Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM | ||||||||||||||||
08V441000 | GENERAL MOTORS CORP. | from 06/30/2005 to 04/30/2006 | V (Vehicle) | 857735 | 09/12/2008 | ODI | GENERAL MOTORS CORP. | 08/28/2008 | 08/28/2008 | |||||||
Defect Summary | Gm is recalling 857,735 my 2006-2008 buick lucerne; cadillac dts; hummer h2; my 2007-2008 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl, saturn outlook; and my 2008 buick enclave vehicles equipped with a heated wiper washer fluid system. a short circuit on the printed circuit board for the washer fluid heater may overheat the control-circuit ground wire. | |||||||||||||||
Consequence Summary | This may cause other electrical features to malfunction, create an odor, or cause smoke increasing the risk of a fire. | |||||||||||||||
Corrective Summary | Dealers will install a wire harness with an in-line fuse free of charge. the recall began on september 12, 2008. owners may contact buick at 1-866-608-8080; cadillac at 1-800-982-2339 or http://www.cadillac.com; chevrolet at 1-800-630-2438; saturn at 1-800-972-8876 or http://www.saturn.com, gmc at 1-866-996-9436; or hummer at 1-800-732-5493; or through their website at http://www.gmownercenter.com . | |||||||||||||||
Notes | Gm recall no. 08048. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
10V240000 | GENERAL MOTORS CORP. | V (Vehicle) | 1365070 | 06/11/2010 | MFR | GENERAL MOTORS CORP. | 06/04/2010 | 06/04/2010 | ||||||||
Defect Summary | Gm is recalling certain model year 2006-2009 buick, lucerne; cadillac dts; hummer h2; model year 2008-2009 buick enclave; cadillac cts; model year 2007-2009 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl; saturn outlook; and model year 2009 chevrolet traverse vehicles equipped with a heated washer fluid system (hwfs). a recall was implemented in 2008 to add a fuse to the control circuit harness to address the potential consequences of a printed circuit board (pcb) electrical short. however, there have been new reports of thermal incidents on hwfs modules after this improvement was installed. these incidents resulted from a new failure mode attributed to the device's thermal protection feature. the significance varies from minor distortion to considerable melting of the plastic around the hwfs fluid chamber. | |||||||||||||||
Consequence Summary | It is possible for the heated washer module to ignite and a fire may occur. | |||||||||||||||
Corrective Summary | Dealers will permanently disable and remove the heated washer fluid module. an updated page for the owner manual will be provided and inserted in the owner manual to document that the feature has been permanently disabled and removed from the vehicle. the safety recall is expected to begin on or before june 11, 2010. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, saturn at 1-800-972-8876, gmc at 1-866-996-9463 and hummer at 1-800-732-5493 or at the owner center at www.gmownercenter.com. | |||||||||||||||
Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM | |||||
PB-10037A | 04/01/2011 | 10038759 | Gm: onstar is making incomplete calls without the driver knowing. when have a data connection. *rm | 06/27/2011 | |
PB-10037A | 04/01/2011 | 10038759 | Ready | 06/27/2011 | |
SB-09-06-03-004A | 09/01/2009 | SB-09-06-03-004B | 10032332 | Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). | 03/05/2010 |
071201 | 02/01/2007 | 10022210 | Electrical diagnostics. illumination of the check engine light, and abs light. and an inoperative central tire inflation system (ctis). *kb | 07/23/2007 | |
060421001 | 05/01/2006 | 10020840 | Updated transfer case connector service kit now available for transfer case speed sensor wire harness connector that comes loose or connector retainer clip breaks. 2007 and prior gm light duty trucks. *kb | 01/24/2007 | |
3812 | 3812C | 10020076 | Throttle body codes p2108, p1516, and u0107. *tt | 07/19/2006 | |
050844027 | 09/01/2005 | 10017841 | Information on vehicles with a stored history dtc b1259 antenna ground circuit. *tt | 12/05/2005 | |
050603002 | 07/01/2005 | 050603002A | 10017463 | Battery and charging system electrical diagnostics. 1997 - 2006 all gm cars and trucks. *tt | 11/08/2005 |
3391 | 3391B | 10013540 | Unwanted operation of the hazard flashers. *eh | 04/21/2005 | |
