Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| 01011901 | 08/01/2005 | 10018184 | Automatic transaxle diagnostic trouble codes list. *nm | 12/16/2005 | |
| 0436022 | 12/01/2004 | 10011790 | Diagnostic trouble code (dtc) p1178 -electronic throttle system (ets) motor power-open and p1118 (ets) motor. *nm | 01/31/2005 | |
| 0436013 | 08/01/2004 | 10009781 | Diagnostic trouble codes (dtcs) revision. to include 2005 santa fe. *tt | 10/25/2004 | |
| 0440008 | 06/01/2004 | 10007957 | Transaxle control module (tcm) reprogramming instructions for driveline bump between 2-10 mph.*mr | 07/18/2004 | |
| 0250013 | 05/01/2004 | 0450002 | 633755 | G sensor diagnostic trouble code inspection and repair procedure. *jg this bulletin replaces 02-50-013 and 01-50-005 dated aug. 2002. *tt | 09/24/2002 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 08/14/2010 | 60000 | ||
| 3rd time crank shart sensor went in 1year/5 months. car only has 60,000 miles. all 3 times, car would not accelerate, check engine light then appears and seconds later the car shuts off. twice we were on the highway when this happened and lucky we had enough time to get over to the breakdown lane before the car shut down. 3 times in a year and 5 months, this should not happen... also, the air bag light has been coming on for the last year. | |||
| 07/27/2006 | 25109 | 1 | |
| I have documented 8 times that the electrical system has failed in my car - taken to dealer and they keep saying due to corrosion on wires but i find it hard to believe that every 3-4 mths that happens - i do not live near the beach. the car will be out of warranty end of this year and i feel the problem is not being solved. *tr | |||
| 12/12/2008 | 90000 | 1 | |
| Airbag light came on. diagnosed as faulty wiring. dealer got it to go out, but if it comes back on again they say the entire passenger side airbag needs to be replaced. dealer cannot say if the air bag will deploy in an accident and says that the manufacturer will not say either. now, the light is out behind the heater control button. once again diagnosed as faulty wiring. faulty wiring sounds like a factory problem to me. all services on this vehicle have been done since day one as recommended by the manufacturer. *tr | |||
| 11/26/2008 | 63200 | 1 | |
| I purchased a used 2004 hyundai santa fe in aug/2005 from a hyundai dealership (# ). in aug/2006, the airbag light came on. the vehicle was taken to the dealership and the results were code b1382 psab resistance high - resecure connector under the passenger seat/clear code. in feb/2008, the airbag sensor again appeared. the same technical code was detected, and the dealership resolution was to reroute wire harness. in mar/2008, the airbag light again appeared and was serviced by the dealership. in nov/2008, the vehicle was again taken to the dealership due to the airbag light appearing. at the time of service in nov/2008, the vehicle was out of warranty. the dealership indicated they would not fix the airbag free of charge under the warranty, at which time, they were informed that a complaint would be filed under the california lemon law due to repeat fixes for the same issue. the dealership then fixed the issue. on nov. 26, 2008, the vehicle was hit in a high-speed rear end collision (~35mph) while at a stop light and pushed into an intersection, where it broadsided a moving vehicle. as a result of the impacts, the hyundai was totaled, all rear seated passengers sustained injury due to the spare tire being lifted from the initial impact and raising the 60/40 split rear seat and pushing it forward, the front passenger received chest contusions and the driver of the vehicle sustained upper body injuries. despite being pushed forward and making a strong impact, the airbags failed to deploy. i requested hyundai investigate the matter, and they determined that although the front right of the vehicle was damaged from the secondary impact, it was not sufficient to warrant airbag deployment. i researched complaints from other hyundai owners regarding repeated airbag sensor light repairs and other airbag failures, including stories of crashes into poles with failed airbags. hyundai has not issued any recall, but they probably should. *tr | |||
| 09/25/2006 | 18000 | 3 | 10/28/2004 |
| Dt*: the contact stated while driving at any speed, the speedometer dropped down to 0 mph. the speedometer picked back up between 2-5 minutes. the problem was getting progressively worse. the dealership was aware of the problem. sometimes the problem occurred 2-3 times a day.*ak updated 10/17/2006 - this problem has been ongoing since the vehicle was purchased. *nm | |||
| 12/27/2005 | 10 | 02/01/2004 | |
| Engine cuts out while driving, unable to have power steering, car lurches without warning, usually when moving from a stop. *jb | |||
| 02/02/2004 | 100 | 9 | 01/15/2004 |
| Dt: the end of january 2004 or beginning of february 2004 while in the car it shout off and steering wheel locked. about 30 seconds later the car just started up by itself. then, in april 2004 the car did this again while driving on the highway. got a recall 03v030000 notice on this vehicle which stated it would stall in cold damp weather, took vehicle tto he dealer they fixed the problem. . then in june 2004 while driving in traffic on a sunshine day the car did same thing. took it back to dealer, and they assured consumer that they fixed the problem. early august the car stalled in an intersection. took back to dealer again, said they fixed it again. late august, two days after the i got the car back,k the car stalled again.also, sept 12, 2004 the car did this again. *ak | |||
| 09/09/2004 | 112 | 6 | 06/11/2004 |
| Failure: gas gauge, acceleration issue, and seat belt sensor. *ak | |||
| ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | |||
| 06/28/2004 | 5000 | 2 | 06/28/2004 |
| The night i took delivery of the vehical i had electrical problems this was to be fix by dealership, well now 8/15/2004 there are more elec. problems the fuses are blowing and the brakes are not stopping as should be.also the trasmission when appling the gas pulls to the right, and between 40/60 mph jecksing sensation to the vehicle. *ak | |||
| ELECTRICAL SYSTEM - WIRING | |||
| 09/01/2004 | 100 | 100 | 08/28/2004 |
| Contact states: while driving radio was going on and off along with automatic locks. took vehicle to dealer and replaced radio but found no problem with locks. while on interstate or for long periods of time the locks begin flipping on and off. had to replace two interior light bulbs as well. dealer does not listen to complaints. | |||