Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | ||||||||||||||||
| 03V257000 | HYUNDAI MOTOR COMPANY | from 06/30/2000 to 12/15/2002 | V (Vehicle) | 312292 | 10/13/2003 | MFR | HYUNDAI MOTOR COMPANY | 07/22/2003 | 07/29/2003 | |||||||
| Defect Summary | On certain passenger vehicles, the rear brake tubes pass behind the front suspension crossmember. two steering gearbox mounting brackets are welded to the crossmember. on vehicles equipped with an antilock brake system (abs), the rear brake tubes could contact both steering gearbox mounting brackets. on vehicles that are not equipped with abs, the rear brake tubes may contact only the left mounting bracket. contact between the rear brake tubes and the steering brackets could cause wear and corrosion that could result in brake fluid leakage. | |||||||||||||||
| Consequence Summary | Fluid leakage could result in reduced braking capability increasing the risk of a crash. | |||||||||||||||
| Corrective Summary | Dealers will reposition the rear brake tubes so they do not contact the mounting brackets, install brake tube clips to control the location of the rear brake tubes, and apply anti-corrosion material to the tubes in the areas where contact with the mounting brackets may have occurred. owner notification began on october 13, 2003. owners should contact hyundai at 1-800-633-5151. | |||||||||||||||
| Notes | Hyundai recall no. 061.customers can also contact the national highway traffic safety administration | |||||||||||||||
| 03V496000 | HYUNDAI CARIBBEAN-PUERTO RICO | from 06/30/2000 to 12/15/2002 | V (Vehicle) | 1993 | 01/22/2004 | MFR | HYUNDAI MOTOR COMPANY | 12/03/2003 | 12/03/2003 | |||||||
| Defect Summary | On certain passenger vehicles, the brake tubes for the rear brakes can contact the steering gearbox mounting brackets. | |||||||||||||||
| Consequence Summary | Contact between the rear brake tubes and the steering gearbox mounting brackets may result in rear brake tube wear and corrosion, increasing the risk of brake fluid leakage. brake fluid leakage could result in reduced braking capability, which could result in a crash. | |||||||||||||||
| Corrective Summary | Dealers will reposition the rear brake tubes, install brake tube clips, and apply anti-corrosion material to the rear brake tubes. owner notification began january 22, 2004. owners should contact hyundai of puerto rico at 1-800-633-5151. | |||||||||||||||
| Notes | Hyundai recall no. 061.customers can also contact the national highway traffic safety administration | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SERVICE BRAKES, HYDRAULIC | |||||
| 061 | 10/03/2003 | 10004464 | Campaign 061 provides the procedures for repositioning the rear brake tubes to prevent contact with the front suspension crossmember's steering gear box mounting brackets. *tt | 12/15/2003 | |
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - CALIPER | |||||
| 0250002 | 01/01/2002 | 628959 | Subject regarding front brake caliper rattle noise repair kit. *tt | 03/25/2002 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SERVICE BRAKES | |||
| 06/04/2002 | 24000 | 1 | |
| Car shimmies really bad at 35 miles an hour replaced front brakes and rotors front struts tie rod ends both inner and outer to no avail i am sick of putting money in this piece of junk. *tr | |||
| 08/25/2012 | 160000 | 1 | |
| The brake lights stayed on all night after car was put in park and engine was turned off, causing battery to lose all power. this could be caused by a faulty brake/stop light switch. a recall was issued for brake/stop light switch on different years and models of hyundai vehicles. my 2001 hyundai elantra gls was not included in the recall but probably should have been. *tr | |||
| 08/25/2012 | 160000 | ||
| The brake lights stayed on all night after car was put in park and engine was turned off, causing battery to lose all power. this could be caused by a faulty brake/stop light switch. a recall was issued for brake/stop light switch on different years and models of hyundai vehicles. my 2001 hyundai elantra gls was not included in the recall but probably should have been. | |||
| SERVICE BRAKES, AIR - ANTILOCK | |||
| 08/07/2002 | 14 | ||
