Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | ||||||||||||||||
| 97V034001 | ISUZU MOTORS LIMITED | from 07/01/1994 to 10/31/1994 | V (Vehicle) | 118485 | 05/24/1997 | MFR | ISUZU MANUFACTURING SERVICES OF AMERICA | 03/07/1997 | 03/20/1997 | |||||||
| Defect Summary | An integrated circuit within the voltage regulator can contain manufacturing errors. | |||||||||||||||
| Consequence Summary | This can cause excessive electrical charging of the vehicle's alternator, resulting in engine control malfunction, and/or eventual engine stall. | |||||||||||||||
| Corrective Summary | Dealers will replace the voltage regulator with a new regulator. | |||||||||||||||
| Notes | Owner notification:owner notification is expected to begin april 4, 1997. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact isuzu at 1-800-643-4070, ext. 241.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. | |||||||||||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 06/07/2010 | 78000 | ||
| Automatic transmission wire harness deteriorated do to excessive heat, routed to close to catalytic converter causing vehicle not to shift and disabling both transmission warning lights. vehicle only has 78k miles on it and wire covering/insulation should not be literally burned away with such low miles on the vehicle. | |||
| 10/14/2006 | 147000 | 1 | 12/19/2005 |
| About two days ago the power windows on my rodeo suddenly stopped working so we took the control out thinking that maybe the wires vibrated loose or something like that. when we removed the control there was nothing wrong with the control or the wiring that we could see by just looking at it so we opened the fuse box that is under the dash and found the fuse that controlled the windows. the power window fuse is a large box looking thing(not a regular fuse) with a red button in the middle that was popped out so we pushed the button back in and the windows began working again. after using them four or five time just to make sure that they worked we turned of the ignition and didn't think anything of it. today when we started the truck everything was fine then after letting it run for 5-10 minutes i went to get into it and the inside was full of smoke we immediately turn off the truck and then i noticed smoke coming from under the power window control on the door we removed the control and the wires were melted pretty bad. we then looked in the fuse box to see if the fuse had popped again and discovered that the fuse had started burning and was melted into the fuse box. we tried to remove the fuse and because it was so badly melted into the fuse box it crumbled when we tried to remove it. we haven't been able to take it to anyone to find out what happened because it is saturday and the dealer isn't open today. *nm | |||
| 02/01/2001 | 4 | 07/28/1994 | |
| Consumer has owned vehicle for about 6 years. problem has been fixed 3 times already, but is reoccurring. consumer contacted dealer. *ak rear doors do not open from inside or outside, consumer states there is a problem with water running down inside the door and corroding the locking controls, dealer instructed consumer to lubricate the doors in certain locations to keep the problem from reoccurring, however 7-8 months later problem happened again, dealer states this is not their problem. radio has had internal failure, speaker has shorted, and lighter deformed, possibly an electrical problem. *slc | |||
| ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||
| 04/01/1994 | |||
| There is a recall for this component (nhtsa campaign id number 97v034001) but we were told that it doesn't apply to our vehicle. we have spent approximately $400 to repair this problem thus far and we still have the same problem. *ak | |||
| 06/23/2000 | 09/01/1997 | ||
| Alternator regulator overcharged, causing major electrical failure in vehicle. damage was $2,000. isuzu indicated 1994 isuzu rodeos were recalled for this exact problem but our vin was not within recall. i maintain the problem was not confined to those | |||
| 10/01/1999 | 1 | 10/01/1994 | |
| I was not notified of alternator recall for vehicle. out of pocket expenses incurred. inoperable hatchback window poses serious potential hazard. *ak | |||
| 06/03/1995 | 3 | 03/01/1994 | |
| Oil leaks from the camshaft. | |||
| ELECTRICAL SYSTEM - BATTERY - CABLES | |||
| 05/15/2001 | 5 | ||
| Motor stays overheated.*ak the water pump, timing belt, and bypass hose have been replaced, however problem continues, vehicle also experiences hesitation. consumer complains of noisy brakes, rotors were glazed, rotors, pads, and seals were replaced, brakes continue to make noise. battery cable was corroded. vehicle lurches into reverse, fuel injector was leaking and caused long crank, all injectors were replaced. rear driver door would not open from outside due to latch sticking. *slc also the cigarette lighter was inoperative.*jb | |||
| ELECTRICAL SYSTEM - IGNITION | |||
| 11/01/1998 | |||
| Hard start problems | |||
| 02/01/1995 | 2 | 07/11/1994 | |
| Speedometer will not register , engine check light will intermittenley come on, vehicle will also stall, causing possible accident. *ak | |||
| The truck just died on the freeway. please describe. tt | |||
| 08/31/1995 | 1 | ||
| Intermittent stalling/rough start. | |||
| ELECTRICAL SYSTEM - IGNITION - ANTI-THEFT CONTROLLER | |||
| 08/14/1996 | |||
| Consumer is having problem getting recall work performed. alram system installed by dynamic electronics. dealership does not want to take responsibility of replacing for this system*ak | |||
| ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||
| 05/31/1994 | 1 | ||
| Short in dash wiring harness. *ak | |||