Jayco Greyhawk 2003
Model Greyhawk made in 2003 by Jayco got 6 recalls. There were some recalls concerningelectrical system, engine and engine cooling and equipment.
Model 2003
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM - WIRING | ||||||||||||||||
| 06V095000 | JAYCO, INC. | from 11/01/2002 to 06/30/2004 | V (Vehicle) | 1107 | MFR | JAYCO, INC. | 03/31/2006 | 03/31/2006 | ||||||||
| Defect Summary | Certain motor homes built on ford chassis may experience stalling without warning while driving and may or may not restart. | |||||||||||||||
| Consequence Summary | Should the engine stall, a vehicle crash could occur. | |||||||||||||||
| Corrective Summary | Ford motor company is conducting the owner notification and remedy for this campaign. dealers will upgrade the fuel injection control module (ficm) wire harness or replaced, and/or have a new injection control pressure (icp)) sensor connector installed free of charge. owners may contact ford at 1-800-392-3673 or jayco at 1-800-283-8267. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||
| ENGINE AND ENGINE COOLING | ||||||||||||||||
| 06V082000 | JAYCO, INC. | from 11/01/2002 to 06/30/2004 | V (Vehicle) | 1107 | MFR | JAYCO, INC. | 03/28/2006 | 03/28/2006 | ||||||||
| Defect Summary | On certain motor homes built on ford e-series chassis, the air filter element material process resulted in an air filter paper element that can smolder or burn. this change in filter paper composition, combined with the configuration of the air induction system, may allow hot carbon particles to contact the air filter element during certain driving conditions that create hot particles. | |||||||||||||||
| Consequence Summary | These hot particles may ignite the air filter element with the potential for air induction system damage or underhood fire. | |||||||||||||||
| Corrective Summary | Ford motor company is conducting the owner notification and remedy for this campaign. dealers will inspect and replace the air filter element. owners should contact ford at 1-800-392-3673 or jayco at 1-800-283-8267. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||
| EQUIPMENT - RECREATIONAL VEHICLE | ||||||||||||||||
| 05V476000 | JAYCO, INC. | from 11/18/2002 to 09/22/2005 | V (Vehicle) | 237 | 10/31/2005 | MFR | JAYCO, INC. | 10/14/2005 | 10/14/2005 | |||||||
| Defect Summary | Certain motor homes built on chevrolet c3500 (express) cutaway chassis have a towing pigtail that will not show brake lights on the towed vehicle if hooked to the towing pigtail. | |||||||||||||||
| Consequence Summary | This condition could result in a crash, injury or death. | |||||||||||||||
| Corrective Summary | Dealers will rewire the towing pigtail wires to include the brake light circuit free of charge. the recall began on october 31, 2005. owners may contact jayco at 1-800-283-8267. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
| 03V383000 | JAYCO, INC. | from 07/06/2001 to 10/15/2003 | V (Vehicle) | 6442 | MFR | JAYCO, INC. | 10/09/2003 | 10/22/2003 | ||||||||
| Defect Summary | On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. an electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a jumper or jump wire. this may cause the oven to activate without pressing any key pads. | |||||||||||||||
| Consequence Summary | An electrical short can occur causing the oven to activate without pressing any key pads. this could result in excessive heat, smoke, or possibly a fire. | |||||||||||||||
| Corrective Summary | Samsung will notify customers and repair the panel free of charge. in the meantime, consumers should unplug their microwave, if possible. if the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or jayco at 1-574-825-0608. | |||||||||||||||
| Notes | Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
| FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | ||||||||||||||||
| 03V057000 | JAYCO, INC. | V (Vehicle) | 4 | 02/20/2003 | MFR | JAYCO, INC. | 02/21/2003 | 03/05/2003 | ||||||||
| Defect Summary | On certain recreational vehicles built on gm gmt610 rv chassis, due to a change in the fuel system of these chassis, increased pressure results in the fuel return line. the fuel return line is used to provide a fuel tap for generators and auxiliary engines. | |||||||||||||||
| Consequence Summary | Operating the generator while the vehicle engine is running will stall the generator due to overfueling. starting, priming or operating the generator with the vehicle engine running could result in fuel overflowing the carburetor, flooding the generator engine and spilling fuel into the generator compartment and on the ground. | |||||||||||||||
| Corrective Summary | Gm/onan advised jayco to stop delivery of these units until a solution to the problem is developed. the manufacturer has not yet provided an owner notification schedule for this campaign. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jayco at 1-574-825-0653. | |||||||||||||||
| Notes | Customers can also contact the national highway traffic safety administration | |||||||||||||||
| SEAT BELTS | ||||||||||||||||
| 06V210000 | JAYCO, INC. | from 06/04/2003 to 01/26/2006 | V (Vehicle) | 49 | MFR | JAYCO, INC. | 06/14/2006 | 06/14/2006 | ||||||||
| Defect Summary | On certain motor homes built on chevrolet chassis, the safety belt buckles may not latch or unlatch. | |||||||||||||||
| Consequence Summary | In the event of a crash, a seat occupant may not be properly restrained increasing the risk of personal injury or death. | |||||||||||||||
| Corrective Summary | General motors is conducting this recall (please see 05v558000) and will inspect the buckles and, if found to be inoperative, the entire buckle assembly would be replaced. for buckles found to be operative, dealers will replace only the upper buckle cover. owners may contact chevrolet at 1-800-630-2438 or jayco at 1-574-825-0608. | |||||||||||||||
| Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||