International 9100i 2003
Model 9100i made in 2003 by International got 3 recalls as well as 1 service bulletin. Technical service bulletines regarding electrical system. There were some recalls concerningelectrical system and service brakes, hydraulic.
Model 2003
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | ||||||||||||||||
03V072000 | INTERNATIONAL TRUCK & ENGINE CORPORATION | from 06/08/2001 to 11/04/2002 | V (Vehicle) | 881 | 03/13/2003 | MFR | NAVISTAR, INC | 03/06/2003 | 03/17/2003 | |||||||
Defect Summary | On certain heavy duty trucks built with a detroit engine and a leece neville alternator. the electrical terminal at the alternator end of the cable that runs from the starter to the battery stud on the alternator may break off, due to vibration in the cable. | |||||||||||||||
Consequence Summary | If the terminal breaks off, the cab will lose all power, resulting in complete electrical failure and engine shutdown, which may result in a crash and potentially cause property damage, personal injury, or death. | |||||||||||||||
Corrective Summary | Dealers will reroute and rewire the wiring harness to the alternator. owner notification began on march 13, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825. | |||||||||||||||
Notes | International recall no. 03506.customers can also contact the national highway traffic safety administration | |||||||||||||||
ELECTRICAL SYSTEM - BATTERY - CABLES | ||||||||||||||||
05V296000 | INTERNATIONAL TRUCK & ENGINE CORPORATION | from 04/01/2002 to 06/15/2005 | V (Vehicle) | 49607 | 07/22/2005 | MFR | NAVISTAR, INC | 06/24/2005 | 06/24/2005 | |||||||
Defect Summary | On certain 4x2 and 6x4 heavy duty trucks, the positive battery cable between the batteries and the starter may rub against an electrical ground cable between the starter and frame rail. | |||||||||||||||
Consequence Summary | This chafing could cause an electrical short and/or fire. | |||||||||||||||
Corrective Summary | Dealers will inspect the vehicles to determine if any chafing has occurred between positive and negative cables. if there is no evidence of chafing, then a saddle clamp will be installed to ensure cables will not rub. if there is evidence of chafing, the damaged cables will be replaced and the swivel saddle clamp installed. the recall began on august 22, 2005. owners may contact international at 1-800-448-7825. | |||||||||||||||
Notes | International recall no. 05514.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - HOSES, LINES/PIPING, AND FITTINGS | ||||||||||||||||
02V309000 | INTERNATIONAL TRUCK AND ENGINE | from 07/22/2002 to 08/16/2002 | V (Vehicle) | 252 | 12/17/2002 | MFR | NAVISTAR, INC | 11/15/2002 | 11/19/2002 | |||||||
Defect Summary | On certain heavy duty trucks, the bolts and locking nuts used to hold the brake spiders or brake anchor plates tight to the axles were under-torqued on the right side of the vehicles. if the clamp load on the bolts is not sufficient, the anchor plate may move when the brake is applied in either the forward or reverse direction. | |||||||||||||||
Consequence Summary | This movement could cause individual brake components to fail or eventually fatigue all the anchor plate mounting bolts. if all the bolts break due to failure, a complete loss of braking at a wheel end could occur. | |||||||||||||||
Corrective Summary | Dealers will inspect and tighten all suspect bolts. new wheel seals and new bolts will be installed where applicable. owner notification is expected to begin during december 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825. | |||||||||||||||
Notes | Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM | |||||
040801 | 01/01/2004 | 10005765 | Slight glow in the parking brake indicator lamp when the parking brake is not applied. *tt | 03/15/2004 |