Itasca Sunstar 2004

Model Sunstar made in 2004 by Itasca got 1 consumer complain, 1 investigation there are 2 recalls as well as 1 service bulletin. Consumer complaints with reference to electrical system. . Technical service bulletines regarding engine and engine cooling. The car had one investigation (engine and engine cooling). There was one recall concerning equipment .

Model 2004

Recalls


CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
EQUIPMENT - RECREATIONAL VEHICLE
04V358000WINNEBAGO INDUSTRIES, INC.from 08/02/2002 to 08/29/2003V (Vehicle)5645MFRWINNEBAGO INDUSTRIES, INC.07/19/200407/20/2004
Defect SummaryOn certain motor homes equipped with samsung microwave ovens, models mr1031wb, mr1032bb, mr1033sb, mr1351wb, and mr1352bb, the microwaves were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a jumper or jump wire. this may cause the oven to activate without pressing any key pads.
Consequence SummaryAn electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire.
Corrective SummarySamsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 1-800-932-3837 or winnebago at 1-641-585-3535.
NotesCustomers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
03V405000WINNEBAGO INDUSTRIES, INC.from 05/01/2000 to 10/31/2003V (Vehicle)15337ODIWINNEBAGO INDUSTRIES, INC.10/16/200310/22/2003
Defect SummaryOn certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a jumper or jump wire. this may cause the oven to activate without pressing any key pads.
Consequence SummaryAn electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire.
Corrective SummarySamsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or winnebago at 641-585-3535.
NotesCustomers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

Bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY
040204/15/200410007297Radiator fan damaged caused by improperly supporting the radiator assembly when repairs require the radiator to be pivoted forward. *tt06/09/2004

Investigations


NHTSA IDManufacturerDate openDate closeSubjectRecall campaign
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN
EA08002WINNEBAGO INDUSTRIES, INC.01/04/200803/14/2008ENGINE COOLING FAN BLADE FRACTURE
 The subject vehicles are built on a volkswagen eurovan chassis and are class c motor homes. on september 5, 2007, the office of defects investigation (odi) opened this investigation as rq 07-002 after receiving four consumer reports of fan blade failure on model year 2002 winnebago rialta and vista vehicles.as a result of additional information received from volkswagen in response to rq 07-002, the investigation was upgraded to engineering analysis (ea) 08-002.the scope of the ea investigation was also expanded to cover model years 2001 through 2004 rialta and vista, 2002 through 2004 sunstar, and 2001 through 2003 eurovan.all of these vehicles utilize the same engine cooling fan.however, the winnebago vehicles are larger and heavier than the eurovan.as a consequence, the cooling fan would operate more frequently in the winnebago vehicles compared to the eurovan for the same on-road operating conditions.analysis of the available data concerning the problem experience indicates that it predominately affects the my 2002 winnebago models.winnebago accounts for 79% of all the reports, but represents only 23% of the total subject vehicle population.the majority of the winnebago reports are for the model year 2002 (64%).the data show a declining report trend, particularly for the 2002 winnebago.reports on the 2002 winnebago reached a high of 11 reports in calendar year 2005, dropping to three reports in 2006,two reports in 2007, and one report in 2008.an existing safety related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.accordingly, this investigation is closed.the closing of this investigation does not constitute a finding by nhtsa that a safety-related defect does not exist.the agency will take further action if warranted by the circumstances.

Consumer Complaints


Fail datemilesoccurencesPurchase date
ELECTRICAL SYSTEM
08/06/20044000204/30/2004
 At freeway speed, while towing a honda behind the 2004 itasca 38 ft. motorhome, the engine, transmission, power steering power brakes and all electronics spontanwously failed. with significant effort, the vehicle was moved out of traffic and stopped. no injuries resulted, however under different conditions such as a curve or grade the results could have been fatal. no diagnosis has been made. the vehicle was towed for warranty repair previously suffered complete hydralic system failure.*ak

Car dealers selling


StateCityZipNamePhone
CASANTA FE SPRINGS90670MIKE THOMPSON RV562-921-0955