Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE | ||||||||||||||||
| 01I002000 | ISUZU MOTORS LIMITED | I | 06/22/2001 | MFR | ISUZU MANUFACTURING SERVICES OF AMERICA | 05/29/2001 | 06/05/2001 | |||||||||
| Defect Summary | This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: 1998-2000 rodeo (ue) and amigo (ua) models equipped with 2.2l 4-cylinder engines. the timing belt could break before the recommended scheduled maintenance. | |||||||||||||||
| Consequence Summary | This condition could cause the engine to crank but will not start or the engine could stall while driving and will not restart. | |||||||||||||||
| Corrective Summary | Dealer will inspect the vehicle to determine the condition of the timing belt and tensioner. the dealer will replace the timing belt. depending on the condition or model of the timing belt tensioner, the tensioner may also be replaced. isuzu has decided to conduct a service campaign to replace the timing belt. owner notification began june 22, 2001. owners can contact isuzu at 1-800-643-4070, ext. 426, concerning this program. | |||||||||||||||
| Notes | ||||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
| 0201S003 | 01/01/2002 | 10002798 | V-6 fan clutch replacement procedures. *tt | 09/24/2003 | |
| 9801L005 | 07/01/1998 | 602260 | Workshp manual revisions on the cooling fan assembly torque specifications. *yc | 10/20/1998 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 0301S002 | 05/01/2003 | 10001772 | Throttle body mounting bolt torque specifications. *tt | 06/25/2003 | |
| IB0101S002 | 06/01/2001 | 621368 | Subject regarding hec engine timing belt scrapping. *tt | 09/18/2001 | |
| IB0104S002 | 03/01/2001 | 621343 | Subject regarding p0337 crankshaft position sensor circuit low input correction. *tt | 09/17/2001 | |
| IB00S005 | 02/01/2000 | 614139 | This information bulletin outlines the proper steps to index the camshafts with the crankshaft for vehicles equipped with direct attack dohc 3.2l / 3.5l v6 engine. in the event that camshaft timing has been disrupted, due to timing belt b | 09/29/2000 | |
| SB9901S002 | 09/01/1999 | 610116 | Maintenance schedule information: timing belt replacement interval and dohc v6 valve adjustment schedule. *tt | 04/17/2000 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| IB0101S003 | 08/01/2001 | 625968 | Subject regarding the availability of hec long block/partial engine assemblies. *slc | 12/12/2001 | |
| SB0001S005 | 04/01/2000 | 612584 | Experiencing intermittent rough idle and / or the malfunction indicator lamp is on with diagnostic trouble codes p0171, p0174, or p1171. *tt | 06/09/2000 | |
| SB0001S003 | 03/01/2000 | 612596 | On some vehicles within vin y4300787 / 74400051, the engine mounts may not isolat engine vibration. *tt | 06/09/2000 | |
| 98040101L001 | 04/01/1998 | 602082 | Concerns with engine oil contamination. *yc | 09/14/1998 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
| 9801L003 | 07/01/1998 | 602251 | Workshop manual revisions on fan belt information. *yc | 10/20/1998 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
| SB0002S002 | 03/01/2000 | SB0003S002 | 612593 | Service information regarding all affected vehicles with the p1441 evaporative emission code that has been diagnosed with no fault found from the appropriate flow chart in the driveability and emissions manual. *tt | 06/09/2000 |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
| 9803L006 | 07/01/1998 | 602256 | Workshop manual corrections regarding driveability and emissions. *yc | 10/20/1998 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 12/10/2005 | 98651 | 1 | 03/02/2005 |
| Dt: the contact stated h vehicle burned to the ground after it stalled. the fire originated from under the hood. the contact had no problems with the vehicle prior to the incident. he took the vehicle to dealer for an oil change less than twelve hours prior to the fire. a police report was taken. the fire department did respond. the police report indicated the fire was of an electrical nature. *ak updated 02/24/06. *jb | |||
| 09/09/2004 | 73000 | 1 | |
| While driving 50 mph engine was producing a loud knocking noise. dealer stated that the bearing rod failed which caused excessive oil burning, and the engine needed to be replaced. *ak | |||
| 09/13/2004 | 131257 | ||
| The vehicle does not start, the check engine light and abs light comes on intermittently. after replacing the battery, the consumer was informed that the wiring harness cable is defective. recall found by the consumer and the manufacture states the repair has been made. | |||
| 04/21/2003 | |||
| The consumer received a recall notice on march 2003 but the part was sill not available for repair. please identify the part. *nlm | |||
| 01/13/2003 | 69500 | 1 | 10/25/1997 |
