, it has caused headlight and engine failure. the consumer contacted honda they have repaired the issue under warranty. the ground wire has burned 3 times at different points. the 1st time aug 2002. first time it only had 18,000 miles. *jb | |||
ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | |||
08/04/2006 | 9000 | 1 | 08/02/2003 |
Motorcycle engine died while running. i did troubleshoot to find an electrical 30 amp fuse wire insulation scorched and burned through. copper conductor had become very hot. *jb | |||
11/01/2005 | 56000 | 2 | 04/12/2002 |
30amp main fuse holder melting. engine stopped on freeway. *nm | |||
ELECTRICAL SYSTEM - WIRING | |||
09/04/2006 | 20054 | 1 | 09/28/2002 |
Had starting problems and went to check the battery. found that the fuse holder, a connector and the small wire between the two had discolored to a brown. there were signs of melting on the wire insulation. the part has not failed to date but gets very hot to the touch when the vehicle engine is running. *jb | |||
ENGINE AND ENGINE COOLING | |||
08/04/2006 | 9000 | 1 | 08/02/2003 |
Motorcycle engine died while running. i did troubleshoot to find an electrical 30 amp fuse wire insulation scorched and burned through. copper conductor had become very hot. *jb | |||
EXTERIOR LIGHTING - HEADLIGHTS | |||
01/10/2007 | 17000 | 4 | 03/02/2002 |
I own a 2002 honda vfr 800 motorcycle that has incurred electrical problems that 2 dealers were unable to repair. the electrical problems occurred while i was driving on the highway at highway speeds, and when trying to use turn signals. the headlights went out and the engine died...a very dangerous situation. now the motorcycle still did the same thing, just that the headlights were practically non functioning ,they came on sometimes when going over a bump but the engines still died whenever i use the turn signals. *ak any help you may provide would be greatly appreciated, the more research i do on the internet reveals that this particular bike has had an abnormal amount of electrical problems, many resulting in dangerous perhaps deadly consequences. | |||
EXTERIOR LIGHTING - TURN SIGNAL | |||
01/10/2007 | 17000 | 4 | 03/02/2002 |
I own a 2002 honda vfr 800 motorcycle that has incurred electrical problems that 2 dealers were unable to repair. the electrical problems occurred while i was driving on the highway at highway speeds, and when trying to use turn signals. the headlights went out and the engine died...a very dangerous situation. now the motorcycle still did the same thing, just that the headlights were practically non functioning ,they came on sometimes when going over a bump but the engines still died whenever i use the turn signals. *ak any help you may provide would be greatly appreciated, the more research i do on the internet reveals that this particular bike has had an abnormal amount of electrical problems, many resulting in dangerous perhaps deadly consequences. | |||
UNKNOWN OR OTHER | |||
06/13/2008 | |||
Tl*the contact owns a 2002 honda vfr800. the contact mailed in a warranty card notifying the honda manufacturer that he now owns the motorcycle. the warranty information was entered into honda's system incorrectly and now it states that the motorcycle is stolen. there is a nhtsa campaign id number 07v359000 (electrical system:wiring) on the vehicle, which the dealers are refusing to acknowledge due to their error. there had been no failure to date. |
Car dealers selling
State | City | Zip | Name | Phone |
---|---|---|---|---|
CA | THOUSAND OAKS | 91361 | THOUSAND OAKS HONDA | |
TX | HOUSTON | HONDA OF HOUSTON |