International Transtar 2010
Model Transtar made in 2010 by International got 2 recalls as well as 44 service bulletins. Technical service bulletines regarding electrical system and engine and engine cooling. There was one recall concerning electrical system .
Model 2010
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | ||||||||||||||||
12V196000 | NAVISTAR, INC | from 06/01/2009 to 04/04/2012 | V (Vehicle) | 19264 | MFR | NAVISTAR, INC | 05/02/2012 | 05/04/2012 | ||||||||
Defect Summary | Navistar is recalling certain model year 2010 through 2013 paystar, workstar, transtar, and prostar, and model year 2012 and 2013 lonestar commercial trucks manufactured from june 1, 2009, through april 4, 2012, equipped with a maxxforce 11 or 13 engine (feature code 12uxj or 12uxh) and with bosch alternator feature codes 08ggn, 08ggr, 08ghg, or 08ghh. the alternator cable may rub on the high pressure power steering hose, possibly chafing its insulation and causing an electrical short. | |||||||||||||||
Consequence Summary | An electrical short may cause a vehicle fire possibly resulting in property damage, personal injury, or death. | |||||||||||||||
Corrective Summary | Navistar will install a standoff bracket and improve harness routing to better route the alternator wires away from the power steering hose. navistar did not provide an expected start date for the recall, but an interim notice will be mailed to owners if parts will not be available before june 30, 2012. owners may contact navistar at 1-800-448-7825. | |||||||||||||||
Notes | Navistar's campaign number is 12515.this recall supersedes safety recall 11v-426, navistar campaign number 11516.all owners that had their vehicles repaired under the earlier recall campaign will need to have their vehicle remedied under this one.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
11V426000 | NAVISTAR, INC | from 06/01/2009 to 05/31/2011 | V (Vehicle) | 5663 | MFR | NAVISTAR, INC | 08/17/2011 | 08/18/2011 | ||||||||
Defect Summary | Navistar is recalling certain model year 2010-2012 paystar, workstar, transtar, and prostar commercial trucks manufactured from june 1, 2009, through may 31, 2011, equipped with a maxxforce 11 or 13 engine (feature code 12uxj or 12uxh) and with alternator feature code 08ggn, 08ggr, 08 ghg, or 08ghh. the alternator cable may rub on the high pressure power steering hose, possibly chafing its insulation and causing an electrical short. | |||||||||||||||
Consequence Summary | An electrical short may cause a vehicle fire possibly resulting in property damage, personal injury, or death. | |||||||||||||||
Corrective Summary | Navistar will install a bracket to route the wires away from the power steering hose. navistar did not provide an expected start date for the recall, but an interim notice will be mailed to owners if parts will not be available until after october 14, 2011. owners may contact navistar at 1-800-448-7825. | |||||||||||||||
Notes | Navistar's recall campaign number is 11516.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM | |||||
IK-0800298 | 08/23/2011 | 10041404 | Navistar: transtar 8600. harness of headlight may be installed in the wrong location and could lead to premature failure of either headlight interconnect. *rm | 09/30/2011 | |
IK-0800298 | 08/23/2011 | 10041404 | Ready | 09/30/2011 | |
SB-IK-0800293-2 | 08/04/2011 | 10041397 | Ready | 09/28/2011 | |
SB-IK-0800293-2 | 08/04/2011 | 10041397 | Navistar: troubleshooting for intermittent or no front blower operation. *rm | 09/28/2011 | |
AFC-11913R | 07/01/2011 | 10040737 | Ready | 09/12/2011 | |
AFC-11913R | 07/01/2011 | 10040737 | Navistar: there are air control valve trouble codes that can be caused by connector vibration, loose terminals, or terminal fretting. *rm | 09/12/2011 | |
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||||
IK-1200788 | 08/06/2012 | 10045802 | International: information provided regarding the re-routing of alternator wiring to prevent rub points. models paystar, transtar, prostar. model years 2009-2011. *pe | 09/17/2012 | |
ELECTRICAL SYSTEM - BATTERY - CABLES | |||||
IK-0800401 | 11/27/2012 | 10049379 | International: instruction information regarding installation and verification of battery cable routing changes, engine parameters, new power steering line, dipstick tube clamps and align cac pipes. model transtar. no model years listed. | 01/15/2013 | |
ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | |||||
IK-0800334 | 02/13/2012 | 10043568 | Incorrect 5amp fuse at location f11-d on wabco 6 sensor 6 modulater. *kb | 04/11/2012 | |
ELECTRICAL SYSTEM - SOFTWARE | |||||
MIN-11107 | 02/08/2011 | 10040309 | Navistar: there are updated calibrations and emissions labels for the engine. *rm | 08/22/2011 | |
MIN-11107 | 02/08/2011 | 10040309 | Ready | 08/22/2011 | |
ELECTRICAL SYSTEM - WIRING | |||||
SB-IK-0800293-2 | 08/04/2011 | 10041397 | Ready | 09/28/2011 | |
SB-IK-0800293-2 | 08/04/2011 | 10041397 | Navistar: troubleshooting for intermittent or no front blower operation. *rm | 09/28/2011 | |
ENGINE AND ENGINE COOLING | |||||
AFC-12902 | 01/01/2012 | 10043556 | Navistar: maxxforce 11, 13, and 15 recalibration to adress frequent warning lights. *kb | 04/10/2012 | |
AFC-11929 | 02/01/2012 | 10043554 | Navistar: hvac front inside module drain repair. *kb | 04/10/2012 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
IK0900075 | 12/10/2012 | 10049579 | Iknow: stratis fan hub diagnostics. horton 12 thx vmaster ultra (stratis) viscous fan drive troubleshooting guide. *js | 01/16/2013 | |