| Engine seizure, spun bearings due to no oil. further investigation found that isuzu suggests changing oil at 7500 mile intervals, but also considers 1qt oil usage per 1000 miles is acceptable usage for the 3.2l v6 205hp engine. truck holds 6 quarts of oil, and i had oil changed by reputable oil change places every 5000 miles. reports of 1qt oil usage per 800 miles fairly common on internet auto bulletin boards. do the math. | |||
| 10/01/2000 | 1 | 11/05/1997 | |
| When consumer was driving vehicle shook and rattled also, engine light came on and off. temperature gauge would register hot, and cold back in forth. dealership stated that warranty ran out, and dealership had acknowledgement of problem with recall. *ak the head gasket and timing chain failed. the consumer had asked the manufacturer to do the repair on warranty. *yh | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 08/01/2003 | 80000 | 1 | 02/09/2000 |
| Car loses coolant and overheats. engine has been pressure-checked and dye-checked. there appear to be no leaks. after further repairs to no avail, it is concluded that coolant is escaping via the exhaust, and the heads need to be replaced. vehicle has only 88,000 miles, which i am told is very low to have such a major problem.*ak | |||
| 06/02/2000 | 3 | 11/01/1997 | |
| The first incident i reported for the water pump failure, i kept hearing a rattle and air escaping so i took it to the dealership and they said the water pump had failed and leaked onto the timing belt causing it to have to be replaced. the next incident with the timing belt in june, 2000 i was driving home from work and had stopped at a stop light and the rodeo just stopped running and would not start up again. the dealership said it was the timing belt and they had just replaced it 23,000 miles ago. it was covered under my extended warranty and they had to basically rebuild the engine and replaced many items. the dealership was unable to determine the cause of the timing belt breaking. the third incident with the timing belt happened this moring on my way to work i was going approximately 65 mph and the car stopped running and i pulled to the side of the road and called for a tow truck. isuzu says it is the timing belt again and it is not covered by the extended warranty because of the mileage and i will probably end up paying out of my ouw pocket to have the repair completed this time.*ak | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 12/30/2005 | 92000 | 1 | 05/20/1999 |
| 1998 isuzu rodeo used 5 liters of oil in 4000 kms and seized up with out warning on 30 dec 05. the oil light and engine light did not come on isuzu dealers said it won't come on until vehicle is out of oil. so why put sensors on the truck. only 92000 kms on the rodeo talked to saturn, isuzu in fredricton and gm customer service was told to bad so sad check you oil more but if we do a recall on excessive oil consumption keep your bill and we may refund you. the truck did not smoke or leak oil. the oil was check 14 nov 05. it always used 1 litre every 5000 kms. i was told by dealer it would not get any worse. guess they were wrong it is going to cost me $3700 to fix. thanks isuzu and gm. *nm | |||
| 05/13/2003 | 63000 | 2 | 12/01/2003 |
| When the brakes were applied vehicle continued to roll. driver had to hit the side of the curb to stop. mechanic replaced the anti lock brake sensor. also, in june of 2003 engine was replaced because the timing belt came off and destroyed the engine. *ak *nm | |||
| 03/01/2004 | 1 | 10/23/2001 | |
| Own a 1998 rodeo with approx 98,000 miles. i know it's high mileage and older model, but have essentially rebuilt engine over past year. new altinater, starter, replace part of exhaust, all belts, idler pulley just to name a few. isuzu dealer wanted $900 to fix abs system, but two recalls seem to have alleviated problem. a/c is broken and they want $1000 to fix. seems a car w/no accident history should have enitire a/c defective/broken not just a compressor or fan or something.. moved on to different dealer in area and they seem to be better to deal w/, but this car has been meticulously maintained in the 2 yrs i've owned it yet i am constantly fixing the car. why is this car falling apart...maybe they should make them cheaper if they are going to be so disposable. *ak | |||
| 02/05/2003 | 1 | ||
| Every time i took my rodeo for an oil change, i was told there was no oil showing on the stick (even though it was usually changed every 3,000 miles). two weeks ago the engine started making noise and i took it to the dealership and was told i needed a new engine!! ($9,000) i think these motors are defective. the manager at my dealership called the factory (to see if they might assume some responsibility-i provided all of my oil change receipts) only to be told that the information i received after each oil change should have been enough to send me to a repair facility??!! they didn't feel that they should be held accountable.*jb | |||
