Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| POWER TRAIN | ||||||||||||||||
| 01V362000 | HYUNDAI MOTOR COMPANY | from 08/24/2000 to 09/30/2000 | V (Vehicle) | 1963 | 01/27/2002 | MFR | HYUNDAI MOTOR COMPANY | 11/29/2001 | 12/04/2001 | |||||||
| Defect Summary | Vehicle description: passenger vehicles. improperly manufactured powertrain control modules (pcm) were installed in some vehicles. the improperly manufactured pcms contained a condenser that was not correctly installed onto the pcm printed circuit board. the incorrect installation of the condenser could result in damage to the ignition failure sensor. | |||||||||||||||
| Consequence Summary | A damaged ignition failure sensor could result in engine stalling, increasing the risk of a crash. | |||||||||||||||
| Corrective Summary | Dealers will inspect the pcm to determine if it was manufactured during the affected production period. if necessary, the pcm will be replaced. owner notification began january 27, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact hyundai at 1-800-633-5151. | |||||||||||||||
| Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN | |||||
| 0340014 | 09/01/2004 | 0440015 | 10009752 | Automatic transaxle diagnostic trouble code p0885 & p1723. *tt | 10/20/2004 |
| 0340006 | 05/01/2003 | 0240026 | 10002334 | Ata solenoid diagnostic trouble codes p0740, p0741, p0742, p0743, p0750, p0755, p0760, p0765, p0770. *tt | 08/22/2003 |
| 14092001 | 09/14/2001 | 623978 | Information regarding pcm adaptation for varying a/c loads to prevent enging surging. *yd | 10/31/2001 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| TSB-09-AT-013 | 07/01/2009 | 10030984 | Hyundai: automatic transaxle range switch diagnostic trouble codes p0705 (range switch signal problems), p0707 (range switch open circuit), and p0708 (range switch short circuit or multiple inputs). an improperly adjusted or improperly op | 12/29/2009 | |
| 0540008 | 12/01/2005 | 05400081 | 10015866 | Automatic transaxle diagnostic trouble codes list. *sc | 08/15/2005 |
| 0140010 | 09/01/2004 | 0440016 | 10010525 | Automatic transaxle diagnostic trouble code p0711, p0712 and p0713. *tt | 11/30/2004 |
| 0440004 | 03/01/2004 | 0340009 | 10003284 | 4-5 shift shudder - automatic transmission replacement procedure and transmission control module (tcm) reprogramming instructions. *tt this bulletin updates tsb 03-40-009 to correct warranty information. *tt | 10/15/2003 |
| 133 | 05/01/2003 | 10003222 | Third gear fail-safe information. *tt | 10/10/2003 | |
| 0340014 | 08/01/2003 | 0240009 | 10003044 | Automatic transaxle diagnostic trouble code (dtc) p1723 accompanied with malfunction indicator lamp (mil) illuminated; transaxle held in 2rd gear fail-safe; harsh shifts into reverse or drive. *tt | 10/07/2003 |
| 122 | 03/01/2002 | 631486 | Subject regarding automatic transaxle harsh or delayed park-reverse or park-drive engagement. *slc | 05/29/2002 | |
| 0240011 | 03/01/2002 | 631411 | Information regarding automatic transaxle diagnostic trouble codes list. *yh | 05/23/2002 | |
| 0240013 | 04/01/2002 | 631418 | Concerns with automatic transaxle shiftronic diagnosis. *yh | 05/23/2002 | |
| 0240008 | 02/01/2002 | 629503 | Vehicles may experience a harsh or delayed park-reverse or park-drive engagement in vehicles equipped with automatic transmissions. *slc | 04/02/2002 | |
| 0240004 | 01/01/2002 | 628958 | Some vehicles may experience a 3-4 shift shudder condition. *tt | 03/25/2002 | |
| 0140023 | 10/01/2000 | 627048 | Subject regarding automatic transaxle oil drain plug. *yd | 02/05/2002 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||||
| TSB-09-AT-018 | 10/01/2009 | 10032908 | Hyundai: ata solenoid diagnostic trouble codes p0740, p0741, p0742, p0743, p0746, p0748, p0750, p0755, p0760, p0765, p0770. incorrect operation of the transaxle solenoids may result in the following symptoms-check engine light illuminated | 06/11/2010 | |
| 0236011 | 03/01/2002 | 0136007 | 630851 | Information regarding powertrain control module reprogramming. *slc | 04/24/2002 |
| 051101 | 05/11/2001 | 623014 | Information on pcm reprogramming for p0128 warning lamp and shift shock issues. *yh | 10/25/2001 | |
| 0136007 | 05/01/2001 | 622935 | This bulletin provides a procedure to reprogram the pcm. *et | 10/24/2001 | |
| POWER TRAIN - AUTOMATIC TRANSMISSION - GEAR POSITION INDICATION (PRNDL) | |||||
| 0140016 | 06/01/2001 | 622940 | Subject regarding automatic transaxle shift lever knob replacement. *yh | 10/24/2001 | |
| POWER TRAIN - AXLE ASSEMBLY | |||||
| 0640018 | 12/01/2006 | 10020912 | Automatic transaxle diagnostic trouble codes (dtc) list. *kb | 01/29/2007 | |
| 0640004 | 03/01/2006 | 10019638 | Oil leak at reduction brake piston cover. *tt | 04/12/2006 | |
| 158 | 11/01/2005 | 10018734 | Reprograms are available for automatic transaxle driveability issues. technet times. hyundai. *tt | 01/12/2006 | |
