Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
PIP-4138K | 01/01/2011 | 10037933 | Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm | 06/08/2011 | |
PIP-4138K | 01/01/2011 | 10037933 | Ready | 06/08/2011 | |
050604060 | 09/01/2005 | 10017826 | Powertrain control module (pcm), engine control module (ecm), transmission control module (tcm) diagnostic trouble code(s) (dtc)(s) p0601, p0602, p0603, p0604, p1621 shared in multiple modules. *tt | 12/02/2005 | |
3045 | 3045E | 10013516 | Shudder or bind on truns in 4 hi. *eh updated 03-01-07. *kb | 04/20/2005 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
SB-07-06-04-019A | 11/01/2008 | 10028831 | General motors: intermittent mil/ses/ dtc p2138 with reduced engine power (repair instrument panel (ip) to body harness connector). 2005-08 gm passengers cars/light duty trucks (incl. saturns). *pe | 06/01/2009 | |
070604019 | 06/01/2007 | 10022702 | Intermittent mil/ses, dtc p2138 with reduced engine power (repair instrument panel (ip) to body harness connector). 2005-2008 gm passenger cars and light duty trucks including saturn. *nj | 09/21/2007 | |
060139002 | 04/01/2007 | 060139002B | 10022260 | Front blower motor inoperative or may not shut off in extremely low ambient temperature conditions. *kb | 07/24/2007 |
4231 | 10021021 | Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb | 02/22/2007 | ||
060604042 | 09/01/2006 | 060604042A | 10020880 | Lr4, ly2, l33, lh6, lm7, l59, lc9, lmg, ly5, ls2, lq9, lq4, l76, ly6 throttle actuator control (tac). module codes, mil/ses dtc's p2108, p1516, u0107, reduced engine power. *kb | 01/25/2007 |
3462 | 3462A | 10020689 | Blower motor is in-operable/ will not shut off/ dead battery. *kb | 12/22/2006 | |
050604035 | 08/01/2007 | 050604035C | 10019884 | Usage of e85 fuels in gm vehicles. 1997 - 2008 all gm cars and trucks. 1997 - 2008 all saturn vehicles. *tt updated. *kb updated on 10/22/07. *nj | 05/08/2006 |
020604015 | 03/01/2006 | 020604015A | 631266 | Intermittent no crank, no start condition for 2001-2002 passenger cars and trucks. *slc 2001-2007 gm passenger cars and light-duty trucks (including saturn). *tt | 05/21/2002 |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
000604033 | 09/01/2005 | 000604033A | 10017832 | I/m readiness as part of emission inspection and maintenance program for obd ii vehicles. *tt | 12/02/2005 |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||||
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
ENGINE AND ENGINE COOLING - ENGINE | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
08/05/2009 | 55000 | 1 | |
1. normal driving in town and highway 2. failure of the drivers side exhaust manifold bolts; causes exhaust gases to fill engine compartment and bypasses the catalytic emissions equipment. *tr 3. drivers side head had to be removed, broken manifold bolts extracted from the head, new manifold and stronger manifold bolts installed. *tr |