| 02/24/2003 | 1 | 12/29/1997 | |
| The vehicle was leaking anti-freeze. service center (non-dealer) reports after analysis that anti-freeze is leaking from spark plugs as a result of a cracked engine head. parts for repair on back order, perhaps indicating a wide-spread problem.*jb | |||
| 02/24/2003 | 1 | ||
| The vehicle burned oil fast.*jb | |||
| 02/07/2003 | 11/01/1998 | ||
| Engine blew after less than 60k miles in 1998 isuzu rodeo. repairman tells me it is a known issue with the engines burning 2 quarts of oil every 1500 miles. | |||
| 05/11/2001 | 1 | ||
| Prior to recall 01i002, timing belt broke causing vehicle to stall, vehicle would not restart, as a result of the damaged caused consumer had to have the engine rebuilt, consumer is requesting reimbursement for all services completed, time missed from work, transportation, and emotional stress. *et | |||
| 12/02/2000 | 1 | 02/01/1998 | |
| We have experienced several problems with this vehicle, the major problems have included the muffler system being replaced, front crank and rear main seals leaking and being replaced, transmission being toally replaced at 57k and now our timing belt has snapped causing $4,000 in damage to the motor. owner's manual states that timing belt does not need to be checked until 75k the vehicle only has 67k. we lost the transmission and the motor on i-20 in louisiana going at a rate of 70mph, both times being left stranded on the interstate early in the am. both incidents have put my family in danger and i honestly believe that if either had occurred later in the day it would have resulted in an accident.*ak | |||
| 11/26/2000 | 6 | 01/01/1999 | |
| Engine idle was resolved by dealer. problem valve cover leak. shifter on natl backorder. *ak | |||
| 06/02/2000 | 3 | 11/01/1997 | |
| The first incident i reported for the water pump failure, i kept hearing a rattle and air escaping so i took it to the dealership and they said the water pump had failed and leaked onto the timing belt causing it to have to be replaced. the next incident with the timing belt in june, 2000 i was driving home from work and had stopped at a stop light and the rodeo just stopped running and would not start up again. the dealership said it was the timing belt and they had just replaced it 23,000 miles ago. it was covered under my extended warranty and they had to basically rebuild the engine and replaced many items. the dealership was unable to determine the cause of the timing belt breaking. the third incident with the timing belt happened this moring on my way to work i was going approximately 65 mph and the car stopped running and i pulled to the side of the road and called for a tow truck. isuzu says it is the timing belt again and it is not covered by the extended warranty because of the mileage and i will probably end up paying out of my ouw pocket to have the repair completed this time.*ak | |||
| 09/29/2000 | 1 | 04/01/1999 | |
| My suv ran just fine , then all of a sudden it just stop running, it was taken to the dealer ship the following monday wherein it was checked out and they told me that all the 16 valves were bent, the timing belt still intact , the pistons were still good, but had to look @ the head to see they was more damage. they let me know that they was a defect from the factory, now i need a new engine $6620 for parts and labor. i did some research on last week and to my knowlegde there was a recall on last year wherein a part needed replacing or clipped for if it is not replaced , results would be engine failure. while driving along ,the engine would shut down and not start back up, not even jump start. now the point of the matter is i was not notified of the recall plus i purchaed the vehicle in may 1999 the dealer failed to correct the problem before i bought it, plus failed to notify me of the recall , to bring the rodeo in for repairs. over 55000 rodeos were recalled. i want justice. ican't afford to pay out $6620 for a defect caused from the factory. please help me!!! 55. *ak | |||
| 10/01/2000 | 1 | 11/05/1997 | |
| When consumer was driving vehicle shook and rattled also, engine light came on and off. temperature gauge would register hot, and cold back in forth. dealership stated that warranty ran out, and dealership had acknowledgement of problem with recall. *ak the head gasket and timing chain failed. the consumer had asked the manufacturer to do the repair on warranty. *yh | |||
| 08/19/1998 | 1 | ||
| Whenever vehicle slows down for a stop, it would stall out for no reason. after stalling out & waiting a while, vehicle can be restarted. had taken vehicle to dealer for repairs, but cause not found. *ak right rear brake leaking oil. *mjs | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 04/30/2003 | 64000 | 2 | 02/01/1999 |
