Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| PIT-5028 | 09/01/2010 | 10036324 | Pontiac/saturn/buick/gmc/chevrolet/cadillac/hummer: vehicle start and stalls after theft deterrent module replacement. model years 2006-2011. does not apply to vehicles with keyless access system. *pe | 03/14/2011 | |
| SB-07-06-04-019A | 11/01/2008 | 10028831 | General motors: intermittent mil/ses/ dtc p2138 with reduced engine power (repair instrument panel (ip) to body harness connector). 2005-08 gm passengers cars/light duty trucks (incl. saturns). *pe | 06/01/2009 | |
| PIP4321 | 02/01/2008 | PIP4321A | 10024285 | Oil leak at rear of engine. equipped with a 4.8, 5.3, 6.0 or 6.2 v8 engine. *nj | 04/01/2008 |
| 070601016 | 08/01/2007 | 10022932 | Information on internal engine noise or damage after oil filter replacement. models - 2008 and prior passenger cars and trucks (including saturn and saab) and prior hummer h2, h3. *nj | 10/05/2007 | |
| 070604019 | 06/01/2007 | 10022702 | Intermittent mil/ses, dtc p2138 with reduced engine power (repair instrument panel (ip) to body harness connector). 2005-2008 gm passenger cars and light duty trucks including saturn. *nj | 09/21/2007 | |
| 04-06-01-029 | 02/01/2008 | 040601029B | 10012707 | Unnecessary engine crankcase and subsystems flushing services, additive recommendations and proper utilization of gm simplified maintenance schedule to enhance customer service experience. 2008 and prior gm cars and trucks. *tt upda | 03/11/2005 |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | ||||||
| PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
| In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ENGINE AND ENGINE COOLING - ENGINE | ||||||
| PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
| In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||