International Harvester 4400 2000-2001
Model 4400 made by International Harvester got 50 service bulletins. Technical service bulletines regarding electrical system, engine and engine cooling and equipment.
Car model
| Name | Recalls | Bulletins | Investigations |
|---|---|---|---|
| International Harvester 4400 2000 | 3 | 1 | 1 |
| International Harvester 4400 2001 | 7 | 7 | 1 |
Model 9999
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| 0245 | 05/01/2002 | 635489 | Subject regarding fault code 2023 14 107 5, fuel level sensor. *tt | 10/23/2002 | |
| SFN0224 | 03/19/2002 | 632423 | Subject regarding j1939 data link changes. *tt | 07/16/2002 | |
| SFN0236 | 04/16/2002 | 631252 | Some rear axle combinations built on or before march 12, 2002 may have been assembled with incomplete wiring in circuit 49 between the dash/center chassis connector and the forward rear axle differential connector. *tt | 05/21/2002 | |
| 010808 | 11/01/2001 | 627551 | Subject regarding dual drive cab throttle position harness. *slc | 02/11/2002 | |
| AFCG01911R | 10/01/2001 | 627548 | Subject regarding vehicles built prior to july 19, 2001, reprogramming the cab electrical system controller to prevent the air conditioning compressor from latching out. *slc | 02/11/2002 | |
| 010807 | 08/01/2001 | 625989 | Subject regarding reading and clearing vehicle on-board diagnostic trouble codes. *slc | 12/12/2001 | |
| TSI010802 | 06/01/2001 | 623465 | Information regarding the audible warning alarm on 4300 and 4400 models. *yh | 10/29/2001 | |
| TSI010805 | 06/01/2001 | 623492 | Information regarding low coolant level sensor on 4300 and 4400 models. *yh | 10/29/2001 | |
| AFCG01911 | 08/01/2001 | 623274 | Subject regarding re-programming the cab electrical system controller to prevent the air conditioning compressor from latching out under certain conditions on models built before july 19, 2001. *sb | 10/26/2001 | |
| ELECTRICAL SYSTEM - IGNITION - MODULE | |||||
| 010807 | 08/01/2001 | 631682 | Subject regarding reading and clearing diagnostic trouble codes. *slc | 06/10/2002 | |
| SFN0202 | 01/09/2002 | 629126 | Subject regarding false diagnostic trouble codes 613-14-1-9 or 612-14-31-1. *tt | 04/01/2002 | |
| DCN020101R | 01/09/2002 | 629125 | Subject regarding sfn-02-02r (revised) false diagnostic trouble codes 613-14-1-9 or 612-14-31-1 erroneously be set indicating a burst pipe/loss of refrigerant and or indicating hvac high pressure switch out of range low. *tt | 04/01/2002 | |
| ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||||
| SFN0229 | 03/01/2002 | 631546 | Subject regarding electronic gauge cluster (egc) lockup while using intune. *tt | 05/31/2002 | |
| SSM120808 | 10/01/2001 | 629980 | Subject regarding apparent electronic gauge cluster (egc) malfunction. *tt | 04/10/2002 | |
| TSI010804 | 06/01/2001 | 623487 | Subject regarding instrument cluster digital lcd display on 4300 and 4400 models. *yh | 10/29/2001 | |
| ENGINE AND ENGINE COOLING | |||||
| TSI011211 | 06/01/2001 | 623562 | Information regarding refilling 4300, 4400 cooling systems. *yh | 10/29/2001 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| SSM120901 | 10/01/2001 | 629982 | Some vehicles may exhibit contact between the left radiator hose and the fan shroud or engine crossmember mounting bracket. *tt | 04/10/2002 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 01903 | 06/01/2001 | 621156 | Replacement rear engine mount snubber washer used on 4300 and 4400 models with vin numbers before 2h411832 built between october 24,2000 and march 21, 2001. *tt | 09/10/2001 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| SSM141202 | 04/01/2002 | 631515 | Information on diagnosing no start conditions on dt466 and dt530 engines for various . *tt | 05/30/2002 | |
| SSM141201 | 04/01/2002 | 631514 | Subject regarding hard start/no start complaints with diamond logic controller (dlc). *tt | 05/30/2002 | |
| AFCG01914 | 01/01/2002 | 629122 | Subject regarding insufficient torque on the engine oil pick up tube support mounting bolt and nut. *tt | 04/04/2002 | |
| EQUIPMENT - ELECTRICAL - RADIO/TAPE DECK/CD ETC. | |||||
| SSM140802 | 04/01/2002 | SSM120804 | 631513 | Information on potential problems with production radios. *tt | 05/30/2002 |
| TSI010803 | 06/01/2001 | 623481 | Subject regarding entertainment radio on 4300 and 4400 models does not respond when any of the function buttons are operated and the display stays illuminated. *yh | 10/29/2001 | |
| EXTERIOR LIGHTING - HEADLIGHTS | |||||
| TSI010902 | 06/01/2001 | 623511 | Information regarding headlight aiming on 4300 and 4400 models. *yh | 10/29/2001 | |
| AFCG01905 | 06/01/2001 | 622592 | On some models, when installing the bulb connector to theheadlamp assembly, the blades of the buld terminals may have poor electrical contact with the harness connector resulting head build up and distortion of the connector body. this | 10/19/2001 | |