| Piston rod failure. the first incident occurred in or about january, 2003. the engine on my 1998 isuzu rodeo began making a loud clanking noise and the check oil light came on. i added a quart and the noise subsided. i had the oil changed the next day. a few months later, the noise returned and i added two quarts of oil. the noise did not subside and i took the vehicle in for its regularly scheduled oil change the next day. the oil change mechanic told me that there were only two quarts of oil in the engine. i took the vehicle to another local mechanic to repair the problem and he told me the no. 1 piston rod had failed. when he called his parts distributor for a quote on a new or rebuilt engine, the distributor said, '98 rodeo engine? let me guess, it's the no.1 rod and stated that this was a very common problem. i had the car towed to the isuzu dealer where i had purchased the car and had almost all regular maintenance and repairs performed. the dealer was unable to get the isuzu district manager to offer any good faith assistance. the car has approximately 64,000 miles on it. i have generally changed the oil every 3,000 miles, although isuzu recommends changing it every 5,000 miles. i have full service records and almost all maintenance (except for some oil changes) was done at the dealer. *nlm | |||
| 08/05/2001 | 1 | 10/08/1998 | |
| Consumer states that the vehicle had an oil issue, the dealer stated that an oil change was needed, however consumer had just had an oil change 3 days prior to this. *slc | |||
| 03/01/2000 | 0 | ||
| When ever vehicle comes to a stop engine will die. consumer has contacted dealer, and they were not able to duplicate the problem. consumer was afraid of being rear ended.*ak | |||
| 07/06/2000 | 2 | 02/01/1999 | |
| After driving for over 200 miles vehicle began to stall out on exit ramps. isuzu has been contacted. *ak the vehicle stalled many times when shifting to lower gear to bring it to a stop after highway driving. dealer is unable to find the cause. *yh | |||
| 04/25/2000 | 30 | 04/01/1998 | |
| The engine of the vehicle has stalled several times in normal driving environments including highway and city street. these incidents that have happened while i am applying brake to slowdown the vehicle due to traffic conditions or changing course to another predetermine direction. occasionally, when i apply brake to slow down the vehicle due to traffic conditions, the tachometer indicates engine rotates abnormally. the engine's speed surges. at times when engine idles at extremely low rpm, it stalls. *ak | |||
| 04/17/2000 | 4 | ||
| While driving at 55 mph highway speed vehicle started jerking until it stopped by itself, and consumer was unable to accelerate. *ak | |||
| When driving consumer heard a noise coming from the engine compartment. engine check light never came on the dash when vehicle cut completly off. consumer contacted the dealer, dealer stated engine needed replacing. please provide any further details. *ak | |||
| 01/01/2000 | 2 | 08/01/1998 | |
| When stopped at a light or stop sign truck idled and it felt like it would die. check engine light came on. took to dealer first time they could not duplicate problem. the next week was on tollway stop and go traffic again it felt like the truck would die and again the check engine light came on. took to dealer again. thet ran the car for 2 hours straight and drove car for 8 miles. could not duplicate problem. the truck only had 10875 miles . since that time has not happened again .when i stop the truck at lights sometimes it seems like the engine rmps go up and down and truck wants to die but the engine light has not gone on. regarding the brakes one time when i first bought the car was driving 30 miles and hour to a stoplight. it felt like the brakes had no grip immediately. took foot of brake and reapplyed and the truck stopped. has not happened again. at the time i thought maybe this truck has a different feel than a car would have. this is my first suv. i have recently heard on the news about brake problems on this particular model. i drive children around in this car and have become very cautious at intersections. i feel there is a problem with this truck that can cause serious injury. i'm very concerned about my family's safety and about the people i could potentially hit if the brakes went out. i called the dealer to ask about information regarding this problem and was rudely told they had absolutely no idea what i was talking about. any information about either of these problems would be greatly appreciated. also i read there was a recall involving paint on the bumper being a problem. have heard nothing from the dealer regarding this. i am very dissapointed with this vechicle. i am 42 years of age and have never had a vechicle i was afraid to drive. *ak | |||
| 05/05/1998 | 5 | 02/01/1998 | |