| The consumer states that when trying to apply the anti lock brakes, the brakes will lock up causing the consumer to have a vehicle accident. dealer notified. the consumer states that after mcconnell, she had taken the vehicle to big 10 to check the brakes. the consumer states that she and a passenger were at a red light when the consumer depressed the brakes, no stopping occured and ran through the lights. the consumer struck the rear bumper of the vehicle in front of her. *scc | |||
| SERVICE BRAKES, AIR - CONTROLS - FOOT CONTROL | |||
| 04/20/2001 | 59900 | 5 | 01/05/2001 |
| Brakes failed. unable to stop. had to initiate emergency measures--emergency brake, put car into park. | |||
| SERVICE BRAKES, AIR - SLACK ADJUSTERS - AUTOMATIC | |||
| 1 | 03/12/2002 | ||
| Consumer had to constantly put brake fluid in vehicle. when the brakes were applied the brake pedal went to the floor, and vehicle hit another vehicle. there were no injuries. the dealer was contacted. *ak | |||
| SERVICE BRAKES, HYDRAULIC | |||
| 02/13/2009 | 99000 | ||
| Tl*the contact owns a 2001 hyundai elantra. while driving 25 mph, the driver was unable to stop the vehicle. the driver's side of the vehicle crashed into a curb. there were no injuries. the contact noticed that the frame of the vehicle was rotted. there were no warnings prior to the failure. the vehicle was towed to the dealer and they stated that the lower front control arm was rusted. no repairs have currently been made to the vehicle. the contact called the manufacturer and was informed that they would cover the repair costs. the failure mileage was 99,000. | |||
| 05/08/2006 | 60000 | ||
| Tl*the contact owns a 2001 hyundai elantra. while driving approximately 30 mph, the brake pedal extended to the floor when it was depressed. the brakes were pumped several times before the vehicle came to a complete stop. a small amount of smoke appeared underneath the hood. the air bag and engine warning lights illuminated intermittently on the instrument panel. in addition, the contact exerted more effort to turn the steering wheel as if there were no power steering. the vehicle was taken to an authorized dealer and they replaced the power steering hose. the vehicle has not been repaired. the failure mileage was 60,000 and current mileage was 98,000. | |||
| 10/28/2005 | 1 | 02/01/2001 | |
| 10/28/05 car did not stop immediately while parking, went through fence and hit deck. brakes did not hold in sand. car towed to dealership who informed, nothing wrong with brakes. advised by dealership that the recall on brakes for hyundai elantra 2001 was remedied by them. brakes still do not hold well, advised by another mechanic that brake shoes are fine. still do not have a good comfort level with brakes. air bag light on, recall on file for model and year, dealer advised not for my car. will fix at cost of approximately $700.00. *nm | |||
| 06/15/2003 | 27694 | ||
| It is back at earnhardts, for the elec. system again 4th time. it started in 3/02 and went out again last fri. 6/6/03 but they don't consider it a problem. because i filed a lemon law on the previous accent and replaced it with the elantra 2001 and i filled out a survey saying they had bad customer service, the normal use of a rental while they fixed it for days was not granted. i am so upset i spent a day out in the az sun waiting for a tow of 205 miles to the next dealership and they tell me i have a bad record with them and don't deserve the courtesy of a rental car. this is my second hyndai and i have had nothing but trouble with it and the dealership. i have sent letters to the attorney general, three on my side, hyndai and earnhardts dealership. i want out of this car and don't feel safe in it any more. i was going down the salt river canyon (if you are not from az picture going down the twisting road to the grand canyon) without any power steering, brakes and trying to keep control of the car with kids in it. and they tell me i shouldn't be excited! 1 1/2 hrs in the sun waiting for the tow, the next dealership 200 mi away, no rental cars authorized, so my husband has to drive up and get me (198) miles from my house and go back so he could be at work in 3 hrs. no sleep for him. the dates are 3, 4, 6 of 2002 and now 6/6/03. the mileage is 27,694. the cost is theirs because it has the 100,000 warranty. just the mental and physical anguish and inconvience of another car that won't work right now. | |||
| 06/30/2003 | 15000 | 4 | 06/30/2001 |
| Air bag light continued to illuminate even after (4) attempts by the dealership. the actual cause had not been identified. mr also the vehicle experienced brake problems. ph *jb abl.pco | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 03/15/2007 | 84000 | 1 | 08/15/2006 |
