International 7500 2002
Model 7500 made in 2002 by International got 4 recalls as well as 7 service bulletins. Technical service bulletines regarding electrical system and engine and engine cooling. There were some recalls concerningelectrical system and fuel system, gasoline.
Model 2002
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - BATTERY - CABLES | ||||||||||||||||
04V306000 | INTERNATIONAL TRUCK & ENGINE CORPORATION | from 07/19/2001 to 05/19/2004 | V (Vehicle) | 18545 | 08/16/2004 | MFR | NAVISTAR, INC | 06/30/2004 | 06/30/2004 | |||||||
Defect Summary | On certain heavy duty trucks equipped with international dt530, cummins, or caterpillar i-6 engines, the positive battery cable between the batteries and the starter may rub against an electrical ground cable between the starter and frame rail. | |||||||||||||||
Consequence Summary | This could cause an electrical short and/or fire. | |||||||||||||||
Corrective Summary | Dealers will inspect for any chafing. if there is no evidence of chafing, a saddle clamp will be installed. if there is evidence of chafing, the damaged cables will be replaced and the saddle clamp installed. the recall began on august 16, 2004. owners should contact international at 1-800-448-7825. | |||||||||||||||
Notes | International recall no. 04510. customers can also contact the national highway traffic safety administration | |||||||||||||||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | ||||||||||||||||
02V205000 | INTERNATIONAL TRUCK AND ENGINE | from 07/19/2001 to 07/16/2002 | V (Vehicle) | 1066 | 12/20/2002 | MFR | NAVISTAR, INC | 07/26/2002 | 08/01/2002 | |||||||
Defect Summary | On certain heavy duty trucks, the fuel line is routed too close to a turbo charger outlet/exhaust pipe. if an interference condition occurs between the fuel harness and the exhaust pipe, the fuel line inside the reflective heat wrap could melt due to excessive heat. | |||||||||||||||
Consequence Summary | The melting of the line could result in immediate engine shut down, increasing the risk of a crash. | |||||||||||||||
Corrective Summary | Dealers will inspect the vehicles for proper routing of the fuel harness. if the harness is routed near the exhaust system, a new fuel harness will be installed. owner notification began december 27, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825. | |||||||||||||||
Notes | Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
POWER TRAIN - DRIVELINE - UNIVERSAL JOINT | ||||||||||||||||
04V144000 | INTERNATIONAL TRUCK & ENGINE CORPORATION | from 09/27/2001 to 03/08/2004 | V (Vehicle) | 2021 | 04/29/2004 | MFR | NAVISTAR, INC | 03/22/2004 | 03/26/2004 | |||||||
Defect Summary | On certain trucks equipped with dt466 or dt530 1308 style engines and 4x4 or 6x6 capability, the universal joint between the front drive shaft and drive axle could come in contact with the engine oil filter under certain braking conditions. | |||||||||||||||
Consequence Summary | This could cause a loss of complete engine oil which could result in the engine shutting down and increase the risk of property damage, personal injury, or a crash. | |||||||||||||||
Corrective Summary | Dealers will install a shorter oil filter and adapter. owner notification is expected to begin april 29, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825. | |||||||||||||||
Notes | International recall no. 04504.customers can also contact the national highway traffic safety administration | |||||||||||||||
TRAILER HITCHES - FIFTH WHEEL ASSEMBLY | ||||||||||||||||
05V188000 | INTERNATIONAL TRUCK & ENGINE CORPORATION | from 10/10/2001 to 03/21/2005 | V (Vehicle) | 4616 | 08/05/2005 | MFR | NAVISTAR, INC | 04/28/2005 | 04/29/2005 | |||||||
Defect Summary | On certain vehicles equipped with air operated fifth wheel slides and an msva 7-pack accessory controller, the 7-pack can allow water to contaminate its circuit board. this could result in inadvertent operation of the fifth wheel slide control. | |||||||||||||||
Consequence Summary | If the slide control actuates while the vehicle is in motion, momentum from the trailer can cause the fifth wheel to slide without input from the driver, which could result in a crash without warning. | |||||||||||||||
Corrective Summary | Dealers will relocate the msva 7-pack to a less water intensive environment. a new msva 7-pack base, that has been improved to prevent water intrusion, and all air accessory solenoids will be installed free of charge. the recall began on august 5, 2005. owners may contact international at 1-800-448-7825. | |||||||||||||||
Notes | International recall no.05511. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM | |||||
0438 | 06/22/2004 | 10007999 | Hvac setting fault code 613-14-1-6 prematurely. *mj | 07/19/2004 | |
0308 | 02/12/2003 | 10001415 | Instrument cluster pto indicator light activation while using in-cab or remote engine speed control. various models including the 7600 and 8600. *tt | 05/05/2003 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
04903 | 09/01/2004 | 04903R | 10008941 | Replace meritor transfer case il pump with new design oil pump in 7300, 7400, 7500 4x4 and 6x6 models built between september 27, 2001 and september 15, 2003. international models 7300, 7400, 7500 start date 09/01 end date 09/03. * | 09/01/2004 |
EQUIPMENT - ELECTRICAL - AIR CONDITIONER | |||||
041607 | 10/01/2004 | 10010694 | Criteria for conditioning accumulator replacement on hpv models. *tt | 12/06/2004 | |
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY | |||||
051501 | 02/01/2005 | 10012848 | Dual fuel tank transfer pump system with two wire fuel transfer pump troubleshooting. international. *tt | 03/31/2005 | |
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||||
061302 | 05/01/2006 | 10020357 | Guidelines to ensure satisfactory performance of meritor transfer case models mtc-4208, mtc-4210, mtc-4213 in certain international 7000 hpv models. *tt | 09/20/2006 | |
(PWS) | |||||
IK-0800219 | 06/04/2012 | 10044293 | International/navistar: a new design aps sensors (accelerator position sensor) has been developed to replaced open/closed ivs switches in old sensors. *pe | 06/06/2012 |