| Invoices list parts replaced as: purge control solenoid valve, solenoid valve, purge canister, convertor purge solenoid, purge canister. reported to isuzu and dealer. neither think failure 5 times is a problem. want us to just 'wait and see if it happens again'. quote from isuzu when trying to resolve problem: the area/zone manager doesn't need to be involved right now. let's just see if it happens again. as long as the dealer is fixing it under warranty, it's not a problem. | |||
| 08/29/1999 | 12 | 04/01/1999 | |
| No summary | |||
| 12/01/1997 | 5 | 10/01/1997 | |
| Very dissatisfied with vehicle, feel extremely endangered in driving vehicle | |||
| 07/09/1999 | 3 | 03/01/1998 | |
| The vehicle was being operated at 65 mph under cruise control for a continuous period of three hours in broad daylight. a rainstorm was encountered and the vehicle's exterior lights and windshield wipers were engaged. after approximately three minutes of such operation, the engine and all electrical components suddenly ceased. the same situation occurred the following day (july 10, 1999). a similar complete shutdown occurred in december, 1998 and the vehicle was taken into the dealership for inspection. the vehicle was also inspected by the dealer on july 13, 1999. in each of these inspections, the dealer advised that the source of the problem could not be determined. the initial incident in december, 1998 occurred while driving at night during a severe snowstorm at 35 mph and resulted in being forced onto the shoulder of the road without any lights/power. the latest two incidents occurred in daylight but at high speed on an interstate highway. one of the two recent incidents was a very near miss as a 16 wheel tractor trailer was following about 200 feet behind when all power was unexpectedly lost. *ak | |||
| 01/07/1999 | 1 | 11/01/1998 | |
| 2 times vehicle left me & my 6 year old twins stranded on dark dangerous hwys. on 2nd engine- and now possibly 2nd transmission? 1-28-99 incident scary- smoke and burning smell. all of sudden-no warning. suv rolled to stop on pavement, unable to shift into any gear. had to allow grade of road to roll me backwards in n off the pavement and into dirt shoulder to safety. suv out of service to date-23 days. dealer does not know what is wrong-can't indicate problem. no one hurt, yet. | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||
| 1 | |||
| Consumer received nhtsa recall 01i002000 regarding timing belt failure. consumer contacted the dealer to schedule an appointment. dealer informed the consumer that the parts were not available. it has been over sixty days and dealer does not have the parts available. *ak | |||
| 04/12/2004 | 1 | ||
| The recall replacement part for the timing belt recall 01i002000 hasn't been available for over a month, and the dealership doesn't know when the part will be available.*ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
| 08/24/2002 | 1 | ||
| Abs light came on, driving 35 mph could not stop suddenly and slid into another car causing $2700 worth of damage to my car and insurance had lapsed had to pay out of pocket. fuel gauge always shows less than really is even when full. catalictic converter is always rattling. dt | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
| 09/19/2004 | 80000 | 20 | 11/18/1998 |
| Failure of abs brake system, even though dealer fixed the problem via recall; fuel leak at hose and fuel pump connection; failure of fuel sending unit and fuel gauge.*ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||
| 08/27/2004 | 2 | ||
| Engine light appeared on the dashboard and remained on. consumer was able to drive the vehicle to the dealer for inspection, and mechanic placed the vehicle on the diagnostic machine code 401 came on, indicating that egr valve insufficiently flowed to the engine. mechanic replaced the engine. then, consumer informed the mechanic that this problem occurred more than once, and had not been resolved. *ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
| 12/02/2000 | 1 | 02/01/1998 | |
| We have experienced several problems with this vehicle, the major problems have included the muffler system being replaced, front crank and rear main seals leaking and being replaced, transmission being toally replaced at 57k and now our timing belt has snapped causing $4,000 in damage to the motor. owner's manual states that timing belt does not need to be checked until 75k the vehicle only has 67k. we lost the transmission and the motor on i-20 in louisiana going at a rate of 70mph, both times being left stranded on the interstate early in the am. both incidents have put my family in danger and i honestly believe that if either had occurred later in the day it would have resulted in an accident.*ak | |||
| 11/18/1998 | 1 | 01/02/1998 | |
| Exhaust pipe and muffler replaced due to noise. | |||