| PARKING BRAKE - CONVENTIONAL - MECHANICAL | |||||
| 01909 | 07/01/2001 | 622594 | New design parking brake lever for models built between october 24, 2000 and june 11, 2001 with hydraulic brakes. *tt | 10/19/2001 | |
| POWER TRAIN | |||||
| 0242 | 05/01/2002 | 635505 | Subject regarding electrical system controlled (esc) vehicles equipped with allison 200 transmissions. *tt | 10/24/2002 | |
| POWER TRAIN - CLUTCH ASSEMBLY | |||||
| 03905 | 05/01/2003 | 10001756 | Clutch release roller yoke may cause wear when it contacts the clutch release housing resulting in linkage noise or a pulsating pedal feel when depressing the clutch pedal. *tt | 06/24/2003 | |
| POWER TRAIN - CLUTCH ASSEMBLY - PEDAL/LINKAGE | |||||
| 0334 | 06/04/2003 | 10003317 | Clutch pedal noise. *tt | 10/16/2003 | |
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - MASTER CYLINDER | |||||
| 02901 | 05/01/2002 | 635479 | Subject regarding reinforcement of brake master cylinder drop hoses in certain models built between august 14, 2000 and october 15, 2001. *tt | 10/23/2002 | |
| STEERING - COLUMN | |||||
| 030501 | 07/01/2003 | 10003462 | Lubrication to the intermediate steering column upper u-joint. *tt | 10/21/2003 | |
| STEERING - HYDRAULIC POWER ASSIST - PUMP | |||||
| AFCG01910 | 08/01/2001 | 623268 | Subject regarding plugged power steering reservoir dipstick vent hole in models built between april 11, 2001 and may 11, 2001 manufactured at the springfield assembly plant. *sb | 10/26/2001 | |
| STRUCTURE - BODY | |||||
| 01904 | 06/01/2001 | 621158 | Some 4300 and 4400 models built between october 24, 2000 and april 11, 2001 may develop grille stress cracks at both the upper and lower attachment points. this service procedure revises the grille attachment method and isolates the grill | 09/10/2001 | |
| 01907 | 06/01/2001 | 621162 | Driver and passenger side cab entry step mounting bolt replacement on 4300 and 4400 models built before april 11, 2001. *tt | 09/10/2001 | |
| 01908 | 06/01/2001 | 621164 | Subject regarding a revised step height on driver and passenger side for 4300 and 4400 models built before april 3, 2001 with 22.5 inch wheels and 65 gallon fuel tanks. *tt | 09/10/2001 | |
| STRUCTURE - BODY - DOOR | |||||
| TSI011606 | 08/01/2001 | 629993 | Subject regarding possibility of the rear edge of the door gap to the cab b-pillar not being uniform. *tt | 04/10/2002 | |
| 011606 | 08/01/2001 | 625996 | Subject regarding door alignment procedures. *slc | 12/12/2001 | |
| STRUCTURE - BODY - HOOD | |||||
| 010903 | 08/01/2001 | 625992 | Subject regarding hood adjustment procedures. *slc | 12/12/2001 | |
| STRUCTURE - FRAME AND MEMBERS | |||||
| AFCG01913 | 03/01/2002 | 632427 | Subject regarding fender extension modification for 4300 and 4400 models with 8000 lb steer axle, code 02adv, built between october 24, 2000 and october 17, 2001 to eliminate tire contact when maneuvering tight turns. *tt | 07/16/2002 | |
| SUSPENSION | |||||
| 0306 | 01/23/2003 | 10000898 | Iros air suspension leak down. *tt | 04/02/2003 | |
| 01906 | 06/01/2001 | 621160 | Rear suspension crossmember improvement for 4300 and 4400 models built between october 24, 2000 and april 16, 2001 with international ride optimized suspension (iros), excluding the lopro models. *tt | 09/10/2001 | |
| SUSPENSION - FRONT - SPRINGS - AIR SUSPENSION SYSTEM | |||||
| 031602 | 05/01/2003 | 10001755 | Cab air suspension ride height measurement and adjustment. *tt | 06/24/2003 | |
| UNKNOWN OR OTHER | |||||
| 020802 | 06/01/2002 | 635483 | Subject regarding remote keyless entry (rke) transmitter learning. *tt | 10/23/2002 | |
| VISIBILITY - DEFROSTER/DEFOGGER SYSTEM | |||||
| SSM121601 | 10/01/2001 | 629984 | Vehicles with optional heater shutoff valve, code 16554, may exhibit kinking of the heater hose and reduced heater performance. *tt | 04/10/2002 | |
| TSI011608 | 12/01/2001 | 629352 | Subject regarding heater shutoff valve, code 16554 for models exhibiting kinking of the heater hose and reduced heater performance. *tt | 04/01/2002 | |
| TSI011605 | 06/01/2001 | 623593 | Subject regarding 4300,4400 model hvac information. *yh | 10/29/2001 | |
| VISIBILITY - GLASS, SIDE/REAR | |||||
| 02904 | 11/01/2002 | 10000475 | European ece regulation 43 side window glass replacement. *tt | 02/28/2003 | |
| VISIBILITY - POWER WINDOW DEVICES AND CONTROLS | |||||
| 130804 | 01/01/2002 | 120806 | 631675 | Subject regarding inoperative power windows. *slc | 06/10/2002 |
| SSM120806 | 10/01/2001 | 629978 | Subject regarding power windows that do not operate. *tt | 04/10/2002 | |
| VISIBILITY - REARVIEW MIRRORS/DEVICES | |||||
| SFN0228 | 03/26/2002 | 632425 | Subject regarding mirror bracket adjustment. *tt | 07/16/2002 | |