| Abs system failed during braking, causing rear end collision air bags did not deploy. *jb | |||
| 21800 | 1 | ||
| Consumer complained about a brake problem. when driver applied brakes while driving 25-30 mph vehicle did not stop. consumer's vehicle rear ended vehicle in front. currently, vehicle was being recalled for brake malfunction.*ak | |||
| 11/06/2003 | 13000 | 2 | |
| While driving at various speeds driver depressed the brake pedal the vehicle took longer to operate, so extended stopping distance was necessary. *ak | |||
| 10/30/2003 | 41500 | ||
| While driving at 30 mph driver applied the brakes and they failed. vehicle took longer to stop,and it rear ended another vehicle. prior to the accident, consumer called the dealer to verify if nhtsa recall 03v25700 concerning abs failure applied to her vehicle. dealer denied it. three weeks after the accident consumer received a recall letter on the abs system.*ak | |||
| No summary listed for above vehicle. *ak | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - ABS WARNING LIGHT | |||
| 08/22/2003 | 19000 | 1 | |
| Abs warning light intermittently flashes on and stays on while driving. this could result in either none deployment or premature deployment of air bags. cause of the problem undetermined. *ak abl.pco | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
| 05/26/2002 | 1 | ||
| Consumer applied brakes at 30-35 mph, vehicle did not slow down. consumer pumped brake pedal numerous times, no braking action, vehicle hit a concrete wall. vehicle was totalled.*ak driver and passenger suffered injuries. none of the air bags deployed in the accident. *jg | |||
| 03/01/2001 | |||
| Brakes engaging and overheating on the freeway, intermittently; this may affect the ability to stop quickly enough in an emergency. details: since the brakes were first serviced at just under 4,000 miles, there is a continuing problem with the brakes randomly engaging by themselves on the freeway. when this happens, its not sufficient to cause the vehicle to stop, but the car at times will labor to maintain speed. the car also produces a low pitch humming sound and a stiff vibration (shimmy) in the steering wheel. the brake pedal pulsates when barely touched (at the time this phenomenon is occurring). after a number of miles the symptoms disappear. the frequency of this event is about once every 100 to 200 miles. i believe the humming, steering wheel vibration, and pulsating feeling of the brake pedal is because the brakes are in an overheated state due to the calipers dragging. hyundai service is unable to replicate this problem, but i strongly believe this is because of their failure to sufficiently road test the vehicle; i.e., they may have to road test the vehicle for 2 hours in varying conditions, hot weather, mostly freeway to replicate. hyundai, after being given the above description of problems on two different service calls, has never resolved the issue (of course, meaning the cause of the problem remains a mystery). i have videotaped this phenomenon, which happens about 30 minutes into the videotaping session. i am willing to make copies and send to those who feel viewing the tape would be helpful in determining the appropriate course of action. please advise if youd like a copy of the videotape, and if so, where it should be sent. please e-mail at: jkunst@swiftcor.com. *ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||
| 1000 | 1 | ||
| Consumer complained about a brake problem. when applying the brakes they vibrated.*ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - ROTOR | |||
| 08/31/2003 | 75890 | 3 | 05/16/2001 |
| Braking from highway speeds 70 down to 50 results in serious vibration and pulsation due to out of round disc brake rotors. feels like possible loss of braking control. problem has existed since vehicle was new and corrected only by machining the front brake rotors. original rotors machined 3 times in 65000 miles. original rotors recently replaced with new oem parts and problem occured again within 5k miles. complained to dealer and hyundai regional manager. explanation was that rotors are not defective if out of round and condition can be corrected by machining. appears rotors are unable to withstand braking temperatures and warp as result. quality of steel material used in manufacturing the rotors appears poor. hyundai does not seem to acknowledge problem with flaw in manufacturing process.*ak | |||