AFC-12942 | 12/01/2012 | 10049499 | Navistar: fan clutch harness routing repair. the fan clutch harness can rub on the fan wiring harness bracket and cause intermittent fault codes. some of the symptoms can include low power, erratic fan engagement, no fan engagement, or a v | 01/16/2013 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
AFC-11934 | 02/01/2012 | 10043719 | Navistar: procedure is provided regarding the installation of grease in egr valve that was produced without grease and may fail prematurely, by drilling small hole in egr housing. *pe | 04/24/2012 | |
IK-1200706 | 01/12/2012 | 10043466 | International: rail tubes, which are excessively hard, may distort fuel rail after initial installation, making replacement fuel to rail tube not seat properly. *pe | 04/03/2012 | |
MIN-11142 | 10/28/2011 | 10041988 | Navistar: engines on certain vehicles have an idler gear stud that was nitrate coated improperly resulting in premature wear out. *pe | 11/21/2011 | |
MIN-11131 | 07/28/2011 | 10040743 | Navistar: there is updated ecm software. *rm | 09/12/2011 | |
MIN-11132 | 07/28/2011 | 10040744 | Ready | 09/12/2011 | |
MIN-11132 | 07/28/2011 | 10040744 | Navistar: poor launch concerns and stored trouble codes. a software problem. *rm | 09/12/2011 | |
MIN-11131 | 07/28/2011 | 10040743 | Ready | 09/12/2011 | |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
MIN-11142 | 10/28/2011 | 10041988 | Navistar: engines on certain vehicles have an idler gear stud that was nitrate coated improperly resulting in premature wear out. *pe | 11/21/2011 | |
IK-0700041 | 10/24/2011 | 10041985 | Navistar truck: when bellows are bent out of form can cause damage to exhaust bellows. premature cracking can appear in bellows core due to stress on portion of pipes. *pe | 11/21/2011 | |
MIN-11102 | 01/12/2011 | 10040305 | Ready | 08/22/2011 | |
MIN-11102 | 01/12/2011 | 10040305 | Navistar: information on the repair of the intake throttle valve. *rm | 08/22/2011 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
IK-0700047 | 07/06/2012 | 10045160 | International: on the aftertreatment support hanger, the horizontal aftertreatment support rod bolt is loose or backed out, due to possible wear and needs to be replaced, if necessary. *pe | 08/21/2012 | |
IK-0700041 | 10/24/2011 | 10041985 | Navistar truck: when bellows are bent out of form can cause damage to exhaust bellows. premature cracking can appear in bellows core due to stress on portion of pipes. *pe | 11/21/2011 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
MIN-11107 | 02/08/2011 | 10040309 | Ready | 08/22/2011 | |
MIN-11107 | 02/08/2011 | 10040309 | Navistar: there are updated calibrations and emissions labels for the engine. *rm | 08/22/2011 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
AFC-11934 | 02/01/2012 | 10043719 | Navistar: procedure is provided regarding the installation of grease in egr valve that was produced without grease and may fail prematurely, by drilling small hole in egr housing. *pe | 04/24/2012 | |
EQUIPMENT - OTHER - LABELS | |||||
MIN-11107 | 02/08/2011 | 10040309 | Ready | 08/22/2011 | |
MIN-11107 | 02/08/2011 | 10040309 | Navistar: there are updated calibrations and emissions labels for the engine. *rm | 08/22/2011 | |
EXTERIOR LIGHTING - BRAKE LIGHTS | |||||
IK-0800348 | 02/27/2012 | 10043570 | Changing truck or trailer lighting, between combined or separate, stop and turn lights. navistar. *kb | 04/11/2012 | |
EXTERIOR LIGHTING - HEADLIGHTS | |||||
IK-0800298 | 08/23/2011 | 10041404 | Navistar: transtar 8600. harness of headlight may be installed in the wrong location and could lead to premature failure of either headlight interconnect. *rm | 09/30/2011 | |
IK-0800298 | 08/23/2011 | 10041404 | Ready | 09/30/2011 | |
EXTERIOR LIGHTING - TURN SIGNAL | |||||
IK-0800348 | 02/27/2012 | 10043570 | Changing truck or trailer lighting, between combined or separate, stop and turn lights. navistar. *kb | 04/11/2012 | |
(PWS) | |||||
IK-0800401 | 11/27/2012 | 10049379 | International: instruction information regarding installation and verification of battery cable routing changes, engine parameters, new power steering line, dipstick tube clamps and align cac pipes. model transtar. no model years listed. | 01/15/2013 | |
IK-0700047 | 07/06/2012 | 10045160 | International: on the aftertreatment support hanger, the horizontal aftertreatment support rod bolt is loose or backed out, due to possible wear and needs to be replaced, if necessary. *pe | 08/21/2012 | |
SEAT BELTS | |||||
TSI-12-16-01 | 05/01/2012 | 10044289 | Navistar: seat belt components currently installed in some buses and trucks will be replaced by new supplier to prevent mixing of any components from previous supplier. *pe | 06/05/2012 | |
STEERING - HYDRAULIC POWER ASSIST SYSTEM | |||||
IK-0800401 | 11/27/2012 | 10049379 | International: instruction information regarding installation and verification of battery cable routing changes, engine parameters, new power steering line, dipstick tube clamps and align cac pipes. model transtar. no model years listed. | 01/15/2013 | |
STEERING - WHEEL AND HANDLE BAR | |||||
IK-0500045 | 09/04/2012 | 10046599 | International (navistar): information is being provided regarding the inspection and removal of steering wheel and three welds between armature and steering wheel. models prostar, lonestar, transtar, workstar, durastar. no model years li | 10/17/2012 |