| 02400131 | 06/01/2002 | 0240013 | 633816 | Subject regarding automatic transaxle shiftronic diagnosis. *jg | 09/24/2002 |
| 0240019 | 08/01/2002 | 633785 | Subject regarding automatic transaxle harsh and/or delayed shifts. *jg | 09/24/2002 | |
| 0140022 | 10/01/2001 | 631719 | Subject regarding shiftlock and key lock cable adjustment for vehicles with sport shift. *slc | 06/19/2002 | |
| 0040014 | 10/01/2000 | 618323 | Information on diagnosing transaxle diagnostic trouble codes. *tt | 04/11/2001 | |
| 010101 | 01/01/2001 | 618054 | Subject regarding intermittent or inoperative sport mode switch. *tt | 04/03/2001 | |
| POWER TRAIN - AXLE ASSEMBLY - AXLE SHAFT - SEAL | |||||
| 0440009 | 06/01/2004 | 10009153 | Automatic transaxle differential oil seal. *tt | 09/14/2004 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 10/20/2003 | 24000 | 1 | 09/01/2001 |
| Tl*the contact owns a 2001 hyundai xg300. the contact stated that the vehicle would pull to the right when she drove various speeds including approximately 35 mph. she noticed the failure in october 2003. the tires were checked and aligned; however, the failure continued to occur. a local mechanic stated that the front subframe was corroded. she later inquired about recall 09v124000, suspension and was told that her vehicle was not included. she also stated that in august 2007 she noticed that the srs light was illuminated. the vehicle was inspected and it was cited that the srs light was on because of a faulty wire which was connected to the front seat and could not be adjusted. the vehicle would have to be taken apart to confirm that the wire was faulty. she also was informed that recall 02v105000, air bags, side/window was related to her failure but did not include her vin. in july 2009, she noticed that the fuel tank would not take gasoline. she felt as if it was because of the fuel tank assembly valve but it was not confirmed by an inspector. the vehicle rejected the fuel and caused spillage. she called the manufacturer and was advised that they could not assist her. the current mileage was 78,225. the failure mileage was approximately 24,000. updated 02/17/10. *lj the transmission was replaced, due to vehicle not going into drive at times. updated 02/19/10 | |||
| 02/17/2008 | 52000 | 1 | |
| I have ongoing problems with my car since after purchase in 2007. hyundai case #3479162 check engine light was going on and staying on unless the battery would die. failed emissions said to be caused by air sensors but codes kept getting whipped out.car has been to dealer countless times! car lunges thrashing motion while at a stop or driving. the air bag light stays on at all times,the first time the lunging happened i thought i was out of gas, with the exception of the violent thrashing that occured/s. my cars control panel,headlights and interior lights dim,shut off at will. all radio & control panel lights come on and go off at any time. the radio starts changing from fm to am to cd at any given time including while the car is turned off and unattended. the tail lights, brake lights and running lights also turn on/off by themselves whether driving the car or if the car is sitting in my driveway. i have to get my car jumped every time i go to start it .it wasn't until earlier this year that a neighbor came to let me know that i left my lights on in the middle of the night. i knew nobody had been in my car because i was recovering from a major surgery and my car keys are always with me. this incident with the neighbor shed light on part of the problem. now i know why my battery is constantly dead. i just don't know why the car is turning on it's electrical components. the ongoing problem with the battery drain has caused the codes for the car to keep being erased so there is no way to diagnose cause for the check engine /air bag light coming on. it's frightening that the lights go on or off, day or night, without cause. this is very dangerous while night driving! the stalling out while driving causes complete loss of the steering/brakescontrols and all power. i am terrified of hwy driving now! i could cause an accident that may kill me or someone else!the thrashing and lunging of the car scares me. the electrical is going on at least 8x day/night. this car is dangerous! *tr | |||
| 02/17/2008 | 52000 | 1 | |