| 11/12/2002 | 42000 | 1 | 07/13/2002 |
| The brake rotor overheated, which caused a grinding noise when the brakes were applied. dealer is aware of the problem. mr *tt *jb | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM - SHOES/LININGS | |||
| 03/27/2001 | 3 | 03/01/2001 | |
| The next day after purchase and the first time i used the auto in reverse there was a loud clunk from the rear right side of the brakes. it sound like the brake shoes were loose and the retaining springs pulled the shoes into proper alignment when the self adjusting brakes came into operation. i was on an approch ramp at 55 miles an hour to merge at 65 to oncoming traffic. i was looking back for on coming traffic, i look up and a car was stopped, i slammed on the brakes. the car finally stop inches from the auto ahead. no skid mark. the wheels didnt lockup. i brougt the car in. on advise of the factoru the cleand up the rotors, replaced the front pads. this a positive indication that they are aware of such a problem. upon a test drive on my own i found i could not lock up the brakes. later i took the car back and had the service manager test drive the car with me. he also could not lock up the brakes. he said he test drove 2 other elantras and they reacted the same. police measure speed at an accident by the skid marks left. if i were to get into an accident they would find no skid an assume i didnt even apply the brakes!!! these are not anti lock. i'm worried. i need help before i'm killed and the accident report says, he didnt even apply the brakes. there were not skid marks and the police could only speculate at what speed he must have been traveling. h e must have been drunk, had a heart attack or passed out.*ak | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | |||
| 02/02/2006 | 58000 | ||
| Tl* the contact owns a 2001 hyundai elantra. his vehicle was repaired according to recall 03v257000 ( service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings). after the repair, he noticed that the brake lines had holes in them which caused brake fluid leakage. there was no compression in the brake line , so the pedal fell completely to the floor during application. he took the vehicle to the dealership and was advised that the entire brake line needed to be replaced. the manufacturer was notified, but no assistance was provided. no repairs were made. the current mileage was approximately 58,000. the failure mileage was approximately 37,000. | |||
| 03/01/2001 | 1000 | 4 | 01/01/2001 |
| Tl*the contact owns a 2001 hyundai elantra. the front passenger side window air bag was replaced in 2004. the day after the replacement, the air bag light illuminated again. the vehicle was taken back to the dealer and they stated that they could not determine the cause of the failure. the contact discovered an air bag safety recall online, but the dealer stated that no recall was available. in 2004, the contact also informed the dealer that the weather stripping on the back door frame was too small. the vehicle was still under warranty. the dealer pushed the weather stripping back on the door. in 2005, the contact heard a strange noise coming from the engine compartment and the vehicle stalled in hot weather. the dealer was unable to duplicate the failure. while at the dealer, she was informed of a brake line recall and clips were applied. the following day, the vehicle began squeaking when she applied and released the brakes. the recall numbers were unknown. the current mileage was 84,448 and failure mileage was 1,000. abl.pco | |||
| 07/01/2004 | 1 | ||
| 2001 elantra regarding rear brake tubes recall notice.*mr it took several tries to get the recall performed on the consumers vehicle. the consumer made an appointment to have the repairs made, however when the consumer showed up, the dealer was closed, the consumer was told the dealership had changed ownership and to call back. the consumer called back twice and was told they were still closed. the consumer took the vehicle to another dealership and was told they were booked despite having an appointment. the consumer took the vehicle back to the dealership the following day and was told it would take most of the day, but when the consumer received the vehicle, the invoice stated the part had to be ordered. *jb | |||