Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| AFC-11929 | 02/01/2012 | 10043554 | Navistar: hvac front inside module drain repair. *kb | 04/10/2012 | |
| AFC-12902 | 01/01/2012 | 10043556 | Navistar: maxxforce 11, 13, and 15 recalibration to adress frequent warning lights. *kb | 04/10/2012 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| IK-1900144 | 02/01/2012 | 10043572 | Hvac system compressor and discharge hose failure diagnostics and repair procedures. navistar. *kb | 04/11/2012 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
| IK0900075 | 12/10/2012 | 10049579 | Iknow: stratis fan hub diagnostics. horton 12 thx vmaster ultra (stratis) viscous fan drive troubleshooting guide. *js | 01/16/2013 | |
| IK-0800251 | 10/06/2010 | 10036730 | Navistar: the fan is running all the time and vehicle is built with 0012tkt borg warner cool logic fan. open up cummins insite and program ecm fan type to electronic variable speed without speed sensor. *pe no model years listed. *p | 04/11/2011 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| AFC-11934 | 02/01/2012 | 10043719 | Navistar: procedure is provided regarding the installation of grease in egr valve that was produced without grease and may fail prematurely, by drilling small hole in egr housing. *pe | 04/24/2012 | |
| IK-1200706 | 01/12/2012 | 10043466 | International: rail tubes, which are excessively hard, may distort fuel rail after initial installation, making replacement fuel to rail tube not seat properly. *pe | 04/03/2012 | |
| MIN-11132 | 07/28/2011 | 10040744 | Ready | 09/12/2011 | |
| MIN-11132 | 07/28/2011 | 10040744 | Navistar: poor launch concerns and stored trouble codes. a software problem. *rm | 09/12/2011 | |
| MIN-11131 | 07/28/2011 | 10040743 | Navistar: there is updated ecm software. *rm | 09/12/2011 | |
| MIN-11131 | 07/28/2011 | 10040743 | Ready | 09/12/2011 | |
| IK-0800180 | 04/15/2009 | 10030247 | International truck: starter, alternator and engine block grounding. to simplify and clarify the operation of improving starter frame ground; engine block ground stud; and alternator ground stud. models lonestar, prostar, 8600 and 7600 only | 09/02/2009 | |
| ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
| IK-1200431 | 01/18/2010 | 10033554 | Navistar: cummins air temperature sensor located rear of vehicle, instead of front, on some models. this can be mistaken for a ground connector. do not bolt this sensor to ground. should remain strapped to harness. *pe | 08/23/2010 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
| AFC-11934 | 02/01/2012 | 10043719 | Navistar: procedure is provided regarding the installation of grease in egr valve that was produced without grease and may fail prematurely, by drilling small hole in egr housing. *pe | 04/24/2012 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
| 03/20/2009 | 1600 | 1 | 12/17/2008 |
| Tl*the contact owns a 2010 international lonestar truck. the contact stated that the windshield begins to ice up while driving 55 mph in 20 degree weather and snow. the manufacturer wanted to send him a heated windshield, but the contact does not want to feel like a lab rat for testing new things on the vehicle. he cannot afford to drive 75 miles to the dealer every time the failure occurs. the contact feels this is a safety issue because visibility is poor during inclement weather. the current mileage was 13,000 and failure mileage was 16,000. updated 04/17/09. *lj the drivers dor handle broke and the emissions control system was inoperative and the fuel lines were leaking after they were supposed to been fixed. updated 04/21/09.*b | |||