| I have ongoing problems with my car since after purchase in 2007. hyundai case #3479162 check engine light was going on and staying on unless the battery would die.failed emissions said to be caused by air sensors but codes kept getting whipped out.car has been to dealer countless times! car lunges thrashing motion while at a stop or driving.the air bag light stays on at all times,the first time the lunging happened i thought i was out of gas, with the exception of the violent thrashing that occurred/s. my cars control panel,headlights and interior lights dim,shut off at will. all radio & control panel lights come on and go off at any time.the radio starts changing from fm to am to cd at any given time including while the car is turned off and unattended. the tail lights, brake lights and running lights also turn on/off by themselves whether driving the car or if the car is sitting in my driveway. i have to get my car jumped every time i go to start it .it wasn't until earlier this year that a neighbor came to let me know that i left my lights on in the middle of the night. i knew nobody had been in my car because i was recovering from a major surgery and my car keys are always with me. this incident with the neighbor shed light on part of the problem. now i know why my battery is constantly dead.i just don't know why the car is turning on it's electrical components.the ongoing problem with the battery drain has caused the codes for the car to keep being erased so there is no way to diagnose cause for the check engine /air bag light coming on. it's frightful that the lights go on or off, day or night, without cause.this is very dangerous while night driving! the stalling out while driving causes complete loss of the steering/brakescontrols and all power. i am terrified of hwy driving now! i could cause an accident that may kill me or someone else!the thrashing and lunging of the car scares me. the electrical is going on at least 8x day/nite. this car is dangerous! *tr | |||
| 01/07/2002 | 1 | 10/13/2001 | |
| I have a hyundai 2001 xg300. since my purchase in 2001 up until present at various and unpredictable times, when i accelerate the transmission stutters/ shudders causing a noticeable delay in acceleration. this condition is at all speeds but notable between 35-43 mph 55-65 mph. when i'm trying to pass another vehicle or if i would accelerate to move out-of another vehicles way i would be bogged down with a stutter/shudder from the transmission which may cause an unsafe condition. i've been to the dealership and they have been very helpful and up-dated the transmission computer but the problem did not get any better or worse. it appears hyundai is aware of the problem because they have a service bulletin on the problem. my concern is it may be a safety problem. *jb | |||
| 02/02/2002 | 02/01/2002 | ||
| My hyundai xg300 will not move and than plunges forward out of my control, does this the initial drive of the day anywhere from 5 to 30 minutes of driving. sometimes it just does it out of the blue, when stopped at a stop light. i spoke with one of your representatives today. i just got back from the store - when started my car, put it in drive and i almost hit the car in front of me, my car would not move and than it plunged out and i hit the brakes in time! this was way too close for comfort, and my body is still upset m as i type! we have a great driving record, great insurance rates and we are not antisipating a change, but if this problem is not corrected i could be looking at an accident or something worse! do you advise we stop driving until the problem is corrected? you site has listed recalls for xg300, same defect , manufactured between a certain date, of which mine was manufactured on 1/9/2001. the dealer told me he found nothing wrong, i wish i would have viewed your site before i saw the dealer, maybe me knowing would have helped him locate the problem. what should i do, take it back to the dealer? *ak | |||
| 01/30/2002 | |||
| When shifting to drive there is a delay of 3-5 minutes before vehicle goes forward, it will lurch quickly. dealer cannot find a cause. *ak | |||
| Vehicle will not shift into reverse. dealer was contacted and serviced vehicle. dealer replaced transmission. please provide further information. *ak | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||
| 04/06/2006 | 60870 | 1 | 07/14/2001 |
| Dt*: the contact stated while driving at various speeds, the automatic transmission pcm condenser failed resulting in a hesitation while accelerating. also, while stopped at a stop sign, the engine revved to a high level and suddenly decreased. the vehicle was seen by a dealer who reprogrammed the pcm, but the problem persisted. | |||
| 04/15/2004 | 34000 | 15 | |
| Intermittently will either stall or launch forward while driving. dealership replaced the pcm as indicated in the power train recall 01v362000, although the vin number was not included in the recall. the replacement of this part didn't correct the failure.*ak | |||
| POWER TRAIN - MANUAL TRANSMISSION | |||
| 12/01/2002 | |||
| While driving at highway speed the transmission light illuminated and there was a sudden decrease in acceleration. the vehicles rpm's dropped to 14. consumer states' this was very dangerous. please provide any further information. ts | |||