3089 | 3089B | 10009520 | Service engine soon light and reduced engine power with a diagnostic trouble code p1516. diagnostic trouble codes p0120, p0220, p1514, p1515, p1518 and p2135 may also be present. *tt | 10/04/2004 | |
030604012 | 08/01/2005 | 030604012A | 10000949 | Inspection of all related wiring harness connections when diagnosing miscellaneous diagnostic trouble codes, intermittent driveability concerns, hard start, no start, incorrect gauges, inoperative air conditioning systems, service engine so | 04/04/2003 |
020603008 | 06/01/2007 | 020603008C | 634241 | Low voltage display on ip gauge, lights dim at stop lights, battery discharged, no start, slow cranking, dim lights at idle, low generator output. nlm *ar includes 1990-2008 passenger cars and light duty trucks including saturn. upda | 09/28/2002 |
ELECTRICAL SYSTEM - BATTERY | |||||
020603009 | 03/01/2006 | 020603009B | 634238 | Battery charging tips - 1990-2003 passenger cars and light duty trucks, 1990-2003 isuzu light duty trucks, 2003 hummer h2. nlm 1990 - 2007 gm passenger cars and light duty trucks (including saturn); 1990 - 2007 isuzu light duty trucks. | 09/28/2002 |
ELECTRICAL SYSTEM - WIRING | |||||
SB-09-06-03-004A | 09/01/2009 | SB-09-06-03-004B | 10032332 | Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). | 03/05/2010 |
060845004 | 05/01/2006 | 10020832 | Instrument panel, body and general wiring harness repair. 2007 and prior gm passenger cars and trucks. *kb | 01/24/2007 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ELECTRICAL SYSTEM | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
ELECTRICAL SYSTEM - BATTERY | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
ELECTRICAL SYSTEM - WIRING | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM | |||
10/22/2008 | 10000 | ||
Tl*the contact owns a 2006 hummer h2t. while driving at approximately 45 mph, the vehicle was hit by another vehicle on the front driver side. none of the air bags deployed and the on-star system did not activate. the vehicle had not been inspected at the time of the complaint but the manufacturer planned to send a team of specialists to look at the vehicle. the failure mileage was approximately 10,000. the current mileage was approximately 35,000. | |||
08/07/2009 | 54500 | 1 | |
I purchased a 2006 hummer h2 at cerritos hummer. i currently have almost 55,000 miles. today i was parking my car and noticed the steering was extremely hard to turn. also the brakes were really weak. i used all the energy i had to get into a gas station driveway. i drove about 1 block because i needed gas where i noticed oil dropping under the car. i checked under the hood and the oil was coming out near the power steering pump. i opened the power steering reservoir and saw that there was very little oil because it had dropped under my car. my steering is too hard to turn and the brakes are almost non existent pulling into the gas station. i called cerritos hummer and talked to their service manager and he said i was past warranty. i told him that there was a recall on this exact problem, but he said no and got very loud and mean to me. i told him he did not have to get mean because he can only do what the computers and protocol suggests, but he did not do enough research prior to rejecting any recalls. he said i would have to tow my car there and they would have to inspect and the charges could be high depending on the problem. i said there was a recall but he rejected it again in a strong tone. i did not want to argue in case they have to repair my car. i think that this problem is a serious health issue because a weak person would not have the strength to pull into the parking lot as i did. i pulled various muscles in my arms and shoulders steering the car into the gas station. i do not have another car and i don't think i can pay the cost to have my car towed approximately 25 miles to cerritos hummer. they said they would not pay any tow charges nor inspection costs nor costs to repair the problem. i spend way too much money at their dealership to be treated this way. i am usually an easy going guy, but the treatment he gave me really angered me. my back arms and shoulders hurt because the steering was so hard. *tr |